® cranmore 5&7 Operating & Installation Instructions
CONTENTS QUICK GUIDE 4 OPERATING INSTRUCTIONS 5 FUEL 5 LIGHTING 5 CONTROLLING THE FIRE 5 REFUELLING 6 ASH CLEARANCE 6 REDUCED BURNING 6 MAINTENANCE 6 THROAT PLATE AND FLUEWAY CLEANING 7 CHIMNEY SWEEPING 7 TROUBLE SHOOTING 8 CO ALARM 8 IF YOU NEED FURTHER HELP 8 INSTALLATION INSTRUCTIONS 9 UNPACKING THE STOVE 9 HEALTH AND SAFETY PRECAUTIONS 9 CO ALARMS 9 SPECIFICATION 9 CHIMNEY 10 HEARTH AND FIRE SURROUND 10 CONNECTIONS TO FLUES 10 SOOT DOORS 11 PRE LIGHTING CHEC
QUICK GUIDE ® Throat plate Improves efficiency of stove by slowing down flue gases Door Keep closed when stove is in use Door handle Pull to open Front Fence Protects glass and prevents spillage Sliding Ashpan For clean and easy ash removal AIR CONTROL Boost Nominal High Low Output Output MAINTENANCE AND CLEANING GLASS Wipe with damp, lint free cloth. Any stubborn deposits on the glass may be removed with a proprietary stove glass cleaner or ceramic hob cleaner.
OPERATING INSTRUCTIONS ® Congratulations on becoming the owner of a Charnwood Cranmore Approximate suitable log sizes are: Stove. Your stove has been approved in smoke control areas to burn 300mm(11in) long and 75mm (3in) diameter - Cranmore 5 wood logs if it is used in accordance with these instructions. It is very 390mm(15in) long and 75mm (3in) diameter - Cranmore 7 important that you read and understand these instructions before using the stove.
OPERATING INSTRUCTIONS ® When the fire is burning normally the air control gives enough Do not operate with the door open except as directed by the airwash to keep the glass clean. However, it will not always be instructions as this can cause excessive smoke. possible to keep the glass clean with the air control fully closed. For ASH CLEARANCE correct firing we recommend the use of a stove pipe thermometer which may be purchased from your supplier or from Charnwood.
OPERATING INSTRUCTIONS ® fire has been out of use, the chimney and appliance flueways should The chimney should be swept at least twice a year. Where the top be cleaned before lighting. outlet or vertical rear flue connector is used it will generally be possible to sweep the chimney through the appliance. Door Seals For the fire to operate correctly it is important that the door seals First remove the upper and lower throat plates. Then sweep the are in good condition.
OPERATING INSTRUCTIONS TROUBLE SHOOTING ® not emit fumes. Occasional fumes from de-ashing and re-fuelling may occur. Persistent fume emission is potentially dangerous and Fire Will Not Burn must not be tolerated. If fume emission does persist, then the following immediate actions should be taken: Check that: a) Open doors and windows to ventilate the room and then leave a) the air inlet is not obstructed in any way, the premises.
INSTALLATION INSTRUCTIONS UNPACKING THE STOVE ® A fixed ducted air supply may be used as an alternative to the traditional method of using a permanent open vent into a room to The stove arrives bolted and strapped to its pallet. There must be supply air for combustion. adequate facilities for unloading and manoeuvring into position.
INSTALLATION INSTRUCTIONS CHIMNEY ® the flat front of the stove by 432mm - Cranmore 5, and 497mm Cranmore - 7. In order for the appliance to perform satisfactorily the chimney must give sufficient draw when warm (minimum of 12pa/0.05” If in doubt as to the positioning of the stove, expert advice should be wg). The height of the chimney must comply with local sought either from the supplier or the local building inspector.
INSTALLATION INSTRUCTIONS Horizontal lengths of flue must be kept to a minimum and should not ® Fig. 5 Vertical Register Plate With Bricked Up Fireplace Soot door inside or rear of chimney be more in length than the flue diameter. The stove comes with the blanking plate (fig. 9) fitted to the top Register plate flue outlet. The seal for the top outlet is a 155mm dia ring of rope seal. The seal for the rear outlet is a length of adhesive backed fibre webbing supplied with instructions ref: TIS093.
INSTALLATION INSTRUCTIONS Fig. 8 Horizontal Register Plate With Optional Vertical Rear Flue Connector ® The Cranmore 5 and Cranmore 7 have been been recommended as suitable for use in smoke control areas when burning wood logs. Alternative soot door positions The stove includes a factory-fitted modification to the air control to prevent complete closure of the air supply. Suitable Authorised fuels can also be burned within Smoke Control Areas.
CRANMORE 5 DIMENSIONS 225 403 178 99 ® VERTICAL REAR FLUE ADAPTOR PLAN VIEW To suit 150mm (6”) flue pipe 92 541 651 142 470 402 FRONT SIDE 13 78 REAR
CRANMORE 7 DIMENSIONS 226 403 445 177 99 ® VERTICAL REAR FLUE ADAPTOR PLAN VIEW To suit 150mm (6”) flue pipe 97 541 651 141 78 535 403 FRONT SIDE 14 REAR
Charnwood Cranmore 5 Parts List IssueCRANMORE A 5 PARTS LIST ® 10 13 11 40 41 6 7 9 33 34 8 8 19 5 3 4 1 17 18 15 29 30 37 36 38 16 14 21 38 23 37 35 26 25 24 20 31 22 27 32 30 28 Item Part No.
Charnwood Cranmore 7 Parts List IssueCRANMORE A 7 PARTS LIST ® 13 40 41 10 6 11 7 33 34 9 19 29 36 38 8 8 30 3 4 1 17 18 37 5 38 37 20 14 22 35 15 16 26 21 31 23 27 25 24 32 30 28 Item Part No.
CERTIFIC ATION ® AJ WELLS & SONS LTD Bishops Way, Newport, Isle Of Wight PO30 5WS, United Kingdom A Division of A.J.Wells & Sons Limited Registered In England No. 03809371 CE certificate for compliance with EN13240:2001 21 EN13240:2001 ROOMHEATERS FIRED BY SOLID FUEL Cranmore 5 Cranmore 7 LC11-CPD-2019 LD11-CPD-2020 WOOD LOGS WOOD LOGS Rated space heating thermal output: 5kW 7kW Emission of CO in combustion products: 0.09 0.
MODÈLE MODELLO MODEL CLASSE D’EFFICACITÉ CLASSE DI EFFICIENZA KLASA EFEKTYWNOŚCI PUISSANCE THERMIQUE NOMINALE INDICE DI EFFICIENZA ENERGETICA EFFICACITÉ ÉNERGÉTIQUE SAISONNIÈRE POUR LE CHAUFFAGE DES LOCAUX EFFICIENZA ENERGETICA STAGIONALE DI RISCALDAMENTO DI AMBIENTE AIRE 3 AIRE 5 AIRE 7 ARC 5 ARC 7 BAY 5 BAY 5 BX BAY 5 VL BEMBRIDGE C-FOUR BLU C-FOUR INSERT C-FIVE BLU C-SIX C-SIX BLU C-EIGHT BLU COUNTRY 4 BLU COUNTRY 6 COVE 3 BLU CRANMORE 5 CRANMORE 7 ISLAND I (AP) ISLAND II (BP) SKYE 5 SKYE 7 C-FO
your premier dealer
