Owner's Manual another free manual from www.searstractormanuals.com ICRRFTSMRN I 8.0 HP 30 INCH TINE WIDTH SLEEVE HITCH TILLER ATTACHMENT Model No. 917.242484 CAUTION: • • • • • Read and follow all Safety Rules and Instructions before operating this equipment. [_ Sears, This from product previously has built a lowengines. emission engine Before you which start operates the engine, differently read and understandthis Owner's Manual. Roebuck and Co., Hoffman Visit our Craftsman PRINTED IN U.S.A.
SAFETY RULES Safe Operation Practices for Tiller Attachments. TRAINING • o. Read the operating and service instruction manual carefully. Be thoroughly familiar with the controls and the proper use of the equipment. Know how to stop the unit and disengage the controls quickly. Never allow children to operate the equipment. Never allow adults to operate the equipment without proper instruction. • • • • another free manual from www.searstractormanuals.
another free manual from www.searstractormanuals.com PRODUCT SPECIFICATIONS CUSTOMER • • RESPONSIBILITIES Read and observe the safety rules. Followa regular schedule in maintaining, caring for and using your tiller attachment. Followthe instructionsinthe Customer ResponsibiliUes and Storage sections of this Owner's Manual. GASOLINE CAPACITY: 1 Gallon Unleaded Regular OIL : (Capacity: 22 oz.) SAE 30W (Above 32°F) SAE 5w-30 (Below 32°F) • TRANSMISSION OIL : (Capacity: 40 oz.
ASSEMBLY • When R.H., (Right Hand) or L.H. (Left Hand) are used, it means from a position behind the steering wheel as If you were seated on the tractor seat and facing forward. NOTE: Remove mower deck from tractor before mounting tiller attachment. • . Remove tiller from carton. LEVEL • Adjust stabilizer bolts so that ends are about flush with rear of hitch bail (Fig. 2 - Inset). Leave nuts loose. • Lower hitch assembly and slide hitch yoke of ti!ler (Fig.
OPERATION IMPORTANT: READ THE =RULES FOR SAFE OPERATION" CAREFULLY BEFORE OPERATING YOUR TILLER ATTACHMENT. CHECK HOW TO USE YOUR TILLER STOPPING (See Fig. 3) another free manual from www.searstractormanuals.com TINES • Move tine clutch lever to "DISENGAGED" position. ENGINE • Move engine throttle lever to "STOP" position. • Never use choke to stop engine. TO USE CHOKE CONTROL (See Fig. TILLING • Fill fuel tank. Use fresh, clean, regular unleaded gasoline with a minimum of 87 octane.
OPERATION another free manual from www.searstractormanuals.com CAUTION: Fill to bottom of gas tank filler neck. Do not overfill Wipe off any spilled oil or fuel, Do not store, spill or use gasoline near an open flame. NOTE: If at a high altitude (Above 3000 feet) or in cold temperatures (below 32°F), the carburetor fuel mixture may need to be adjusted for best engine performance. See "TO ADJUST CARBURETOR" in the Service and Adjustments section of this manual.
CUSTOMER RESPONSIBILITIES MAINTENANCE SCHEDULE another free manual from www.searstractormanuals.com FILL IN DATES AS YOU COMPLETE REGULAR SERVICE Check Engine Oil Level SERVICE If DATES If Change Engine Oil _1,2 Oil Pivot Points V' Inspect Spark Arrester/Muffler Inspect Air Screen If I_ Clean or Replace Air Cleaner Cartridge I_ 2 Clean Engine Cylinder Fins I/ Replace Spark Plug I/ 1 - Change more often when operatingundera heavy load or in high ambienttemperatures.
CUSTOMER RESPONSIBILITIES TO CHANGE ENGINE OIL (See Figs. 6 and 7) another free manual from www.searstractormanuals.com Determine temperature range expected before oil change. All oil must meet API service classification SF or SG. • • • Be sure tiller engine is level. Oil will drain more freely when warm. Catch oil in a suitable container. • • • Remove drain plug. Tip tiller forward to drain oil. After oil has drained completely, replace oil drain plug and tighten securely. Remove oil filler plug.
CUSTOMER COOLING SYSTEM RESPONSIBILITIES (See Fig. 9) Yourengineisaircooled Forproperengineperformanceand long life keep your engine clean • Clean air screen frequently using a stiff bristled brush • Remove blower housing and clean as necessary • Keep cylinder fins free of dirt and chaff OPPOSITE SIDE SPARK PLUG WIRE AND COVER another free manual from www.searstractormanuals.com MUFFLER Do not operate tiller without muffler. Do not tamper with exhaust system.
SERVICE AND ADJUSTMENTS I_ CitAhUTIluOgN" Disconnectsparkplugwiresfromsparkplugand placewirewhereitcannotcomeintooontact I TILLER TO ADJUST GAUGE See 'q'O ADJUSTTILLING this manual. another free manual from www.searstractormanuals.com TO ADJUST BELT WHEELS DEPTH" in Operation section of TINE CLUTCH LEVER ENGINE - SHEAVE (SET SCREW END) (See Fig. 10) The clutch is a belt-tightener type. Belt should be just tight enough to prevent slipping. Over-tightening will reduce belt life.
