GRILL NAME GRILL2GO X200 MODEL NUMBERS 12401734 13401856 Product Guide IMPORTANT: Fill out the product record information below. Serial Number See rating label on unit for serial number. Date Purchased FOR OUTDOOR USE ONLY WARNING: CAUTION: Read and follow all safety statements, assembly instructions, and use and care directions before attempting to assemble and cook. Failure to follow all manufacturer’s instructions could result in serious personal injury and/or property damage.
TABLE OF CONTENTS Product Record Information . . . . . . . . . . . . . . . . . 1 For Your Safety . . . . . . . . . . . . . . . . . . . . . . . . . . 2 Safety Symbols . . . . . . . . . . . . . . . . . . . . . . . . . . 2 Installation Safety Precautions. . . . . . . . . . . . . . . . 3 Use and Care . . . . . . . . . . . . . . . . . . . . . . . . . . 4-7 Food Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8 Limited Warranty . . . . . . . . . . . . . . . . . . . . . . . . . 9 Parts list . . .
INSTALLATION SAFETY PRECAUTIONS Installation Safety Precautions • Use grill, as purchased, only with LP (propane) gas and the regulator/valve assembly supplied. • This appliance is not for use in or on recreational vehicles and/or boats. • Grill installation must conform with local codes or, in the absence of local codes,with the National Fuel Gas Code, ANSI Z223.1/NFPA 54, Storage and Handling of Liquefied Petroleum Gases, ANSI/NFPA 58; or Natural Gas and Propane Installation Code, CSA B149.
USE AND CARE WARNING For Safe Use of Your Grill and to Avoid Serious Injury: • Do not let children operate or play near grill. • Keep grill area clear and free from materials that burn (i.e. gasoline, propane, or any other flammable liquid or gas). • Do not block holes in bottom or back of grill. • Check burner flames regularly. • Never use regulator from this grill with any other LP appliance. • When cooking, the appliance must be on a level surface in an area clear of combustible material.
Propane Cylinder Installation/Removal Propane Cylinder Installation: 1. Remove cap from end of Propane cylinder (sold separately). 2. Cap should be kept on cylinder when not in use to prevent dirt and debris from entering Regulator/Valve. 3. Check end of cylinder attachment for dirt and debris. Clean out if necessary. 4. Insert threaded end of Propane Cylinder into Regulator/Valve and hand-tighten turning cylinder clockwise as shown below.
DANGER • NEVER store a spare cylinder under or near the appliance or in an enclosed area. • Never fill a cylinder beyond 80% full. • An overfilled or improperly stored cyclinder is a hazard due to possible gas release from the safety relief valve. This could cause an intense fire with risk of property damage, serious injury or death. • If you see, smell or hear gas escaping, immediately get away from the LP cylinder/appliance and call your fire department.
CAUTION CAUTION • Putting out grease fires by closing the lid is not possible. Grills are well ventilated for safety reasons. • Do not use water on a grease fire. Personal injury may result. If a grease fire develops, turn regulator control knob and LP cylinder off. • Do not leave grill unattended while preheating or burning off food residue on HIGH. If grill has not been regularly cleaned, a grease fire can occur that may damage the product. NATURAL HAZARD • SPIDERS Burner Flame Check Light burner.
Storing Your Grill • Clean cooking surface. • When LP cylinder is connected to grill, store outdoors in wellventilated space and out of reach of children. • Cover grill if stored outdoors. • Store grill indoors ONLY if LP cylinder is turned off and disconnected, removed from grill and stored outdoors in wellventilated space and out of reach of children. • Leak test the grill after removing from storage and follow Cleaning Burner Assembly instructions before starting grill.
LIMITED WARRANTY This warranty only applies to units purchased from an authorized retailer. Manufacturer warrants to the original consumer-purchaser only that this product shall be free from defects in workmanship and materials after c rrect assembly and under normal and reasonable home use for the periods indicated below beginning on the date of purchase*.
PARTS LIST Key Qty Description A 1 FIREBOX B 1 LEFT, GREASE TRAY RAIL C 1 RIGHT, GREASE TRAY RAIL D 1 BURNER, W/ ELECTRODE E 1 VAPORIZER BAR F 1 HEAT SHIELD G 2 LATCH ASSEMBLY H 1 WIND BARRIER I 1 GREASE TRAY J 1 LEG, LEFT K 1 LEG, RIGHT L 1 COOKING GRATE M 1 LID N 1 HANDLE O 1 LOGO PLATE P 1 TEMPERATURE GAUGE Q 1 LID HINGE HARDWARE R 1 IGNITOR S 1 GROUND CONNECTOR T 1 REGULATOR NOT Pictured Page 10 … 1 GRATE CLEANING TOOL … 1 PRODUCT GU
PARTS DIAGRAM Q O M N P L G H T A K C B I J D S R E F Page 11
DANGER: If a gas leak cannot be stopped, or a fire occurs due to gas leakage, call the fire department. Emergencies Possible Cause Prevention/Solution Gas leaking from LP cylinder. •Mechanical failure due to rusting or mishandling. •Replace LP cylinder. Gas leaking between LP cylinder and regulator control valve connection. •Improper installation, connection not tight, failure of rubber seal. • Remove regulator control valve from cylinder and visually inspect for damage.
Troubleshooting (continued) Problem Possible Cause Prevention/Solution Burner(s) will not light using ignitor. PIEZO PUSH-BUTTON AND ROTARY: •Push-button sticks at bottom. •Replace ignitor. •Sparking between ignitor and electrode. Burner(s) will not match light. •Inspect wire insulation and proper connection. Replace ignitor wires / electrode assembly if insulation is broken. •See “GAS ISSUES:” on previous page. •Match will not reach using match holder. •Use long-stem match (fireplace match).
Page 14
Please register your product online at: Registre su producto en línea en: Veuillez enregistrer votre produit à l'adresse: www.charbroil.com/register (If you register online, you do not need to send in this registration card.) (Si registra en línea, no es necesario enviar esta tarjeta de registro.) (Si vous enregistrez votre produit en ligne, il n'est pas nécessaire d'envoyer la carte d'enregistrement.) PLEASE FILL OUT THIS CARD AND ATTACH A COPY OF YOUR SALES RECEIPT. RETURN IT WITHIN 10 DAYS OF PURCHASE.
THANK YOU FOR YOUR RECENT PURCHASE FROM CHECK OUT THESE GREAT FEATURES ON OUR WEBSITE • Valuable product information • Inspiring grilling accessories • Reliable customer support • Delicious recipes and tips from chefs • Exciting events and promotions • And much more! REGISTER YOUR PRODUCT TO RECEIVE A SPECIAL OFFER CHARBROIL.
