Owner's Manual

15
3F. BASKET INSTALLATION
/ĨLJŽƵƌďŝŬĞŝƐĞŝƚŚĞƌĂŚĞƌŝƚĂŐĞŽƌƚƌĞŬŬŝŶŐƐƚLJůĞďŝŬĞŝƚŵĂLJŚĂǀĞĐŽŵĞǁŝƚŚĂďĂƐŬĞƚdŚĞƌĞĂƌĞƚǁŽŵĂŝŶƚLJƉĞƐŽĨďĂƐŬĞƚƚƌĂĚŝƟŽŶĂůĂŶĚƋƵŝĐŬ
ƌĞůĞĂƐĞ
dƌĂĚŝƟŽŶĂůďĂƐŬĞƚ
/ĨLJŽƵŚĂǀĞĂƚƌĂĚŝƟŽŶĂůǁŝĐŬĞƌŽƌĨĂƵdžǁŝĐŬĞƌďĂƐŬĞƚĮƌƐƚLJŽƵǁŝůůŶĞĞĚƚŽĮƚƚŚĞďĂƐŬĞƚďƌĂĐŬĞƚŽŶƚŚĞǁŚĞĞůĂdžůĞdŚŝƐĞdžƉůĂŝŶĞĚŝŶƚŚĞǁŚĞĞů
ƐĞĐƟŽŶŽĨƚŚŝƐŵĂŶƵĂů/ĨLJŽƵƌǁŚĞĞůŝƐĂůƌĞĂĚLJŝŶƐƚĂůůĞĚLJŽƵŵĂLJŶĞĞĚƚŽůŽŽƐĞŶƚŚĞŶƵƚƐƚŽŐĞƚƚŚĞďƌĂĐŬĞƚŝŶƉůĂĐĞKŶĐĞLJŽƵŚĂǀĞĚŽŶĞƚŚŝƐ
ĨŽůůŽǁƚŚĞƐĞƐƚĞƉƐƚŽŝŶƐƚĂůůƚŚĞďĂƐŬĞƚ
DĂŬĞƐƵƌĞƚŚĞƐƚĞŵďĂƐŬĞƚďƌĂŬĞƚŝƐĨĂĐŝŶŐƚŚĞĨƌŽŶƚĂŶĚƚŚĂƚƚŚĞĨŽƌŬ
ďĂƐŬĞƚďƌĂĐŬĞƚŝƐĂďŽǀĞƚŚĞǁŚĞĞůŝŶƚŚĞŚŽƌŝnjŽŶƚĂůƉŽƐŝƟŽŶĂƐƐŚŽǁŶ
^ŝƚƚŚĞ ďĂƐŬĞƚŽŶ ƚŚĞĨŽƌŬďƌĂĐŬĞƚ ǁŝƚŚƚŚĞĮdžŝŶŐ ƉůĂƚĞ ƚŽǁĂƌĚƐ ƚŚĞ
ƐƚĞŵďƌĂĐŬĞƚŵĂŬŝŶŐƐƵƌĞƚŚĞĐĂďůĞƐĚŽŶƚŐĞƚŝŶƚŚĞǁĂLJ
>ŝŶĞƚŚĞďĂƐĞƉůĂƚĞŽŶƚŚĞďƌĂĐŬĞƚƵƉǁŝƚŚƚŚĞŚŽůĞƐŽŶƚŚĞďĂƐŬĞƚ
ďƌĂĐŬĞƚ ĂŶĚĚƌŽƉϮ ĮdžŝŶŐƐĐƌĞǁƐǁŝƚŚ ǁĂƐŚĞƌƐŝŶ ƚŚĞŚŽůĞƐ ĂƐ
ƐŚŽǁŶ
WůĂĐĞƚǁŽǁĂƐŚĞƌƐĂŶĚƐĐƌĞǁŽŶƚŚĞƚǁŽŶƵƚƐĨƌŽŵƵŶĚĞƌŶĞĂƚŚ
ĂƐƐŚŽǁŶƚƵƌŶŝŶŐĐůŽĐŬǁŝƐĞƵŶƟůĮŶŐĞƌƟŐŚƚ
i
ii
STEM BASKET
BRACKET
FORK BASKET
BRACKET
FIXING
SCREWS
TOP VIEW BOTTOM VIEW
21
BRAKE PAD ADJUSTMENT AND REMOVAL BOLT
This bolt secures the brake pad to the brake arm and
can be released to adjust the angle of the brake pad,
or to remove the brake pad completely to replace
when worn
BRAKE PADS
Usually made from
rubber, these rub against
the rim to slow the wheel
BRAKE ARMS
Move inwards to press the
brake pads against the
rim of the wheel
ANCHORING BOLT
This bolt holds the
brakes on to the
frame
CALIPER ALIGNMENT
SCREW
Should one brake pad be
closer to the rim than the
other, turn this to centre the
brake. Check anchoring bolt
is tight after adjusting.
