Troubleshooting guide

ManualsBrandsCentro ManualsGrillBronze 3000RT

WARNING

Failure to follow all of the Manufacturer’s instructions

could result in hazardous fires, explosions, property

damage, or serious personal injury or even death.

WARNING

Follow all leak check procedures carefully prior to

operation of barbecue, even if barbecue was stored

assembled. Do not try to light this barbecue without

reading the Lighting Instructions section of this manual.

THIS BARBECUE IS FOR

OUTDOOR USE ONLY

FOR YOUR SAFETY

1. Do not store or use gasoline or other flammable

vapours and liquids in the vicinity of this or

other appliance.

2. An LP Gas cylinder not connected for use shall not

be stored in the vicinity of this or other appliance.

FOR YOUR SAFETY

If You Smell Gas

1. Immediately turn off the flow of gas to the unit.

2. Extinguish any open flame.

3. Open the lid of the unit.

4. If the odour does not stop quickly, immediately call

your gas supplier or Fire Department for assistance.

3 YEAR LIMITED WARRANTY

85-1207-2 (PROPANE)

Read and save this manual for future reference.

If pre-assembled, leave this manual with

unit for consumer’s future reference.

For product inquiries, parts, and warranty

and troubleshooting support, please call

1-877-707-5463

Bronze 3000RT Barbecue

SAFE USE, CARE AND ASSEMBLY MANUAL

Summary of content (24 pages)

