Owner's Manual

Safety Rules
4 Rev 14551-20090309
WARNING
Batteries contain acid and produce explosive
gases.
Keep sparks, flames and cigarettes away from
batteries at all times. Wear safety glasses and
protect the eyes at all times. Do not lean over
the batteries during operation.
WARNING
When re-spooling the cable, ensure that the
cable spools in the under-wind position with the
cable entering the drum from the bottom, not the
top.
To re-spool correctly, and while wearing gloves,
keep a slight load on the cable while pushing the
remote button to draw in the cable. Walk toward
the winch not allowing the cable to slide through
your hands. Do not let your hands get within 12”
of the winch while re-spooling. Turn off the
winch and repeat the procedure until a few feet
of cable is left. Disconnect the remote control
and finish spooling by rotating the drum by hand
with the clutch disengaged. Keep hands clear of
the fairlead and drum while the winch is under
power.
WARNING
Do not use as a hoist. Do not use for overhead
lifting.
CAUTION
Use gloves to protect hands when handling the
cable. Never let the cable slide through your
hands.
CAUTION
Do not wrap the cable around any object and
hook it back onto itself.
CAUTION
Apply blocks to the wheels of the vehicle when
on an incline.
CAUTION
Duration of winching pulls should be kept as
short as possible.
If the motor becomes uncomfortably hot to the
touch, stop winching immediately and let it cool
down for a few minutes. Do not pull for more
than one minute at or near the rated load.
CAUTION
If the motor stalls, do not maintain power to the
winch.
Electric winches are designed and made for
intermittent use and should not be used in
constant duty applications.
CAUTION
Never release the free-spool clutch when there is
a load on the winch.
CAUTION
Use hook strap when handling the hook for
spooling or unspooling the wire rope.