User's Manual

CONDITION CAUSE SOLUTION

Asinglepumpwillnotrun Motoroverloadtripped....................... Resetoverloadincontrolcabinet

 Defectivemotor Contactyourserviceagency

Lowornowater Mainwatersupplyisturnedoff.......... Turnonhousewatersupply

 Drainvalvesareopen.......................... Closealldrainvalves

 Doorsarenotfullyclosed................... Closedoors

 Faultyllvalve................................... Contactyourserviceagency

 Stuckordefectiveoatswitch............ Freeoat/Contactserviceagency

 Cross-owpipingmisadjusted/

 clogged................................................ Adjustcross-owsetting/Cleanpiping

 Cloggedstraineratsupply

 connection........................................... Cleanstrainerscreen

 PRVmisadjustedordefective............. ReadjustpressuresettingorreplacePRV

Continuouswaterlling Stuckordefectiveoatswitch............ Freeoat/Contactserviceagency

 Fillvalvewillnotclose....................... Cleanvalve,repairorreplacevalve

 Drainvalvesopen................................ Closedrainvalves

Wash/Rinsetank Incomingwatertemp. Raiseincomingtemperatureislow 

temperaturelow atmachinelow..................................... 140°Fminimumfor40°Frisebooster

  110°Fminimumfor70°Frisebooster

  180°Fminimumwithoutbooster

 Defectivethermometer........................ Checkorreplace

 Defectivethermostat........................... Readjustsettingorreplace

 Defectiveelectricheaterelement........ Checkorreplace

 Lowsteampressureorvolume........... Checksteamsupplypressure

 Defectivesteamtrap............................ Checkorreplace

 Defectivesolenoidvalve..................... Checkorreplace

Prewashtanktemperature Incomingcoldwatertemperature Lowerincomingwatertemperature

istoohigh(OptionalCold toohigh................................................ tomaximumof65°F

WaterthermostatOnly) Defectivecoldwaterthermostat......... Checkorreplace

Insufcientpumpedspray Cloggedpumpintakescreen............... Clean

pressure Cloggedspraypipe.............................. Clean

 Scrapscreenfull.................................. Mustbekeptcleanandinplace

 Lowwaterlevelintank Checkdrainvalves

 Pumpmotorrotationincorrect............ ReversewiresL1andL2incontrolcabinet

 Defectivepumpseal............................ Contactserviceagency

Insufcientnalrinseor Faultypressurereducingvalve

nonalrinse (PRV).................................................. Cleanorreplace

 ImpropersettingonPRV.................... SetFlowpressureto20-22PSI

 Cloggedrinsenozzleorpipe.............. Clean

 Improperwaterlinesize...................... Installermustchangetopropersize

 Clogged“Y”strainer........................... Cleanorreplace

Troubleshooting