Operation Manual

TheseapplianceshavebeenapprovedbyHETASasintermittent
operatingappliancesforburningdryseasonedwoodlogsonly.
HETASapprovaldoesnotcovertheuseofotherfuelseitheraloneor
mixedwithwoodlogsnordoesitcovertheinstructionsforuseof
otherfuels.
Toolrequiredforfittingtheriddlinggrate:
10mmSpanner
Pozidrivscrewdriver
Beforefittingtheriddlinggrate(Fig.1)removethefuelretainerand
thewoodashretainer.Thewoodashretainerisnotrequiredwhen
theriddlinggrateisfitted.
Undothenutontheriddlingblankingholeusinga10mmspanner.
Removethecoverandspacingwasher(ensureyoukeeptheseina
safeplaceasyouwillneedtoreplacethemiftheriddlinggrateis
removed).
Feedtheriddlerrodthroughtheholeontherighthandsideofthe
stove,andslideonewasherontotherod(ifthereisnotsufficient
roomtotherightofthestovetodothisthenremovetheriddler
knob,fitonewasherovertherodandthenslidetherodthroughthe
holefromtheinsideofthestove).
Feedtherodthroughthetwosidefireplatesandslidetheother
washerontotherodsothatthewashersendupoutsidethetwoside
fireplates.Withthesidefireplatespushedtogetherfittheretaining
clipssothatthewasherscomeinsidetheclips.
Slidethesidefireplatesapartsothattheyrestagainstthesidesofthe
firebox.Slotinthefrontandrearsupportplates.
FITTINGTHERIDDLINGGRATE
CongratulationsonbecomingtheownerofaHETASapproved
CharnwoodC-SeriesStove.YourstovehasbeenapprovedbyDEFRA
toburnwoodlogsinasmokecontrolareaifitisusedinaccordance
withtheseinstructions.Itisthereforeveryimportantthatyouread
andunderstandtheseinstructionsbeforeusingthestove.
FUEL
Beforelightingthestovecheckwiththeinstallerthattheworkand
checksdescribedintheInstallationInstructionshavebeencarriedout
correctlyandthatthechimneyhasbeenswept,issoundandfree
fromanyobstructions.Thestoveisnotsuitableforuseinashared
fluesystem.
Rememberthatthestovewillbehotandthatitismadefromhard
materials – ensurethatyouhavegoodbalancebeforeoperatingthe
fire.
Donotuseanaerosolsprayonornearthestovewhenitisalight.
Thereisariskofexplosionorflashignitionofthespray.
Thestoveissuitableforintermittentoperation.
Thisstovehasbeendesignatedtoburnwood.Onlydrywellseasoned
woodshouldbeburntonthisapplianceasburningwetunseasoned
woodwillgiverisetoheavytardepositsinthestove,ontheglassand
withinthechimney.Forthesamereasonhardwoods(suchasAsh,
BeechandOak)arebetterthansoftwoods(suchasPineand
Spruce).Burningwetunseasonedwoodwillalsoresultin
considerablyreducedoutputs.Thewoodshouldbecutandsplitand
thenlefttoseasoninawellventilateddryplaceforatleastoneyear
butpreferablytwoyearsbeforeuse.Approximatesuitablelogsizes
are:
C4&C6 255mm(10in)longand75mm(3in)diameter
C5&C8 305mm(12in)longand75mm(3in)diameter
C7 380mm(15in)longand75mm(3in)diameter.
Thisstoveisnotdesignedtoburnhouseholdwaste.
ForadviceonotherfuelspleasecontactCharnwood.
PETROLEUMCOKEISNOTSUITABLEFORUSEON
THISAPPLIANCE.ITSUSEWILLINVALIDATETHE
GUARANTEE.
Whenusingthestoveinsituationswherechildren,agedand/or
infirmpersonsarepresentafireguardmustbeusedtoprevent
accidentalcontactwiththestove.Thefireguardshouldbe
manufacturedinaccordancewithBS8423:2002.
®
OPERATINGINSTRUCTIONS
4
Fig.1.OptionalGrateKit
FrontGrate
Support
RHSideGrate
Support
GratePlates
RearGrate
Support
Riddler
Rod
Ashpan
LHSideGrate
Support