STORAGE Immediately prepare your tiller for storage at the end of the season or if the unit will not be used for 30 days or more. A ENGINE OIL Drain oil (with engine warm) and replace with clean oil. (See "ENGINE" in the Customer Responsibilities section of this manual). CAUTION: Never store the tiller with gasoline in the tank inside a building where fumes may reach an open flame or spark. Allow the engine to cool before storing in any enclosure. CYLINDER(S) • • another free manual from www.
TROUBLESHOOTING CAUSE PROBLEM another free manual from www.searstractormanuals.com Will not start Hard tostsrt Loss of power overheats CORRECTION 1. Out of fuel. 2. 3. 4. 5. Engine not "CHOKED" Engine flooded. Dirty air cleaner. Water in fuel. 6. 7. Clogged fuel tank. Loose spark plug wire. 6. 8. 9. Bad spark plug or improper gap. Carburetor out of adjustment. 8. 9. 1. Throttle control not set properly. 2. 3. 4. 5. Dirty air cleaner. Bad spark plug or improper gap. Stale or dirty fuel.
another free manual from www.searstractormanuals.
REPAIR PARTS 8 HP TILLER A'I-I'ACHMENT - - MODEL NUMBER 917,242484 ENGINE AND TINES D another free manual from www.searstractormanuals.
REPAIR PARTS 8 HP TILLER ATTACHMENT another free manual from www.searstractormanuals.com ENGINE PART NO. i 2 3 4 5 6 7 132776 6924J 67-7A860 132044 6"77A855 6922R 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 917.242484 AND TINES KEY NO, 9 10 11 12 13 14 15 - - MODEL NUMBER DESCRIPTION ControlThrottle Bracket, Throttle Control Hitch Yoke Assembly Cover, Handle Hitch Channel Assembly Plate, Adapter Engine Tecumseh Model No.
REPAIR PARTS 8 HP TILLER A'I'rACHMENT another free manual from www.searstractormanuals.com TRANSMISSION AND GAUGE - - MODEL NUMBER 917.
REPAIR PARTS 8 HP TILLER A'rrACHMENT another free manual from www.searstractormanuals.com TRANSMISSION AND GAUGE - - MODEL NUMBER 917,242484 WHEELS KEY NO, PART NO.
REPAIR PARTS 8 HP TILLER A'I-rACHMENT another free manual from www.searstractormanuals.com ENGINE, TECUMSEH - - MODEL NUMBER - - MODEL NUMBER 917.
REPAIR PARTS 8 HP TILLER ATTACHMENT another free manual from www.searstractormanuals.com ENGINE, TECUMSEH KEY NO. PART NO. 1 2 4 4A 14 15 15A 15B 16 17 18 19 20 25 26 28 30 35 36 37 38 40 40 41 41 42 42 43 45 47 48 49 50 60 65 69 70 71 72 75 80 81 82 83 84 86 87 89 90 92 93 100 101 102 103 110 119 129 125 125 126 127 128 130 130A 130B 135 139 140 149 149A 150 151 169 170 171 172 35385 27652 30968 32214 28277 30699 30700 650494 37255A 29916 651028 34663 35319 36460 650561 30322 .
REPAIR PARTS 8 HP TILLER A'n'ACHMENT ENGINE, TECUMSEH - - MODEL NUMBER - - MODEL NUMBER HM80-155644U 1A_ KEY NO. PART NO. 640268 another free manual from www.searstractormanuals.com 917.242484 1 1A 2 4 5 6 7 10 11 12 13 14 15 16 17 18 20 20A 25 27 28 29 30 31 36 37 40 44 47 48 60 _37 .6_.37 25.
REPAIR PARTS 8 HP TILLER A'I-FACHMENT - - MODEL NUMBER ENGINE, TECUMSEH - - MODEL NUMBER HM80-155644U 111 another free manual from www.searstractormanuals.com 13 917.242484 12 KEY NO. PART NO. DESCRIP_ON 1 2 3 4 5 6 7 8 11 12 13 590746 590599A 590600 590679 590601 590678 590680 590412 590681 590747 590535 59O7O1 Recoil Starter Spring Pin (Incl.
another free manual from www.searstractormanuals.
another free manual from www.searstractormanuals.
Get it fixed, at your home or ours! another free manual from www.searstractormanuals.com For repairof majorbrand appliances in your own home... no matter who made it, no matter who sold it! 1-800-4-MY-HOME _ Anytime, dayornight (1-800-469-4663) (U.S.A. and Canada) WWW.Sears.com wlt_v.seal_.ca For repair of carry-in products like vacuums, lawn equipment, and electronics, call for the nearest Sears Parts and Repair Center. 1-800-488-1222 Any_me, dayor night (U.S.A. only) w_Rv.seal_.