Product Manual

ManualsBrandsCET ManualsDiesel350 GPM (2-1/2") Electric Start Diesel Fire Fighting Pump w/ Yanmar Engine

*CET is a trademark of CET Fire Pumps Mfg Ltd.

75 Hector St., P.O. Box 90, Pierreville (Québec) Canada J0G 1J0 Telephone: 1-800-567-2719 Fax: 1-800-434-2613 www.fire-pump.com

ACCEPT ONLY THE BEST

A CENTURY OF ENGINEERING FOR THE BRAV E ST

PFP-9hp-DSL INSTRUCTIONS MANUAL

Congratulation, you have just purchased a C.E.T. portable pump. If you follow the procedures in this

operation manual, it will give you years of use without any problems.

ENGINE SPECIFICATIONS

• Yanmar 9hp at 3600 RPM, air cooled engine.

• Single cylinder diesel engine.

• 12V electric start with recoil start as backup.

• 1.45 gallons (5.5 l) integrated fuel tank.

PUMP UNIT SPECIFICATIONS

• Direct drive C.E.T. single stage centrifugal pump.

• Pump body made from resistant aluminum alloy.

• Bronze impeller.

• Mechanical shaft seal.

• Exhaust priming system, guaranteed up to 20’ (6 meter) lift.

• One 2 1/2” (65 mm) delivery outlet with 1/4-turn ball valve.

• One 3” (77 mm) suction inlet.

• Dimensions : Length : 20 1/2 ” (520 mm); Width : 25 7/8 ” (657 mm); Height : 24 5/8” (625 mm).

• Weight : 190 lbs (86 kg).

INCLUDED ACCESSORIES

• Swivel spotlight.

• 100 watts alternator.

• Pressure gauge.

• Vernier throttle.

• 12-V battery.

PERFORMANCE

380 GPM (1436 LPM) @ 10 PSI (0.7 bar)

275 GPM (1040 LPM) @ 25 PSI (1.7 bar)

170 GPM (643 LPM) @ 50 PSI (3.5 bar)

70 GPM (265 LPM) @ 75 PSI (5.2 bar)

5 GPM (19 LPM) @ 100 PSI (6.9 bar)

Your pump comes with a full year warranty on all mechanical components.

Summary of content (4 pages)

PAGE 1
PFP-9hp-DSL INSTRUCTIONS MANUAL Congratulation, you have just purchased a C.E.T. portable pump. If you follow the procedures in this operation manual, it will give you years of use without any problems. ENGINE SPECIFICATIONS • • • • Yanmar 9hp at 3600 RPM, air cooled engine. Single cylinder diesel engine. 12V electric start with recoil start as backup. 1.45 gallons (5.5 l) integrated fuel tank. PUMP UNIT SPECIFICATIONS • • • • • • • • • Direct drive C.E.T. single stage centrifugal pump.
PAGE 2
PFP-9hp-DSL INSTRUCTIONS MANUAL DOS AND DONTS Do… • • • • • Read your Yanmar owner’s manual Close your drain valve on the pump casing before starting the engine Seal up any air that could leak into the suction side Charge you battery at least once every three months Stop your pump before fuelling Do Not… • • • • • • • • Let your pump freeze up with water in it (drain the casing) Allow sand in the suction, it will damage the wear ring and the mechanical seal (use floating strainer if water supply doubtf
PAGE 3
PFP-9hp-DSL INSTRUCTIONS MANUAL IMPORTANT NOTICE - FRESH WATER FLUSH AFTER EVERY USE After Operating a CET Pump, it is critical to FRESH WATER FLUSH the pump at the end of use before restoring it as a good damage control practice. If the pump has been used to pump seawater, the seawater must be drained from the pump by opening the pump casing drain valve. The pump must be flushed with fresh water to prevent corrosion and salt crystals from forming on close tolerance pump internals.
PAGE 4
PFP-9hp-DSL WARRANTY CET warrants to the original purchaser that CET will, at its election, either replace or repair any part of the new equipment sold to the purchaser hereunder which has been given no abnormal use; and which has received proper maintenance; and which is determined by CET to be defective in material or workmanship; and which has, within two (2) years after delivery to the purchaser be returned at the purchaser's expense, with transportation charges prepaid, to CET factory OR which has, w