OWNER’S MANUAL & OPERATING INSTRUCTIONS 7800 Starting Watts / 6500 Rated Watts Electric start PORTABLE GENERATOR MODEL NUMBER 100107 SAVE THESE INSTRUCTIONS Important Safety Instructions are included in this manual. MADE IN CHINA REV 100107-20140923 12039 Smith Ave. Santa Fe Springs CA 90670 USA / 1-877-338-0999 www.championpowerequipment.
AN IMPORTANT MESSAGE ABOUT TEMPERATURE: Your Champion Power Equipment product is designed and rated for continuous operation at ambient temperatures up to 40°C (104°F). When your product is needed your product may be operated at temperatures ranging from -15°C (5°F) to 50°C (122°F) for short periods. If the product is exposed to temperatures outside this range during storage, it should be brought back within this range before operation.
100107 7800 Starting Watts / 6500 Rated Watts Electric Start PORTABLE GENERATOR Table of Contents Introduction. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 Introduction. . . . . . . . . . . . . . . . . . . . . . . . . . . 1 Portable Power Generator. . . . . . . . . . . . . . . . . . 1 Accessories . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 This Booklet. . . . . . . . . . . . . . . . . . . . . . . . . . . 1 Manual Conventions. . . . . . . . . . . . . . . . . . . . . . . .
ENGLISH 100107 Introduction Introduction Accessories Congratulations on your purchase of a Champion Power Equipment generator. CPE designs and builds generators to strict specifications. With proper use and maintenance, this generator will bring years of satisfying service. Champion Power Equipment manufactures and sells accessories designed to help you get the most from your purchase. To find out more about our covers and power cables, please visit our web site at: www.championpowerequipment.
100107 ENGLISH Manual Conventions This manual uses the following symbols to help differentiate between different kinds of information. The safety symbol is used with a key word to alert you to potential hazards in operating and owning power equipment. Follow all safety messages to avoid or reduce the risk of serious injury or death. DANGER DANGER indicates an imminently hazardous situation which, if not avoided, will result in death or serious injury.
ENGLISH 100107 Safety Rules WARNING Read this manual thoroughly before operating your generator. Failure to follow instructions could result in serious injury or death. WARNING The engine exhaust from this product contains chemicals known to the state of California to cause cancer, birth defects, or other reproductive harm. DANGER Generator exhaust contains carbon monoxide, a colorless, odorless, poison gas. Breathing carbon monoxide will cause nausea, dizziness, fainting or death.
100107 ENGLISH DANGER Safety Rules WARNING Fuel and fuel vapours are highly flammable and extremely explosive. Fire or explosion can cause severe burns or death. Unintentional startup can result in entanglement, traumatic amputation or laceration. Rapid retraction of the starter cord will pull hand and arm towards the engine faster than you can let go. Unintentional startup can result in entanglement, traumatic amputation or laceration. Broken bones, fractures, bruises or sprains could result.
ENGLISH 100107 Controls and Features Read this owner’s manual before operating your generator. Familiarize yourself with the location and function of the controls and features. Save this manual for future reference. Generator 1 2 3 9 4 7 8 5 6 (1) Fuel Tank – 6.1 gallon (23 L) capacity fuel tank. (2) Choke Lever – Used to start the engine. (3) Fuel Valve – Turn this valve to the “ON” position to supply fuel to the engine.
100107 ENGLISH Controls and Features Power Panel 6 7 1 2 3 4 5 (1) Ignition Switch – Press the switch to the “START” position to start the generator, or to the “ON” position to start the generator manually. Flip to the “OFF” position to turn off the generator. (4) 120V/20A Duplex (NEMA 5-20R) – May be used to supply electrical power for the operation of 120 Volt AC, 20 Amp, single phase 60 Hz electrical loads.
ENGLISH 100107 Controls and Features Parts Included Your 100107 Gasoline Powered Generator ships with the following parts: Wheel Kit –– –– –– –– –– –– –– –– 10 in. (25.4 cm) Wheel. . . . . . . . . . . . . . . . . . . . Bushing. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Flange Bolt (M10x120 for Wheel) . . . . . . . . . . . . . Flat Washer ø10. . . . . . . . . . . . . . . . . . . . . . . . . Lock Nut (M10) . . . . . . . . . . . . . . . . . . . . . . . . . Support Leg w/vibration mounts .
100107 ENGLISH Your generator requires some assembly. This unit ships from our factory without oil. It must be properly serviced with fuel and oil before operation. If you have any questions regarding the assembly of your generator, call our help line at 1-877-338-0999. Please have your serial number and model number available. Assembly Install the Support Leg 1. Attach the support leg to the generator frame with flange bolts (M8x16) and flange lock nuts (M8). 2.
