Supplementary Document

ManualsBrandsCertainTeed ManualsBuilding SuppliesFine Fissured Mineral Fiber Ceiling Tile HHF-157, Performance Series, Trim Edge, 24"L

MATERIAL SAFETY DATA SHEET

TRADE NAMES: (Wet-Felted – Safetone

Class A and Protectone

)

Alaska, Baroque

™

, Baroque Customline

Directional Fissured, Fine Fissured,

Fine Fissured Customline

Sand Micro

™

, School Board

Serene

™

, Vantage 10

™

CertainTeed Ceilings

P.O. Box 860

Valley Forge, PA 19482

Professional: 800-233-8990

Consumer: 800-782-8777

www.certainteed.com

I. PRODUCT IDENTIFICATION

Products: Wet-Felted (Safetone Class A, Protectone and Time-Rated) Acoustical Ceiling Products.

II. INGREDIENTS

Material CAS Number WT%*

(Approx.) OSHA PEL** ACGIH TLV*** Comments

01 Slag Wool NONE <50 5 10 See Below

02 Starch 9005-84-9 <10 5 10 mg/m

Resp

03 Clay 1332-58-7 <16 5 10 See Below

04 Cellulose 9004-34-6 <20 5 10 mg/m

Resp

05 Perlite 93763-70-3 <60 5 10 See Below

06 Crystalline Silica 14808-60-7 <5 0.1 0.1 mg/m

Resp

* % Approximate

**PEL - OSHA Permissible Exposure Limit, 1910.1000, Nuisance Dust (Respirable)

***TLV - Threshold Limit Value, adopted by American Conference of Governmental Industrial Hygienists, 1984-85 OSHA/PEL = 10 /

(2X% SI02) mg/m

Respirable

NA = Not Applicable, NE = Not Established

Carcinogenicity NTP Listed IARC Listed OSHA Regulated

Ingredient Number: 06

SARA Title III Section 313:

Ingredients Listed: All ingredients of this product are included in the U.S. Environmental Protection Agency’s Toxic Substances

Control Act (TSCA) Chemical Substance Inventory and the Canadian Domestic Substances List (DSL) or the

Canadian Non-Domestic Substances List (NDSL).

As a manufactured article this product is exempt from the requirements of Canada’s WHMIS.

III. PHYSICAL DATA

Boiling Point: N/A Sp. Gravity: SAFE 0.18-0.26

Vap Pressure: PCT. Volatiles: PROT. 0.28-0.40

Vap Density: N/A EVAP. Rate: N/A

Sol. in Water: N/A Appearance/Odor: Various Colors; slight earthy odor.

MSDS #: 00024-85L

Effective Date: 06/17/02

Revised Date: 04/30/10

Summary of content (4 pages)

PAGE 1
MATERIAL SAFETY DATA SHEET TRADE NAMES: (Wet-Felted – Safetone® Class A and Protectone®) Alaska, Baroque™, Baroque Customline®, Directional Fissured, Fine Fissured, Fine Fissured Customline®, Sand Micro™, School Board®, Serene™, Vantage 10™ MSDS #: 00024-85L Effective Date: 06/17/02 Revised Date: 04/30/10 CertainTeed Ceilings P.O. Box 860 Valley Forge, PA 19482 Professional: 800-233-8990 Consumer: 800-782-8777 www.certainteed.com I.
PAGE 2
IV. FIRE and EXPLOSION HAZARD DATA Flash Point (method): Flammable Limits: N/A LEL % N/A UEL % N/A Extinquishing Media: Water fog, foam or dry chemical. Sp. Fire Fighting Procedures: None Known Unusual Fire & Explosion Hazards: May smolder - extinguish completely. NFPA Ratings: 4 = Severe Hazard, 3 = Serious Hazard, 2 = Moderate Hazard, 1 = Slight Hazard, 0 = Minimal Hazard Flammability: 0 Health: 0 Reactivity: 0 Special Hazards: V.
PAGE 3
VII. SPILL OR LEAK PROCEDURES Steps to be taken in case material is released or spilled: Broken or damaged tiles should be picked up and placed in a container. Dust generated from making modifications of tile should be cleaned by wet wiping or filtered vacuuming. Do not dry sweep or use compressed air to remove dust. Disposal Method: In accordance with local, state and federal regulations. VIII.
PAGE 4
PROTECT YOUR SKIN: If ceiling tile dust gets on your skin do not rub or scratch that area. Remove the dust by washing your skin thoroughly, but gently, with warm water and mild soap. Using a skin cream or lotion after washing may also help. EEP YOUR WORK K AREA CLEAN: Avoid unnecessary handling of scrap ceiling tile material or debris pile up on the floor. Follow an organized housekeeping program at all times.