Operating Guide

C-1

OPERATING INSTRUCTIONS

Setting Up

Set grill up on solid, flat surface with adequate wind shelter. Do not move grill while hot, and do not

leave unattended during operation.

This appliance is designed for use outdoors, away from any flammable materials. It is important that

there are no overhead obstructions and that there is a minimum distance of 12 feet (3,65 m) from the

side or rear of the appliance. It is important that the ventilation openings of the appliance are not

obstructed. The barbecue must be used on a level, stable surface. The appliance should be protected

from direct drafts and positioned or protected against direct penetration by any trickling water (e.g. rain).

** PLEASE NOTE: NO RETURNS ON USED GRILLS **

Seasoning and Preparing the Grill

IMPORTANT! BEFORE YOU USE YOUR GRILL FOR THE FIRST TIME

YOU MUST SEASON THE CAST IRON COOKING GRATE(S).

Cure grill prior to your initial use to protect the interior and exterior finish, cooking grates, and to prevent

unnatural flavors to your first meals.

1. Lightly coat ALL INTERIOR SURFACES (including grills, grates, and inside of barrel.) with vegetable

oil (spray vegetable oil is easiest but do not use near hot coals or re).

2. Build a medium sized re on the re grate. Always put charcoal on top of the re grate and not

directly into the bottom of the grill.

3. After coals ash over, spread out coals, replace cooking grates, close lid and heat at approximately

250 F for two hours.

4. Remove grates from the grill with oven mitts, allow to cool, then re-coat grates and return to grill at

approximately 200° F for two hours.

5. You can lightly coat the exterior of the grill body (while warm) with vegetable oil. This will extend the

life of the nish, much like waxing a car. Your grill is now ready for use.

NOTE: Grill will drip oil during this process and for several uses afterwards.

This is normal.

NEVER EXCEED 400°F BECAUSE THIS WILL DAMAGE THE FINISH AND CONTRIBUTE

TO RUST. PAINT IS NOT WARRANTED AND WILL REQUIRE TOUCH-UP

. THIS UNIT IS NOT

WARRANTED AGAINST RUST.