PAGE 1
Bronze 3000RT Barbecue S A F E U S E , C A R E A N D A S S E M B LY M A N U A L FOR YOUR SAFETY If You Smell Gas 1. Immediately turn off the flow of gas to the unit. 2. Extinguish any open flame. 3. Open the lid of the unit. 4. If the odour does not stop quickly, immediately call your gas supplier or Fire Department for assistance. FOR YOUR SAFETY 1. Do not store or use gasoline or other flammable vapours and liquids in the vicinity of this or other appliance. 2.
PAGE 2
TA B L E O F C O N T E N T S WARRANTY Warranty . . . . . . . . . . . . . . . . . ii 3 Year Limited Warranty Installation . . . . . . . . . . . . . . . 1 Additional Warnings . . . . . . . . 1 L.P. Gas Cylinder, . . . . . . . . . . . 1 Transportation and Storage of Cylinder, Filling the Cylinder Hose and Regulator . . . . . . . . . 3 Leak Testing, . . . . . . . . . . . . . . 3 Prior to Using the Grill Lighting the Grill . . . . . . . . . . . 5 Tips On Using . . . . . . . . . . . . .
PAGE 3
I N S TA L L AT I O N The installation of this appliance must be in accordance with all local codes, or in the absence of local codes: • Canadian installation must conform to the current national standards, which at this time are CAN / CGA-B149.1/2-Natural Gas / Propane installation code. ADDITIONAL Minimum clearance to adjacent combustible materials: WARNINGS • 76 cm (30˝ ) from furthest protruding edge on side of barbecue. • 76 cm (30˝ ) from furthest protruding edge on back of barbecue.
PAGE 4
The Cylinder must also be equipped with: • A shut-off valve with a correct cylinder valve outlet as specified in current standards. • Canada: CAN / CGA 1.6g-M97 Outdoor Gas Grilles. a) A safety relief valve with direct connection to the vapour space of the cylinder. b) A collar to protect the tank shut-off valve. c) A device for vapour withdrawal. d) A ring on the bottom to secure the tank to its support assembly. • Always turn off the cylinder valve completely when the barbecue is not in use.
PAGE 5
HOSE AND Propane Gas Models: Your barbecue is designed to operate on L.P. (Propane) gas at a R E G U L AT O R pressure of 2.74 Kpa (11˝ water column). A regulator preset to this pressure is supplied with the barbecue and must be used. This regulator is equipped with the Type-1 quick-closing connecting system, which incorporates these safety features: • Will not allow gas to flow until a positive seal has been made.
PAGE 6
The Following Must be Checked • The tank valve including the threads into the tank (drawing C). • All tank welds (drawing B). • Regulator fittings and tank connections (drawing C). • All hose connections (drawing D). • With a newly filled and tested propane tank attached to the barbecue, and all the barbecue controls turned OFF, slowly open Drawing B the cylinder valve one full turn.
PAGE 7
LIGHTING • Make sure you have followed all the checks, procedures and instructions indicated in the prior sections before attempting to light the grill. THE GRILL • Always raise the barbecue lid before lighting the burner. • Do not bend directly over the barbecue while lighting in case of back flash. • Making sure all the control knobs are off, slowly and carefully open the propane gas cylinder valve. Wait about five seconds before opening the burner valve and lighting the barbecue.
PAGE 8
WARNING If the heat output is too low, the flow control feature may have been activated by a gas leak. If so, turn off the burner valve and cylinder valve, and perform the “Leak Test”. If there aren’t any leaks, re-light the burner. Lighting the Second Burner • Turn the second control knob on the main control panel to the “HIGH” position. The unlit burner will automatically ignite.
PAGE 9
Shutting Down the Barbecue After Use • Turn off the gas cylinder valve. • Turn the burner control valve to the “OFF” position. This sequence is important as it prevents residual gas from being left in the system under pressure and will make the next use easier. Visually Check Burner Flame HI Take off the grates and heat shield. Light burners. Adjust the flame by turning the knobs from LOW “HIGH” to “LOW”. The flames will be smaller when the knobs are in the “LOW” position.
PAGE 10
TIPS ON USING Using for the First Time: Before cooking, turn on the grill and operate on “HIGH” for YOUR BARBECUE about 10 – 15 minutes with the lid open. Close the lid and continue to run the grill on “HIGH” for another few minutes. After this, your grill should be burned in and ready to use. Preparation: The barbecue should be preheated before adding any food. This is done by lighting the grill and running at “HIGH” for up to ten minutes with the lid down.
PAGE 11
CLEANING To get many years of service out of your barbecue, perform the following procedures at least AND MAINTENANCE once a year, especially at the start of a new season. Purchase a barbecue cover to protect your investment. Grill: Apply a light coating of cooking oil to the grating to prevent food from sticking. After each use, and after the barbecue has cooled down, scrub the grating with a non-abrasive brush.
PAGE 12
STORAGE When the outdoor cooking season is over and you’re going to store the unit for the winter, please do the following: • After removing and cleaning the burner and grill (lightly oil the grill after cleaning) wrap them in paper and store indoors. • The barbecue, after being covered, can be stored outdoors. • Do not store the L.P. cylinder in an enclosed area. • Remove igniter battery to avoid corrosion, if storing unit away in the winter, or a prolonged period.
PAGE 13
TROUBLESHOOTING GUIDE Problem Burner will not light (match or igniter) Possible Causes Corrective Action • Blocked Venturi tubes • Clean out blockage • Cylinder or gas supply valve turned off • Open cylinder or gas supply valve • Venturi tubes not properly sealed over orifices • Ensure proper Venturi assembly • Burner ports blocked • Clean / replace burner • Low or out of propane • Refill cylinder • Regulator safety devise must be re-set • Follow How to Reset the Gas Regulator Safe
PAGE 14
PA RT S L I S T I N G F O R 8 5 - 1 2 0 7 - 2 ( P R O PA N E ) 12 Item No. Quantity Specification Part No.
PAGE 15
1 2 3 4 7 5 6 9 8 11 10 14 12 26 13 25 27 42 15 29 28 30 16 17 31 43 18 32 33 19 34 20 44 21 35 36 40 22 23 41 45 37 38 24 39 13
PAGE 16
A S S E M B LY I N S T R U C T I O N S Tools Needed for Assembly • #2 Phillips® screwdriver • 1/4˝ slotted screwdriver • Adjustable wrench • Pliers • Rubber mallet Before assembling the barbecue, read these instructions carefully. Assemble the barbecue on a flat, clean surface. Notes: Do not fully tighten all the nuts during this initial stage. Caution: Sheet metal can cause injury. Wear gloves when installing the grill. Use care when assembling.
PAGE 17
1 16 I After removing the unit from carton please make sure that all hardware is present. Before starting to assemble the unit, read these G instructions carefully. Assemble the unit on a flat, clean surface. 23 A Assemble the upper panel (16) to the left & right legs using machine screws (Key I) as shown. 25 Assemble the front panel (23) to the left & right legs using machine screws (Key G) as shown. K Assemble the rear brace to the left & right legs using machine screws (Key K) as shown.
PAGE 18
4 21 22 Attach the control panel (20) to the front of the barbecue by using machine screws (Key I) as shown. Attach the control knobs (21) to the valves as shown. Attach the igniter (smaller) knob (22) to the I igniter as shown. Very Important! Burner tubes must engage valve 20 openings. Make sure the valves are aligned with burner tubes. 5 Connect the gas tube to the rotisserie burner as shown. Connect the igniter wires (Main and rotisserie burner) to electrode as shown.
PAGE 19
7 O 17 Assemble the heat shield (17) to the side brace (35) using machine screws (Key O) as shown. Assemble the tank clip (34) onto the side brace using carriage bolts E and wing nuts (Key M, E ) as shown. 34 M 35 8 Secure the heat shield assembly to the left leg using machine screws and flange nuts (Key K, A) as shown. K A 9 J Assemble the hanging pole & hooks to the side shelves using flange nuts (Key D) as shown.
PAGE 20
10 Install the side burner valve (18) to the side shelf and attach the control knob to the valve as shown. Connect the electrode wire to the igniter as shown. 18 26 27 11 Assemble the side burner (27) using wing nuts (Key P). Position the side burner cooking grate (26) over the burner. P 12 Important! Burner tube must engage valve opening, and the burner tube must be aligned with the valve as shown.
PAGE 21
13 9 Attach the warming rack (8) to the hood by inserting the supporting rods into the pointed holes as shown. Position the cooking grates (9) on the fire box as shown. 8 14 Using the tank clip, secure the propane tank to the bottom brace as shown. 15 Assembly of the barbecue is complete. Please read cautions and warnings before using your barbecue.
PAGE 22
20
PAGE 23
DISTRIBUTOR Trileaf Distribution Trifeuil Toronto, Canada M4S 2B8 21
PAGE 24