User Manual CBO HYBRID OV ENS Fire Up the Good Life! A MAJOR CAUSE OF OVEN-RELATED FIRES IS FAILURE TO MAINTAIN REQUIRED CLEARANCES (AIR SPACES) TO COMBUSTIBLE MATERIALS. IT IS OF UTMOST IMPORTANCE THAT THIS OVEN BE INSTALLED ONLY IN ACCORDANCE WITH THESE INSTRUCTIONS.
CBO-750 HYBRID-R OVEN | Instructions Manual ELECTRICAL DIAGRAM IS LOCATED BEHIND FRONT PANEL THIS OVEN MAY BE OPERATED OUTDOORS. KEEP THIS MANUAL FOR FUTURE USE. Chicago Brick Oven, LLC. | 1020 Davey Road, Suite 300 | Woodridge, IL 60517 Customer Assistance: 877.730.7758 © 2018 Chicago Brick Oven. All rights reserved.
Manufacturer's Contact Information Chicago Brick Oven, LLC 1020 Davey Road, Suite 300 - Woodridge, IL 60517 www.chicagobrickoven.com (877) 730-7758 IMPORTANT Register your product to activate your warranty and gain access to exclusive offers Register here: www.chicagobrickoven.com/apps/product-registration . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .. .
TO INSTALLER: LEAVE THESE INSTRUCTIONS WITH THE CONSUMER. TO CONSUMER: RETAIN THESE INSTRUCTIONS FOR FUTURE USE. WARNING! 1. DO NOT STORE OR USE GASOLINE OR OTHER FLAMMABLE LIQUIDS OR VAPORS IN THE VICINITY OF THIS OR ANY OTHER APPLIANCE. 2. AN LP CYLINDER NOT CONNECTED FOR USE SHALL NOT BE STORED IN THE VICINITY OF THIS OR ANY APPLIANCE. WARNING! DO NOT USE THIS APPLIANCE UNDER EXTENDED AWNINGS. FAILURE TO COMPLY COULD RESULT IN A FIRE OR PERSONAL INJURY.
READ ALL INSTRUCTIONS BEFORE INSTALLING AND USING THIS GAS & WOOD BURNING OVEN. SAVE THESE INSTRUCTIONS. Before installation, contact local authorities having jurisdiction (municipal building department, fire prevention bureau, etc.) about required permits, restrictions and installation inspection in your area. Please read this entire manual before you install the Oven. Failure to follow instructions may result in property damage, bodily injury or even death.
Outdoor Entertainment Welcome to a whole new dimension of outdoor cooking and entertaining with your new hybrid brick oven from Chicago Brick Oven! We invite you to visit (and frequent) our website, chicagobrickoven.com. It’s a great source of information and suggestions that will help you enjoy your new oven to the fullest: • Choose from dozens of mouthwatering recipes for everything from appetizers and breads to main courses and desserts, and of course, pizzas.
Table of Contents CBO-750 Installation Prep .............................................. 6 CBO-750 Hybrid Assembly Instructions.............7 -10 Detailed Specs CBO 750 Hybrid DIY Kit.......................................................11 CBO 750 Hybrid Countertop.................................................12 CBO 750 Hybrid Stand..........................................................13 Gas/Electric Installation............................................14-17 CBO Oven Operation................
CBO-750 Installation-Prep INSTALL AND USE ONLY IN ACCORDANCE WITH CHICAGO BRICK OVEN’S INSTALLATION AND OPERATING INSTRUCTIONS (OR EQUIVALENT). CONTACT LOCAL BUILDING OFFICIALS OR FIRE OFFICIALS ABOUT RESTRICTIONS AND INSTALLATION INSPECTION IN YOUR AREA. Requirements for Clearance from Combustible Materials The CBO-750 models come with a DuraTech 6" Anchor Plate (Model #6DT-AP) that works with a Class A Stainless Steel DuraTech 6" Double Wall Pipe (model #6DT-24SS to meet Standard HT103).
CBO-750 Hybrid Assembly Instructions CBO-750 OVENS SHOULD BE INSTALLED BY A PROFESSIONAL OR SUITABLY QUALIFIED INDIVIDUAL.
