CHARNWOOD COUNTRY 15B Roomheater with Boiler Operating and Installation Instructions CHARNWOOD Bishops Way, Newport, Isle of Wight PO30 5WS, United Kingdom T:+44 (0)1983 537799 F:+44 (0)1983 537788 charnwood@ajwells.co.uk www.charnwood.
OPERATING INSTRUCTIONS FOR THE CHARNWOOD COUNTRY 15B Before lighting the stove check with the installer that the work and checks described in the Installation Instructions have been carried out correctly and that the chimney has been swept, is sound and free from any obstructions. Do not light the fire before the boiler and heating system have been filled with water as this can damage the boiler. FUELS reduced outputs.
or fire lighters, and kindling on the grate and cover with approximately 2 inches of fuel. Turn the control knob to maximum, and open the airwash control fully (see Fig. 1). Light the paper or fire lighters. Close the doors until the fuel is well ignited then load with fuel and adjust the air controls to the required setting. On initial lighting, the stove may smoke and give off an odour as the silicon paint with which the firebox is painted reacts to the heat.
e) that an extractor fan is not fitted in the same room as the stove. f) there is sufficient draw in the chimney, (once the chimney is warm a draught reading of at least 0.10 inches water gauge should be obtained). maximum. When the fire is burning well load on more fuel as necessary and move the air controls to the desired setting. When burning wood use large logs rather than small ones. Proceed as above, but do not riddle the fire either when shutting down or reviving.
ventilate the room. b) Let the fire out and safely dispose of the fuel from the appliance. c) Check for flue or chimney blockage, and clean if required. d) Do not attempt to re-light the fire until cause of fume has been identified, if necessary seek professional advice. The most common cause of fume emission is flueway or chimney blockage. For your own safety these must be kept clean. Over-Firing If the fire is over-fired it will cause premature failure of the internal fire parts.
INSTALLATION INSTRUCTIONS FOR THE CHARNWOOD COUNTRY 15B HEALTH AND SAFETY PRECAUTIONS Please take care when installing the stove that the requirements of the Health and Safety at Work Act 1974 are met. Some types of fire cement are caustic and should not be allowed to come into contact with the skin. In case of contact wash with plenty of water. If there is a possibility of disturbing any asbestos in the course of installation then please use appropriate protective equipment.
suitable inhibitor should be used. The system must be correctly vented as shown in Figs. 5 and 6. The height differential between the header tank and the appliance must not exceed 15.2 metres (50 feet). If all four boiler tappings are used then, if possible, diagonal pairs should be connected for domestic hot water and central heating. Where a common return is used an injector tee must be incorporated into the system as shown in Fig. 7.
Blanking Plate Soot Door In Side or Rear Alternative Of Chimney Soot Door Back of the Stove Positions Register Plate With Soot Door Blanking Plate Clamping Plate with fold horizontal Clamping plate finishes flush with inside face of firebox top and bottom. Fig 8. Vertical Register Plate With Bricked Up Fireplace Fig 11. Horizontal Register Plate With Vertical Rear Flue Connector Alternative Soot Door Positions Register Plate With Soot Door domestic hot water.
knob is turned. PRE LIGHTING CHECK roof of the appliance and should be checked to ensure that it has not become dislodged in transit. The method of location and positioning of the throat plate is shown in Fig. 3. Before initial lighting the following points should be checked :- COMMISSIONING 2. The plates round the sides and back of the grate must be in position and sitting correctly.
Issue D CHARNWOOD COUNTRY 15B PARTS LIST 38 40 35 48 Items 26 & 27 are not used on models after serial no. 1926 Item 24 has been replaced by items 51 & 52 but they are not interchangeable. 9 23 39 28 14 52 7 13 6 10 11 46 12 33 15 21 43 41 45 44 47 42 16 32 34 29 15 21 30 31 17 31 19 Item Part No. Description 1* 008/FV35L Left Hand Door Seal 2* 008/FV35R Right Hand Door Seal 3* 008/FV35/S Door Seal Set Incl.
Your Local Charnwood Dealer CHARNWOOD Bishops Way, Newport, Isle of Wight PO30 5WS, United Kingdom T:+44 (0)1983 537799 F:+44 (0)1983 537788 charnwood@ajwells.co.uk www.charnwood.