ENGLISH 100107 Assembly Add Engine Oil CAUTION DO NOT attempt to crank or start the engine before it has been properly filled with the recommended type and amount of oil. Damage to the generator as a result of failure to follow these instructions will void your warranty. NOTE The generator rotor has a sealed, pre-lubricated ball bearing that requires no additional lubrication for the life of the bearing. NOTE The recommended oil type is 10W-30 automotive oil. 1.
100107 ENGLISH Add Fuel 1. Use clean, fresh, regular unleaded fuel with a minimum octane rating of 85 and an ethanol content of less than 10% by volume. 2. DO NOT mix oil with fuel. 3. Clean the area around the fuel cap. 4. Remove the fuel cap. 5. Slowly add fuel to the tank. DO NOT OVERFILL. Fuel can expand after filling. A minimum of 6.4 mm (¼ in.) of space left in the tank is required for fuel expansion, more than 6.4 mm (¼ in.) is recommended.
ENGLISH 100107 Operation Generator Location Grounding NEVER operate the generator inside any building, including garages, basements, crawlspaces and sheds, enclosure or compartment, including the generator compartment of a recreational vehicle. Please consult your local authority. In some areas, generators must be registered with the local utility. Generators used at construction sites may be subject to additional rules and regulations. Generators should be on a flat, level surface at all times.
100107 ENGLISH Operation Starting the Engine Connecting Electrical Loads 1. Make certain the generator is on a flat, level surface. 2. Disconnect all electrical loads from the generator. Never start or stop the generator with electrical devices plugged in or turned on. 3. Turn the Fuel Valve to the “ON” position. 4. Flip the ignition switch to the “ON” position. 5. Move the choke lever to the “CHOKE” position. 6. ELECTRIC START: Press and hold the ignition switch to the “START” position.
ENGLISH 100107 Operation Stopping the Engine Do Not Overload Generator 1. Turn off and unplug all electrical loads. Never start or stop the generator with electrical devices plugged in or turned on. 2. Let the generator run at no-load for several minutes to stabilize internal temperatures of the engine and generator. 3. Turn the Fuel Valve to the “OFF” position. 4. Let the engine run until fuel starvation has stopped the engine. This usually takes a few minutes. 5.
100107 ENGLISH The owner/operator is responsible for all periodic maintenance. WARNING Never operate a damaged or defective generator. WARNING Maintenance and Storage Oil Cont’d. NOTE Once oil has been added, a visual check should show oil about 1-2 threads from running out of the fill hole. If using the dipstick to check oil level, DO NOT screw in the dipstick while checking. Tampering with the factory set governor will void your warranty. WARNING Improper maintenance will void your warranty.
ENGLISH 100107 Maintenance and Storage Spark Arrester Maintenance Schedule 1. Allow the engine to cool completely before servicing the spark arrester. 2. Remove the screws (3) holding the cover plate which retains the end of the spark arrester to the muffler. 3. Remove the spark arrester screen. 4. Carefully remove the carbon deposits from the spark arrester screen with a wire brush. 5. Replace the spark arrester if it is damaged. 6.
100107 ENGLISH Storage The generator should be started at least once every 14 days and allowed to run for at least 20 minutes. For longer term storage, please follow these guidelines. Generator Storage 1. Add a properly formulated fuel stabilizer to the tank. 2. Be sure all appliances are disconnected from the generator. 3. Run the generator for a few minutes so the treated fuel cycles through the fuel system and carburetor. 4. Turn the fuel valve to the “Off” position. 5.
ENGLISH 100107 Specifications Engine Specifications Spark Plugs –– –– –– –– OEM spark plug: NHSP F6RTC Replacement spark plug: NGK BPR6ES or equivalent Make certain the spark plug gap is 0.7 - 0.8 mm or (0.028 - 0.031 in.). Model. . . . . . . . . . . . . . . . . . . . . YF190FD-2-110 Displacement. . . . . . . . . . . . . . . . . . . . . . . 439cc Type. . . . . . . . . . . . . . . . . . . . . . . . 4-Stroke OHV Start Type . . . . . . . . . . . . . . . . . . . .
