OWNER’S MANUAL 3-BURNER OUTDOOR STOVE Model #3338 Keep your receipt with this manual for Warranty. CUSTOMER SERVICE 1-912-638-4724 Service@CharGriller.com Danger • Never operate this appliance unattended. • Never operate this appliance within 10 ft (3.0 m) of any structure, combustible material or other gas cylinder. • Never operate this appliance within 25 ft (7.5 m) of any flammable liquid. • Heated liquids remain at scalding temperatures long after the cooking process.
This Page Intentionally Left Blank
TABLE OF CONTENTS Safety Warnings & Warranty............................... A-1 Assembly Instructions ..................................... B-1 Product Usage .................................................. C-1 Accessories ....................................................... D-1 Danger If you smell gas: 1. Shut off gas to the appliance. 2. Extinguish any open flame. 3. If odor continues, keep away from the appliance and immediately call your gas supplier or fire department. Warning 1.
IMPORTANT SAFETY WARNINGS An LP cylinder is required for operation. This outdoor stove is not intended for commercial use. SAVE THESE INSTRUCTIONS FOR FUTURE REFERENCE. IF YOU ARE ASSEMBLING THIS UNIT FOR SOMEONE ELSE, GIVE THIS MANUAL TO HIM OR HER TO SAVE FOR FUTURE REFERENCE. WARNING: Improper installation, adjustment, alteration, service, or maintenance could cause injury or property damage.
Read the following instructions carefully and be sure your outdoor stove is properly assembled, installed and maintained. Failure to follow these instructions may result in serious bodily injury and/or property damage. If you have any questions concerning assembly or operation, consult your dealer or LP gas company. • While in-use, always place the outdoor stove and LP cylinder on flat level ground. Outdoor stove can be used with 20lb LP cylinder.
• This outdoor stove is only intended for heating water (not oil or grease). 1. Never fill the LP cylinder beyond 80% full, as this may result in a fire and cause serious injury or death. 2. DO NOT store a spare LP cylinder under or near this outdoor stove, and: 3. If the instructions in 1 and 2 are not followed exactly, a fire causing death or serious injury may occur. CAUTION • This outdoor stove is for use with propane gas only (LP cylinder not included).
• DO NOT leave a lit gas outdoor stove unattended. Keep children and pets away from outdoor stove at all times. • DO NOT place outdoor stove on any type of tabletop surface. • DO NOT use outdoor stove in high winds. • Disconnect the LP cylinder by first turning off valve on top of the cylinder, turn off burner valves, then disconnect regulator from valve on propane tank by turning plastic connector counterclockwise.
*** STOP! CALL FIRST! *** Do NOT Return Product to Store. This outdoor stove has been made according to the highest of quality standards. If you have any questions not addressed in this manual, or, if you need a replacement part(s), please contact CharGriller® Customer Service via phone at 1-912-638-4724 (USA) or via email at Service@CharGriller.com. To ensure a quick and accurate resolution, please locate and record your outdoor stove’s serial number prior to reaching out.
WARRANTY INFORMATION A COPY OF THE DATED PROOF OF PURCHASE (RECEIPT) IS REQUIRED WHEN REGISTERING OR SUBMITTING A WARRANTY* CLAIM. PLEASE RETAIN A COPY OF THE RECEIPT FOR YOUR RECORDS. Char-Griller® will replace any defective part of its grillers/smokers, under warranty, as outlined below. PLEASE READ THIS INFORMATION IN DETAIL AND IF YOU HAVE ANY QUESTIONS CONTACT CUSTOMER SERVICE AT 1-912-638-4724 OR SERVICE@CHARGRILLER.COM.
ASSEMBLY INSTRUCTIONS 1 4 2 3 19 6 5 5 21 7 8 20 18 9 17 10 11 16 12 13 15 14 B-1
PARTS LIST Item QTY Part Name 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 1 1 1 1 2 3 3 1 1 1 1 2 4 1 1 3 3 2 3 1 WIND SCREEN STOVE GRATE STOVE GRATE HOLDING BRACKET STOVE GRATE HOOK SIDE HANDLE BURNER ASSEMBLY BURNER AIR DAMPER RIGHT SIDE SHELF STOVE BODY LOGO PLATE CONTROL PANEL RIGHT LEG ASSEMBLY LEG ADJUSTER SCREW BODY HEAT DEFLECTOR HOSE VALVE REGULATOR ASSEMBLY KNOB KNOB BEZEL LEFT LEG ASSEMBLY IGNITER IGNITION CHAIN 21 1 LEFT SIDE SHELF HARDWARE NEEDED Tools Needed: Phillips Head Scr
STEP 1 PRESS TO RELEASE 18 12 18 12 B-3
STEP 2 A x8 5 A A A A 5 A A A B-4 A
STEP 3 8 21 STEP 4A 1 B-5
STEP 4B 1 STEP 4C 1 1 B-6
STEP 5 16 16 16 STEP 6 To ensure sturdy assembly, tighten all BOLTS.
