Owner`s manual

10 • 463232103
5. Hold regulator, insert nipple (B) into LP tank valve.
Hand tighten coupling nut,holding regulatorina
straightline(C)withLPtankvalve so as not to cross
thread the connection.
6. Turnthecouplingnutclockwisetotightentoafullsoli dstop.
TheregulatorwillsealonthebackcheckfeatureinLPtank
valve, resultinginsome resistance. An additional onehalf
to three quarters turn is required to complete
connection. Tighten by hand only  do not use tools.
NOTE: Ifyoucannotcompleteconnection,disconnectregulatorand
repeatsteps5and6.Ifyouarestillunabletocompletethe
connection, do not use this regulator!
Hold coupling nut
and regulator as
shown for proper
connection to LP
tank valve.
Nipple has to be
centered into the
LP tank valve
• Do not insert any foreign objects into the valve
outlet. You may damage the valve and cause a leak.
Leaking propane may result in explosion, fire, severe
personal injury, or death.
• Never attempt to attach this grill to the selfcontained
LP gas system of a camper trailer or motor home.
• Do not use grill until leak checked.
• If leak is detected at any time, STOP and call the Fire
Department.
• If you cannot stop a gas leak,immediately close LP
tank valve and call LP gas supplier or your fire
department!
WAR NING WAR NING
WAR NING WAR NING
WAR NING
B B
B B B
C C
C C
C
Use of this POL transport plug
(A) (plastic part with external
threads) will defeat safety
feature of valve.
A A
A A A
LPTankL eakTest
For your safety
• LeaktestmustberepeatedeachtimeLPtankisexchangedor
refilled.
• Donotsmokeduringleaktest.
• Donotuseanopenflametocheckforgasleaks.
• Grillmustbeleakcheckedoutdoorsinwellventilatedarea,away
fromignitionsourcessuchasgasfiredorelectricalappliances.
Duringleaktest,keepgrillawayfromopenflamesorsparks.
Useacleanpaintbrushand50/50soapandwater
solution. Use mild soap and water.
Do not use household cleaning agents.
Damagetogastraincomponentscanresult.
Brushsoapysolution
ontotheshadedareas.
ConnectingTheRegulatorToTheLPTank
OPD Hand
Wheel
Type 1 outlet with thread on outside
1. LPtankmustbeproperlysecured ontogrill.
2. Turnallcontrolknobsincludingsideburner(iffeatured)totheOFF
position.
3. TurnLPtankOFFbyturninghandwheel
clockwisetoa full stop.
4. Removetheprotectivecapfrom
LPtankvalve.Alwaysusecapand
strapsuppliedwithvalve.
Strap and Cap
Safety Relief Valve
If
"growing"
bubbles appear
do not use or move
the LP tank. Contact
an LP gas supplier or
your fire department!