BRAKE CABLE
Operates the brake arms
when the brake lever on
the handlebars is pulled
CABLE PINCH BOLT
This bolt secures the brake
cable to the brakes. You can
release this bolt to adjust the
distance from the brake arm
to the wheel
CABLE TENSION SCREW
Turn anti-clockwise to ne
tune the distance from the
brake arms to the wheel
when brake pads begin to
wear. Once adjusted, tighten
locking nut below.
CALIPER BRAKES
If you need to release your caliper brakes to install
or replace a wheel, slightly loosen the cable pinch
bolt. Turn it anti-clockwise with the spanner
provided as shown. This will open up the break
pads so the wheel ts through.
Once the wheel is in place and tight, squeeze the
brake arms together until there is a 1 - 1.5 mm gap
betwen the brake pads and the rim. Both sides
should be equal. Whilst holding in place you then
need to pull the brake cable tight, and tighten the
cable pinch bolt by turning clockwise using the
spanner provided as shown.
27
tĞƚŚĞŶŶĞĞĚƚŽĮƚƚŚĞĐĂďůĞƚŽƚŚĞďƌĞĂŬůĞǀĞƌŶƐƵƌĞƚŚĞƐůŽƚƐŽŶƚŚĞĐĂďůĞƚĞŶƐŝŽŶƐĐƌĞǁĂƌĞŝŶůŝŶĞǁŝƚŚƚŚĞƐůŽƚŽŶƚŚĞ
ďƌĂŬĞůĞǀĞƌŚŽƵƐŝŶŐ
^ƋƵĞĞnjĞƚŚĞďƌĂŬĞůĞǀĞƌĂŶĚŝŶƐĞƌƚƚŚĞďƌĂŬĞĐĂďůĞŝŶƚŽƚŚĞƐůŽƚĂƐƐŚŽǁŶďĞůŽǁ
tŝƚŚƚŚĞďƌĂŬĞůĞǀĞƌĐůŽƐĞĚLJŽƵĐĂŶŶŽǁƉƵůůƚŚĞďƌĂŬĞĐĂďůĞŽƵƚĞƌĐĂƐŝŶŐĂŶĚŝŶƐĞƌƚƚŚĞĐĂďůĞƚŚƌŽƵŐŚƚŚĞƐůŽƚŚƐŝŶƚŚĞďƌĂŬĞ
ůĞǀĞƌŚŽƵƐŝŶŐĂŶĚƚŚĞďƌĂŬĞĐĂďůĞƚĞŶƐŝŽŶƐĐƌĞǁ
KŶĐĞƚŚĞďƌĂŬĞĐĂďůĞŽƵƚĞƌŚŽƵƐŝŶŐŚĂƐƐůŽƩĞĚŝŶƚŽƚŚĞďƌĂŬĞĐĂďůĞĂĚũƵƐƟŶŐƐĐƌĞǁƚƵƌŶƚŚŝƐƐĐƌĞǁƐŽƚŚĂƚƚŚĞƐůŽƚƐĂƌĞŶŽ
