How to Guide
107
Threaded Fittings
Please see the section of this technical manual for complete
JOGPSNBUJPOPO5ISFBEFE+PJOUT
maximum recommended temperature and de-rating of work-
ing pressure applies to both heat generated from fluid being
distributed through pipe system and heat generated from
sources external to the pipe system.
CPVC can be connected to tankless gas water heaters using a
CPVC-to-brass threaded transition fitting. Verify code require-
ments prior to installation.
Dimensional Data
For dimensional requirements of FlowGuard Gold
®
CTS and
3F6[F
®
CPVC please see the Dimensional Data section of
this manual.
Disinfection
'MPX(VBSE(PMEBOE3F6[F
®
CPVC have been tested and found
to be unaffected by chlorine in concentrations up to 3,000
QBSUTQFSNJMMJPOJOXBUFS/PSNBMTZTUFNEJTJOGFDUJPOBU
parts per million chlorine will not harm CPVC.
Elevated-Temperature
Performance
(T/P Relief Valve Drainage Pipe)
$54$17$QJQFDPOGPSNJOHUP"45.%JTSBUFEGPSDPO-
UJOVPVTPQFSBUJPOBU×'QTJ5IFGPMMPXJOHBEESFTTFT
the expected capabilities of CPVC during short-term exposure
UPUFNQFSBUVSFTBOEPSQSFTTVSFTBCPWF×'QTJUIBU
NBZPDDVSGSPNUJNFUPUJNF)PXFWFS$54$17$QJQFJTOPU
recommended for pressure applications where temperatures
will consistently exceed 180°F.
6TFPG$54$17$GPS51SFMJFGWBMWFESBJOBHFMJOFT
$17$JTBTVJUBCMFNBUFSJBMGPS51EJTDIBSHFQJQJOH"
CPVC-to-brass transition fitting should be used connecting
UP51SFMJFGWBMWF
'MPX(VBSE (PME QJQF BOE mUUJOHT NFFU UIF 6OJGPSN
Plumbing Code short term working pressure requirement
PGIPVSTBU×'QTJ'VSUIFSNPSF$17$QJQF
JTBQQSPWFEGPS51EJTDIBSHFQJQJOHVOEFSUIFGPMMPXJOH
model codes:
SBCCI Standard Plumbing Code - Section 1210.1.
#0$" #0$"/BUJPOBM1MVNCJOH$PEF
Section P 1506.4.2 (1991)
61$ 6OJGPSN1MVNCJOH$PEF
Installation Std. IS-20 - Sec. 1007.1.
ICC International Code Council
4FDUJPO
SPECIAL CONSIDERATIONS
Use of FlowGuard Gold
®
CTS CPVC all-plastic threaded
male adapters in hot water applications may result in
system failure and property damage.
Ki[ fbWij_Y j^h[WZ[Z 9JI 9FL9 cWb[ WZWfj[hi _d YebZ
mWj[hWffb_YWj_ediedbo$
Ki[9JI9FL9nXhWiij^h[WZ[ZjhWdi_j_ed\_jj_d]i\eh^ej
mWj[hWffb_YWj_edi$
:e dej ki[ Yecfh[ii_ed \_jj_d]i m_j^ XhWii \[hhkb[i je
Yedd[Yjje9JI9FL9f_f[eh\_jj_d]im^[h[mWj[h
j[cf[hWjkh[im_bb[nY[[Z'*&Z[]h[[i<$
9FL9f_f[YWdX[ki[Zm_j^ijWdZWhZXhWii\[hhkb[ije
cWa[ Yecfh[ii_ed Yedd[Yj_edi m^[h[ j^[ ef[hWj_d]
j[cf[hWjkh[m_bbdej[nY[[Z'*&<$7ffboJ[\bedFJ<;
jWf[el[hj^[\[hhkb[jeWbbem\ehj^[Z_ii_c_bWhj^[hcWb
[nfWdi_ed WdZ YedjhWYj_ed Y^WhWYj[h_ij_Yi e\ j^[ c[jWb
\[hhkb[WdZj^[fbWij_Yf_f[$
Tub Fillers, Showerheads and Outside Sillcocks
CTS CPVC should be connected to tub fillers, showerheads
and outside sillcocks with a CPVC to brass threaded transition
fitting or a metal nipple. Direct connection to CPVC or CPVC
threaded fittings is not recommended.
Water Heaters / Boilers
Instructions from the manufacturer of the water heater and
applicable local plumbing and building codes should be fol-
lowed.
Do not use FlowGuard Gold CTS CPVC pipe or fittings on sys-
tems capable of achieving temperatures greater than 180°F.
8IFO'MPX(VBSE(PME$54$17$QJQFJTVTFEXJUIBOFMFD-
tric water heater, a CPVC-to-brass transition fitting should
be used. CPVC threaded male adapters should not be used to
connect to water heaters or connect to metallic nipples in close
proximity to water heater.
8IFODPOOFDUJOHUPBHBTXBUFSIFBUFSBUMFBTUJODIFTPG
metal nipple or appliance connector should be used so that the
CPVC tubing cannot be damaged by the build-up of excessive
radiant heat from the draft diverter. Some high-efficiency
direct-vent gas water heaters eliminate the radiant heat from
the flue and can be piped directly to the water heater. A brass
threaded CPVC transition fitting must be used for connection
to the water heater.
NOTICE: Do not connect CTS CPVC or Schedule 80 CPVC
directly to a boiler due to excessive heat generated. The