B Y L G R W ST ON OFF BLACK YELLOW BLUE GREEN RED WHITE 2 4 5 6 Br BROWN B/W BLACK WHITE W/G WHITE GREEN G/Y GREEN YELLOW W/L WHITE BLUE In INDIGO 3 COMBINATION SWITCH 1 DCW EXW L B W R Y W L L R Y Y L L R B B SPARKING PLUG B R W B R B FUSE 10A W G/Y B Y B B/W W/G FUEL CUT SOLENOIL B/G B/G L W G/Y G/Y W L14-30R B R B B W B 5-20R EARTH TERMINAL ON OFF 5 4 OIL LEVEL SW Y ST 2 6 1 3 COMBINATION SW G/Y CONTROL BOX BLOCK G/Y CIRCUIT BREAKER 20A
70 19 REV 100107-20140923 85 86 50 69 71 72 80 81 82 83 84 68 48 65 66 67 56 73 19 74 78 79 77 75 76 87 75 88 62 107 105 106 60 89 90 91 98 99 100 58 17 57 56 55 59 61 54 53 57 94 92 93 101 108 63 64 95 109 52 96 110 15 48 16 17 18 19 20 3 97 103 102 49 111 51 50 1 2 47 13 14 4 104 46 5 45 8 9 10 11 9 22 30 42 41 21 113 36 12 43 7 112 44 6 40 39 37 25 26 27 24 23 38 37 30 35 36 34 28 29 30 31 32 33 Specifications ENGLISH 100107
100107 ENGLISH Parts List # Part Number Description Qty # Part Number Description 1 122.070100.07 Fuel Tank Cap 1 59 1.894.1.10 Circlip Ø10 Qty 2 2 122.070300.03 Fuel Filter 1 60 152.200703.04 Long Pin, Handle 2 3 24.070800.00 Reversal Valve 1 61 1.894.1.08 Circlip Ø8 2 4 2.06.006 Clamp (Ø7×Ø1) 1 62 152.200703.02 Short Pin, Handle 2 5 24.070030.00 Hole, Breather Tube 1 63 152.200701.02.2 Handle, U Shape 1 6 152.070014.
21 112 89 REV 100107-20140923 2 97 1 98 3 102 103 104 105 91 106 107 114 99 24 4 100 101 25 5 6 7 26 108 109 110 8 27 9 28 91 10 11 29 90 30 111 31 89 12 88 13 87 14 32 86 96 63 85 15 64 95 16 17 33 65 66 94 67 69 18 34 68 93 70 19 35 71 72 92 113 20 12 73 74 36 75 16 30 76 2 37 77 78 21 79 81 45 22 38 80 46 82 47 49 23 84 48 23 83 39 50 51 52 12 44 53 43 54 42 55 56 41 57 40 58 59 60 61 6
100107 ENGLISH Parts List # Part Number Description Qty # Part Number Description 1 21.061300.00 Recoil Handle 1 62 47.020100.00 Bolt, Cylinder Head Cover 1 2 1.5789.0608 Flange Bolt M6×8 4 63 2.08.039 Drain Bolt (M12×1.5×15) 2 3 46.061100.00.2 Recoil Starter Cover, Black 1 64 47.041000.01 Camshaft (EPA) 1 4 45.060005.00 Recoil Starter Spring 1 65 47.040004.00 Valve Lifter 2 5 45.061102.00 Recoil Starter Reel 1 66 47.040002.00 Intake Valve 1 6 2.10.
ENGLISH 100107 Troubleshooting Problem Cause Solution Generator will not start No fuel Add fuel Faulty spark plug Replace spark plug Unit loaded during start up Remove load from unit Low oil level Fill crankcase to the proper level Generator will not start; Generator starts but runs roughly Generator will not start electrically Place generator on a flat, level surface Choke in the wrong position Adjust choke.
100107 ENGLISH Warranty WARRANTY CHAMPION POWER EQUIPMENT 2 YEAR LIMITED WARRANTY Warranty Qualifications Champion Power Equipment (CPE) will register this warranty upon receipt of your Warranty Registration Card and a copy of your sales receipt from one of CPE’s retail locations as proof of purchase. Please submit your warranty registration and your proof of purchase within ten (10) days of the date of purchase.
Champion Power Equipment, Inc (CPE), Emission Control System Warranty Your Champion Power Equipment (CPE) engine complies with Environment Canada (EC) emission regulations. YOUR WARRANTY RIGHTS AND OBLIGATIONS: CPE is pleased to explain the Emission Control Systems Warranty on your 2014 small off-road engine. New engines must be designed, built and equipped, at the time of sale, to meet EC regulations for small non-road engines.
EMISSION CONTROL SYSTEM WARRANTY The following are specific provisions relative to your Emission Control System Warranty Coverage. Emission Control System Warranty (ECS Warranty): 1. APPLICABILITY: The ECS Warranty Period shall begin on the date the new engine or equipment is delivered to its original, end-use purchaser, and shall continue for 24 consecutive months thereafter. 2.
EMISSION-RELATED PARTS INCLUDE THE FOLLOWING: (using those portions of the list applicable to the engine) Systems covered by this warranty Fuel Metering System Air Induction System Ignition System Exhaust System Miscellaneous Parts Evaporative Emissions Parts Description Fuel regulator, Carburetor and internal parts Air cleaner, Intake manifold Spark plug and parts, Magneto ignition system Exhaust manifold, catalytic converter Tubing, Fittings, Seals, Gaskets, and Clamps associated with these listed system