FOLDING YOUR OUTDOOR STOVE STEP 1A 1 STEP 1B 1 B-8
STEP 1C 1 STEP 2 LATCH SECURELY 8 21 B-9
STEP 3 PRESS TO RELEASE 12 18 FOLD ‘N GO B-10
OPERATING INSTRUCTIONS Setting Up This appliance is designed for use outdoors, away from any flammable materials. It is important that there are no overhead obstructions and that there is a minimum distance of 36 inches (90 cm) from the side or rear of the appliance. Maintain a minimum 10 ft. clearance to objects that can catch fire or sources of ignition, such as: pilot lights on water heaters, live electrical appliances, etc.
NEVER EXCEED 650°F BECAUSE THIS WILL DAMAGE THE FINISH AND CONTRIBUTE TO RUST. PAINT IS NOT WARRANTED AND WILL REQUIRE TOUCH-UP. THIS UNIT IS NOT WARRANTED AGAINST RUST. CAUTION: 1. All cleaning and maintenance should be done when the outdoor stove is cool and the fuel supply is DISCONNECTED. 2. Do NOT clean any outdoor stove part in a self-cleaning oven as the extreme heat will damage the finish. 3. Do NOT enlarge valve orifices or burner ports when cleaning the valve or the burners. NOTICES: 1.
GAS OPERATION Regulator and Hose Regulator and Hose are supplied with the outdoor stove. If a replacement is necessary, please visit CharGriller.com or call our Customer Service department at 1-912-638-4724. DO NOT use replacement parts that are not intended for this outdoor stove. It is recommended that the regulator is changed within 10 years of the date of manufacture. The use of the wrong regulator or hose is unsafe. Always check that you have the correct items before operating the outdoor stove.
** BEFORE USE CHECK FOR LEAKS ** Never check for leaks with a naked eye. Always use a soapy water solution. NOTE: Before starting the stove, check for leaks. To prevent a fire or an explosion hazard when testing for a leak, ensure the regulator valve is securely fastened to the burner and the LP cylinder. Always perform the “Leak Test” as described below before lighting the outdoor stove or each time the LP cylinder is connected for use.
Leveling the Outdoor Stove For safe operation, your outdoor stove must be level. If your outdoor surface is slightly out of level, use the adjustable feet at the bottom of each leg to correct. Turning the adjustable feet counterclockwise will raise the leg and clockwise will lower.
Lighting Instructions When lighting, keep your face and body as far away from burners as possible and never lean over outdoor stove surface. If outdoor stove does not light immediately or goes out during operation, turn all burner knobs to the OFF position and wait 5 minutes for gas to clear before attempting to relight. Failure to do so may result in an explosive flare-up, which can cause serious bodily injury or death.
Lighting Burner with a Match 1. Make sure all burner knobs are in OFF position. 2. Open valve on LP cylinder. 3. Locate ignition chain on the side of the outdoor stove and install match. Light match. 4. Push in and rotate knob counterclockwise to “HI” position. 5. Using ignition chain, place flame though outdoor stove grate near burner ports. Burner should light immediately. Burner Ports Ignition Chain 6. Adjust knobs to desired cooking settings. 7.
Observe Flame Height When Lit Flame should be blue and yellow in color and approximately 1/2 in. - 1 in. (1.2 cm - 2.54 cm) tall on HI setting. High Low Temperature Management Manage desired heat for cooking by adjusting burner knobs from LOW to HI. Weather conditions may cause heat fluctuations and require more heat in cold and/or windy conditions. Different types and amounts of food will also impact your temperature management and distribution.
CARE & MAINTENANCE When you are finished cooking, turn off all burners and allow to cool. When performing cleaning and maintenance of the burners, always ensure burner ports are properly aligned with valve openings after reinstalling on the outdoor stove. See figure for correct alignment. 0.5" Once cool, clean your outdoor stove with a rag, soap and water. To protect and prevent rust, lightly coat the cooking grates with flaxseed or other vegetable oil.
SCAN FAVORITE ACCESSORIES FOR MORE FOR THE FULL LINE OF ACCESSORIES VISIT CHARGRILLER.
This Page Intentionally Left Blank
This Page Intentionally Left Blank
P.O. Box 30864 Sea Island, GA 31561 1-912-638-4724 www.CharGriller.com Service@CharGriller.