CBO-750 Hybrid Assembly Instructions Hearth Insulation Sub-hearth Insulation Boards (supplied) Your CBO-750 Hybrid Oven comes Pre-Assembled with Insulation Boards that are placed under both pieces of the Hearth—on top of the Steel Plate—for insulation. Place the Hybrid Unit on the Support Base. The Oven's decorative finish should be built on top of the Support Base, not on top of the Insulation Boards. Remember, the Insulation Boards should not be exposed to the elements and should not get wet.
CBO-750 Hybrid Assembly Instructions 1 You are now ready to mortar the Arch to the Dome. Use the refractory mortar provided to completely seal the space between the Arch and Dome. You will also put some mortar on the Front Hearth under the Arch. You don’t need a lot of mortar; just enough to make a seal. Place the mortar all the way around the Arch and on the Hearth on both sides under the Arch. 2 Note: Be very careful to not get any mortar in the mounting holes for the Arch and Door.
CBO-750 Hybrid DIY Kit Specifications Base SKU CBO-O-KIT-HYB Details • 6-Piece Oven (Dome, 3-piece Hearth, Arch, Decorative Door) • Gas Package (Available in Natural or Propane Gas; Specify Altitude) • Pre-Assembled Install Kit (Anchor Plate, Insulating Board & Blanket, Steel Plate, Mortar) • Residential (R) - Certified for Outdoor Use Only • Commercial (C) - Certified for Indoor & Outdoor Use Ambient Burner Switch Hearth Burner Switch • Accessory Package (Pizza Peel, Brush, Infrared Thermometer) • He
CBO-750 Hybrid Countertop Specifications Base SKU CBO-O-CT-750-HYB Details • Preassembled • Metal Insulating Hood Available in Silver Vein (SV) or Copper Vein (CV) • Gas Package (Available in Natural or Propane Gas; Specify Altitude) • Residential (R) - Certified for Outdoor Use Only • Commercial (C) - Certified for Indoor & Outdoor Use • Accessory Package (Pizza Peel, Brush, Infrared Thermometer) • Hearth Cooking Surface 38” x 28” • Oven Weight: 980 lbs Ambient Burner Switch Hearth Burner Switch © 2018
CBO-750 Hybrid Stand Specifications Base SKU CBO-O-STD-750-HYB Details • Preassembled • Custom-Built, Heavy-Duty Stand • Metal Insulating Hood Available in Silver Vein (SV) or Copper Vein (CV) • Gas Package (Available in Natural or Propane Gas; Specify Altitude) • Accessory Package (Pizza Peel, Brush, Infrared Thermometer) • Residential (R) - Certified for Outdoor Use Only • Commercial (C) - Certified for Indoor & Outdoor Use • Hearth Cooking Surface 38” x 28” Ambient Burner Switch Hearth Burner Switch
Gas/Electric Installation I. General outdoors only and not to be used in a building, garage or any other enclosed area. It is not intended to be installed in or on boats or recreational vehicles. • Upon receipt of your oven, thoroughly inspect for any damage. If damage is observed, contact the delivery agency immediately. • Safe and satisfactory operation of your oven depends to a great extent on its proper installation.
Gas/Electric Installation Continued IV. Information for Use with a SelfContained LP-Gas Supply System Locate and orient the LP cylinder to provide proper vapor withdrawal. Connect the regulator to the LP cylinder. Hand tighten it. Do not use a wrench. Check for leaks using a soapy water solution. NEVER USE OPEN FLAME TO CHECK FOR GAS LEAK. DO NOT STORE A SPARE LP GAS CYLINDER UNDER OR NEAR THIS APPLIANCE. NEVER FILL THE CYLINDER BEYOND 80% FULL.
Gas/Electric Installation Continued VIII. Electrical Connections When installed, the oven must be electrically grounded in accordance with local codes or in the absence of local codes, with the National Electrical Code, ANSI/NFPA 70, or the Canadian Electrical Code Part 1, CSA C22.1. Electrical Rating Volts Amps Frequency 120 1.50 60 • To protect against electric shock, do not immerse cord or plugs in water or other liquid; • Unplug from the outlet when not in use and before cleaning.