ůŽŶŐĞƌĂůŝŐŶĞĚĂŶĚƚŚĞĐĂďůĞĐĂŶŶŽůŽŶŐĞƌĐŽŵĞŽƵƚ
iv
v
vi
vii
iv v vi vii
ĂďůĞƚĞŶƐŝŽŶ
screw
ůǁĂLJƐƚĞƐƚƚŚĞďƌĂŬĞƐďĞĨŽƌĞƌŝĚŝŶŐ^ŚŽƵůĚLJŽƵŶĞĞĚƚŽĂĚũƵƐƚƚŚĞŵǀŝƐŝƚƚŚĞďƌĂŬĞƐƐĞĐƟŽŶŽĨƚŚŝƐŵĂŶƵĂů
/&zKh,sEzWZK>D^KZZhE^hZKhdEzK&d,^^dW^KE^h>dYh>/&//z>D,E/
32
ůĞĂŶŝŶŐΘ>ƵďƌŝĐĂƟŽŶ
/ƚŝƐŝŵƉŽƌƚĂŶƚŝŶŽƌĚĞƌƚŽŬĞĞƉLJŽƵƌďŝŬĞŝŶŐŽŽĚĂŶĚƐĂĨĞǁŽƌŬŝŶŐŽƌĚĞƌƚŽŵĂŬĞƵƐƌĞŝƚŝƐĐůĞĂŶĂŶĚůƵďƌŝĐĂƚĞĚůǁĂLJƐǁĂƐŚŽīĂŶLJ
ĞdžĐĞƐƐĚŝƌƚĂŶĚĚƌLJǁĞůůďĞĨŽƌĞůƵďƌŝĐĂƟŶŐŵŽǀŝŶŐƉĂƌƚƐĞůŽǁŝƐĂŐƵŝĚĞƚŚĂƚŵĂLJŚĞůƉLJŽƵǁŝƚŚLJŽƵƌŵĂŝŶƚĞŶĂŶĐĞƐĐŚĞĚƵůĞďƵƚ
ƚŚŝƐǁŝůůĚĞƉĞŶĚŽŶŚŽǁĂŶĚǁŚĞƌĞLJŽƵƌŝĚĞĂŶĚĂůƐŽŽŶŚŽǁŽŌĞŶLJŽƵƌŝĚĞ
ŽŶŽƚŽǀĞƌůƵďƌŝĐĂƚĞĂŶĚ>tz^ǁŝƉĞŽīĂŶLJĞdžĐĞƐƐůƵďƌŝĐĂƟŽŶƐƉĞĐŝĂůůLJŝĨLJŽƵŐĞƚŝƚŽŶƚŚĞďƌĂŬĞƐďƌĂŬĞƉĂĚƐŽƌƌŝŵƐĂŶĚ
ƚŚŝƐŵĂLJĚĞĐƌĞĂƐĞďƌĂŬĞĨƵŶĐƟŽŶĂůŝƚLJĂŶĚŝŶĐƌĞĂƐĞƐƚŽƉƉŝŶŐĚŝƐƚĂŶĐĞ/ĨLJŽƵŚĂǀĞĂŶLJĚŽƵďƚƐĂďŽƵƚĂŶLJŽĨƚŚĞƐĞƉĂƌƚƐƉůĞĂƐĞ
ĐŽŶƐƵůƚĂƋƵĂůŝĮĞĚďŝĐLJĐůĞŵĞĐŚĂŶŝĐ
,ŽǁŽŌĞŶ
Every week
Every week
Every week
Every month
ǀĞƌLJƐŝdžŵŽŶƚŚƐ
ǀĞƌLJƐŝdžŵŽŶƚŚƐ
Every year
Every year
Every year
Every year
Every year
Every year
tŚĂƚǁŝƚŚ
>ŝŐŚƚŽŝů
Oil
Oil
>ŝƚŚŝƵŵďĂƐĞĚŐƌĞĂƐĞ
Oil
>ŝƚŚŝƵŵďĂƐĞĚŐƌĞĂƐĞ
>ŝƚŚŝƵŵďĂƐĞĚŐƌĞĂƐĞ
>ŝƚŚŝƵŵďĂƐĞĚŐƌĞĂƐĞ
>ŝƚŚŝƵŵďĂƐĞĚŐƌĞĂƐĞ
>ŝƚŚŝƵŵďĂƐĞĚŐƌĞĂƐĞ
>ŝƚŚŝƵŵďĂƐĞĚŐƌĞĂƐĞ
>ŝƚŚŝƵŵďĂƐĞĚŐƌĞĂƐĞ
,Žǁ
ƌƵƐŚŽƌƐƉƌĂLJ
KŝůĐĂŶ
KŝůĐĂŶ
Disassemble
KŝůĐĂŶ
Disassemble
Disassemble
Disassemble
Disassemble
Disassemble
Disassemble
Disassemble
tŚĂƚWĂƌƚ
Chain
Derailleurs
ƌĂŬĞƐΘ>ĞǀĞƌƐ
'ĞĂƌ>ĞǀĞƌƐ
&ƌĞĞǁŚĞĞů
ƌĂŬĞĂďůĞƐ
ŽƩŽŵďƌĂĐŬĞƚ
WĞĚĂůƐ
'ĞĂƌĐĂďůĞƐ
tŚĞĞůďĞĂƌŝŶŐƐ
,ĞĂĚƐĞƚ
^ĞĂƚƉŽƐƚ