Owner`s manual

463232103 • 15
Problem
Burner will not
light using
ignitor.
Burners will not
match light.
Sudden drop in
gas flow or low
flame.
Flames blow out.
Flareup.
Persistent grease
fire.
Flashback...
(fireinburner
tubes)
Possible Cause
 Wiresand/orelectrodecoveredwith
cookingresidue.
 Electrodecrackedorbroken"sparks
atcrack"
 Electrodetipnotinproperposition
 Wiresarelooseordisconnected.
 Wireisshorting(sparking)between
ignitorandelectrode.
 Deadbattery.
 Nogasflow.
 Obstructionofgasflow.
 Disengagementofburnertovalve.
 Outofgas.
 Excessflowvalvetripped.
 Highorgustingwinds.
 Greasebuildup.
 Excessivefatinmeat.
 Excessivecookingtemperature.
 Greasetrappedbyfoodbuildup
aroundburnersystem.
 Burnerand/orburnertubesare
blocked.
Prevention/Cure
 Cleanwiresand/orelectrodewithrubbingalcoholandcleanswab.
 Replaceelectrode(s).
 MainBurners:Tipofelectrodeshouldbepointingtowardtipofcollectorbox.
Thedistanceshouldbe1/8"to1/4",adjustifnecessary.
Sideburner:Tipofelectrodeshouldbepointingtowardgasportopeningon
burner.Thedistanceshouldbe1/8"to3/16",adjustifnecessary.
 Reconnectwiresorreplaceelectrode/wireassembly.
 Replaceignitorwire/electrodeassembly.
 ReplacewithanewAAbattery.
 Turngasonatsource.
 Clearburnertubes.
 Reengageburnerandvalve.
 CheckforgasinLPtank.
 Turnoffknobs,wait30secondsandlightgrill.Ifflamesarestilllow,turnoff
knobsandLPtankvalve.Disconnectregulator.Reconnectregulatorandleak
check.TurnonLPtankvalve,wait30secondsandthenlightgrill.
 Turnfrontofgrilltofacewindorincreaseflameheight.
 Cleangrill.
 Trimfatfrommeatbeforegrilling.
 Adjust(lower)temperatureaccordinglyoruseindirectcooking.
 TurnknobstoOFF.Turngasoffatgassource.Leavelidinposition andlet
fireburnout. Aftergrillcools,removeandcleanallparts.
 Cleanburnerand/orburnertubes.
Troubleshooting