OWNER’S MANUAL Charcoal Grill Model #1515 Patio Pro Keep your receipt with this manual for Warranty. OM1515 B ™ & © Char-Griller / A&J Mfg.
PARTS LIST AND TOOLS REQUIRED (Tools Not Included) and 7/16" nut driver Pliers 2 19 7 1 4 3 18 5 7 16 15 6 9 8 17 9 13 1 3/4” Hex Bolt Parts Bag Contains: 10 Damper Circle 12 11 14 “U” handle Bolt 1pc 2pcs Lock Bracket 1 pcs # QTY Part Name Part # 16pcs Push on Wheel 1 3 SIDE SHELF SLAT 10-0113 Caps Washer 2 1 HOOD HANDLE 55-0014 1/4” 3 1 GRILL BODY 20-0102 Lock Washer 4 1 WIRE HANDLE 55-0016 5 1 FIRE GRATE 20-0028 6 1 U HANDLE 55-0004 15 pcs 7 2 DAMPER CIRCLE 10-0036 5 pcs 2 pcs 8
ASSEMBLY INSTRUCTIONS Read all safety warnings and instructions carefully before assembling and operating your grill. IMPORTANT HINT: DO NOT TIGHTEN ANY NUTS AND BOLTS UNTIL GRILL IS FULLY ASSEMBLED. 1. Remove and unwrap the Patio pro and all of its parts from the packaging. Also remove the ash drawer from the Patio Pro. Place GRILL on its end with damper opening facing up. Spread if open in order to reach inside to perform the following. 2.
5. Attach the other end of the LEG BRACES to the corresponding legs using 1 3/4" Hex Bolts and Nuts but only finger tight. See below. Wheel Cotter Pin Hub Cap Washer Axle 6. Attach the WHEEL to the spindle coming out of the SHORT LEGS. Install one WASHER, COTTER PIN and HUB CAP onto the spindle after the WHEEL. Repeat this on the opposite SHORT LEG. 7. Stand the CART/LEG ASSEMBLY upright.
10. Attach LOCK BRACKET to the End of the GRILL between SIDE HANDLE and SIDE DRAWER with one 1/2” hex bolt, one flat washer and one lock washer and on nut. 11. Attach two (2) SIDE SHELF BRACKETS to the four (4) holes on left side of grill with 1/2” hex bolts and nuts. Next, attach three (3) WOOD SLATS to the brackets with six (6) 1” carriage bolts and nuts. Then, holding shelf straight, screw two(2) 1/2” screws through bracket and into outer wood slat from underneath. See Below 12.
GRILL PREPARATION & OPERATING INSTRUCTIONS PLEASE NOTE: NO RETURNS ON USED GRILLS Read all safety warnings and instructions carefully Before assembling and operating your grill. 1. Cure GRILL prior to your initial use to protect the interior and exterior finish and to prevent unnatural flavors to your first meals. (A) Lightly coat ALL INTERIOR SURFACES (including GRILLS, GRATES, AND INSIDE OF BARREL.) with vegetable oil (spray vegetable oil is easiest but do not use near hot coals or fire).
GRILLING RECIPES DIRECT METHOD STEAK (& ALL MEATS): Cook food directly above coals/heat. Generally speaking, to grill meats, raise fire grate to high position (hot) and sear for one minute on each side with the lid open to seal in flavor and juices. Then lower fire grate to medium position with lid closed and cook to desire doneness. Control heat with dual dampers and adjustable fire grate.
KABOBS: Alternating on skewers any combination of meat, onions, tomatoes, green peppers, mushrooms, zucchini, circular slice of corn-on-the-cob, or pineapple. Meat could consist of chunks of shrimp, scallops, lobster, chicken, sausage, pork, beef, etc. Marinate the meat in refrigerator for several hours. Grill each side approximately 7 minutes turning occasionally while basting with marinade. Leave a small amount of room between pieces in order to cook faster.
IMPORTANT SAFETY WARNINGS READ ALL SAFETY WARNINGS AND INSTRUCTIONS CAREFULLY BEFORE ASSEMBLING AND OPERATING YOUR GRILL Use caution when assembling and operating your grill to avoid scrapes or cuts from sharp edges. Do not use gasoline, kerosene or alcohol for lighting charcoal. Use of any of these or similar products could cause an explosion possibly leading to severe bodily injury. Keep children & pets away from grill. Supervision is necessary and do not leave grill unattended when in use.
IMPORTANT SAFETY WARNINGS READ ALL SAFETY WARNINGS AND INSTRUCTIONS CAREFULLY BEFORE ASSEMBLING AND OPERATING YOUR GRILL Do not exceed a temperature of 400 F. Do not allow charcoal and/ or wood to rest on the walls of grill. Doing so will greatly reduce the life of Always wear oven mitts to protect hands from burns. Avoid touching hot surfaces. When opening lid, make sure it is pushed all the way back so it rests against the lid support brackets.
ACCESSORIES Patio Pro Model# 1515 ORDER FORM Cover Custom Fit, Weather Resistant Protects grill finish Grill cover #6060……………………………..………………………..…………$14.99 TO ORDER Visit our online store at: www.chargriller.com or CALL: 912-638-4724 or FAX: 912-638-2580 or MAIL: P.O. Box 30864 Sea Island, GA 31561 Apron Machine Washable Two Front Pockets Adjustable Straps……………………$14.
P.O. Box 30864 Sea Island, GA 31561 912-638-4724 www.CharGriller.com Warranty Information — Charcoal Grill Char-Griller® will repair or replace any defective part of its grillers/ smokers for a period of up to one year from the date of purchase. CharGriller® will also repair or replace the body (bottom half) of its grillers/ smokers if the metal is rusted through or burned through for a period up to five years.
