SAFETY & INSTRUCTION MANUAL Honcho Pump Spring-Assisted .
IMPORTANT DO NOT MODIFY THIS FIREARM IN ANY WAY. DOING SO MAY CHANGE THIS FIREARM’S ATF CLASSIFICATION AND MAY RESULT IN VIOLATION OF NFA REGULATIONS. CHECK WITH YOUR LOCAL LICENSED RETAILER OR STATE POLICE FOR ANY RESTRICTIONS THAT MAY APPLY TO FIREARMS OF THIS TYPE.
TABLE OF CONTENTS Warnings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 Safety Rules . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-6 Identifying Marking . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
WARNINGS The manufacturer is not responsible for damage to objects caused by misuse of the firearm or for injuries to persons or animals, or in case of death, caused voluntarily or involuntarily by the firearm user. The manufacturer is not responsible for injuries caused by poor maintenance, misuse of the firearm, unauthorized or improper modifications.
SAFETY RULES 1. Read the instructions carefully before use. Reading the manual and careful examination of the firearm are fundamental to avoid any kind of problem. 2. Be aware that you are handling a firearm; therefore your knowledge and behavior may affect your life and those of the people close to you. 3. Firearms and ammunitions must be kept in separate places. 4. Always keep firearm and ammunitions out of reach of children. 5.
SAFETY RULES 20. Never rest your finger on the trigger until the very moment you wish to shoot. Always keep the safety on until you are ready to safely shoot at an intended target. Note: Safety devices on firearms are extras and are not a substitute for your proper and safe handling practices. 21. Always keep the firearm unloaded when transporting it from home to the shooting areas. Carefully check that cartridge chamber is empty. 22.
IDENTIFYING MARKINGS Every firearm we produce has a serial number that is marked on the receiver/frame . Close to the serial number you will also find the manufacturers information with the model name and caliber marked either on the frame or the barrel as required by law . These markings must not be removed from the firearm for any reason. DESCRIPTION & SPECS The model 410 Honcho is a spring assisted pump-action firearm with a capacity of 5+1 of 2-1/2” shells and 4+1 of 3” shells .
B. To engage the safety, push the button so that it protrudes from the right side of the gun and RED BAND MARKING CAN NOT BE SEEN. The safety should always be in the “on” or “safe” position until you intend to fire the gun. (Fig. 1) C. When you are ready to fire the gun, press the safety button 1 to the “off” position so that the safety protrudes from the left side of the gun and the RED BAND MARKING IS SHOWING.
UNLOADING Be sure the safety is in the “on” or “safe” position and the barrel is pointed in a safe direction. 1. Pull forend back until unused cartridge ejects from the ejection port. Repeat this until all cartridges have been ejected (Fig. 5). 2. Visually and physically inspect that all cartridges have been cleared. 5 DISASSEMBLY Be sure the safety is in the “on” or “safe” position and the barrel is pointed in a safe direction. CAUTION: Make sure the gun is unloaded. 1.
REASSEMBLY 1. Insert trigger group from the back of the receiver and install retaining pin on the opposite side of the ejection port with knurled side of pin away from the receiver (Fig. 10). A hammer may be necessary to fully seat the pin. Please use caution not to damage your shotgun. 2. Replace the spring back onto the magazine tube (Fig. 11). 3. Reassemble the action assembly with the barrel and forend (Fig. 12). 4.
CLEANING & MAINTENANCE CAUTION: Make sure the firearm is unloaded. 1. Make sure the broad, polished finely fitting mating surface of a the breech block and receiver is especially clean and lightly oiled with high quality gun oil. Do not use silicone, lanolin or WD-40. 2. Run an oil patch through the bore with a cleaning rod starting from the breech end. To prevent leading, use a cleaning solvent and brass brush to clean the bore periodically. Follow this cleaning with one or two clean oil patches.
EXPLODED VIEW 12 CHARLESDALY.
PARTS LIST Part # Description 38 Sear Pin 1 Receiver 39 Sear Plunger 2 Magazine Follower 40 Sear Spring 3 Magazine Tube Spring 41 Sear 4 Magazine Spring Retainer 42 Trigger Plate Pin 5 Magazine Tube 43 Magazine Cap 6 Barrel Collar 44 Grip Cap 7 Barrel Extension 45 Swivel Stud 8a Ejector Housing 46 Action Spring 8b Ejector Plunger 47 Grip Screw 8c Ejector Spring 48 Grip Bolt Washer 8d Ejector Spring Stop Pin 49 Grip Cap Screw 8e Ejector House Screw 50 Cartri
WARRANTY CONDITIONS This warranty only applies to Charles Daly products imported by Chiappa Firearms USA, Ltd. and purchased in the USA. The manufacturer guarantees that our products are scrupulously checked against defects in materials, workmanship, aesthetics and functioning problems. In case you find a defect in one of our products, you should immediately contact Chiappa Firearms USA, Ltd. All warranty work will be performed by Chiappa Firearms USA, Ltd.
WARRANTY CONDITIONS The Guarantee Is Void In Case: • Inadequate ammunition has been used (any ammunition but those commonly on sale, reloaded ammunition, different from caliber and specification indicated on the firearm barrel) • The product failed to be provided proper maintenance and cleaning • The product has been modified without our prior consent • Unauthorized, inadequate or incorrect repairs have been carried out • Non-original spare parts were used • Parts subject to wear and corrosion • Damage (imp
RETURN MERCHANDISE FORM To return your firearm for any reason, please call Customer Service at (937) 835-5000 for an RMA (Return of Merchandise Authorization). CUSTOMER INFORMATION Name: RMA# Address: City: State: Phone: Best Time to Call: Email: PRODUCT INFORMATION Model: Serial #: GUN SHOP/ DEALER Purchase Date: Dealer Name: Dealer Address: DESCRIPTION OF DEFECT Remember: Attach Proof of Purchase w/ Date 16 CHARLESDALY.
NOTES 17 CHARLESDALY.
NOTES 18 CHARLESDALY.
CHARLESDALY.COM Exclusively Distributed by Chiappa Firearms USA, Ltd. 1415 Stanley Ave | Dayton, OH 45404 | Tel: 937-835-5000 | Email: info@chiappafirearms.