Gas/Electric Installation Continued 5. Place ambiance burner “ON/OFF” switch in “OFF” position. 6. Set main gas supply cock in “ON” position. 7. Turn main electrical supply “ON.” 8. Place main “ON/OFF” switch in “ON” position. 9. If burner does not light, repeat steps 1-8. VII. Ambient Burner Lighting Instructions Note: The hearth burner system must be ON as controlled by the thermostat. Place ambient burner ON/OFF switch in “ON” position. VIII.
Operation IX. CAUTION: In the event of power failure, do not attempt to operate oven until power is resumed. Note: Due to thermal expansion, small cracks may appear in the dome or hearth during the curing process. This is normal and the quality of your oven will not be compromised. NOTE: Inspect the gas hose (if used) before each use of the oven.
Maintenance X. CAUTION: Oven must be “OFF” and cool before any cleaning is done. • For service and repairs, contact factory, factory representative or local service company. • All maintenance and/or repair MUST be performed by someone trained/qualified to work on gas/ electrical equipment. For additional information or assistance, contact Chicago Brick Oven Customer Assistance at 630.359.4793 Disconnect the power supply to the appliance before cleaning and servicing the oven.
CBO Oven Operating Instructions TO PROTECT THE INTERIOR OF YOUR OVEN FROM RAIN AND OTHER MOISTURE, A PROTECTIVE RAIN CAP MUST BE INSTALLED ON TOP OF THE FLUE PIPE TO ENSURE THAT MOISTURE DOES NOT GET INTO YOUR OVEN. Operating Instructions After you have cured your Oven and are ready to start cooking, light a small fire and slowly build it up. The interior Dome of the Oven will at first turn black from the fire smoke.
CBO Oven Best Practices Other Precautions and Instructions away from all combustible materials, pending final disposal. When the ashes are disposed of by burial in soil or otherwise locally dispersed, they should be kept in the closed container until all cinders have thoroughly cooled. • LOCAL REGULATIONS ABOUT WOOD-BURNING EQUIPMENT SHOULD BE CONSULTED. • CBO OVENS SHOULD BE INSTALLED BY A PROFESSIONAL OR SUITABLY QUALIFIED INDIVIDUAL.
Customized Enclosure Designs However you plan to install your CBO Oven—as a stand-alone unit or as part of a complete outdoor kitchen—and whatever your material preference— stone, brick, stucco, etc.—your design choices for creating a customized enclosure are as limitless as your imagination. Here are just a few examples of how other homeowners have customized their CBO Hybrid wood burning ovens and created their ultimate outdoor and indoor cooking, dining and entertaining spaces. Visit chicagobrickoven.
Curing Your Oven Although your Oven may seem dry once you complete the installation process, there are small amounts of moisture pockets that need to work their way out. Another method of curing your new Oven is to build a fire in a separate location. Then take the coals and place them into the Oven. You’ll generate heat without the flame and the Oven will cure as required. Some new owners find this method a much easier way to cure the Oven and ensure the temperature doesn’t get too hot.
Firing Your Hybrid Oven with Wood A Once you’ve properly cured your Oven, you’re ready to fire it for cooking. B Always start with dry kindling placed 10 inches from the front of the Oven. CAUTION: NEVER USE CHEMICALS OR STARTER FLUIDS; YOU WILL NOT NEED THEM. C Once the fire is going, add small pieces of wood to build the fire. You want to raise the temperature slowly, so avoid building a huge fire that pours out of the mouth of the Oven.
How the Oven Works WOOD BURNING BRICK OVENS ARE SPECIALLY DESIGNED TO TAKE FULL ADVANTAGE OF ALL THREE COOKING METHODS—RADIANT HEAT, CONVECTION AND CONDUCTION. FlameRoll ™ Only our proprietary low-dome construction creates the perfect FlameRoll ™ from front to back. In this unique cooking method, the vent pulls the flame horizontally across the top of the Dome and then vertically back down the side.
Cooking in Your Oven ONCE THE OVEN HAS BEEN HEATED TO THE POINT THE ENTIRE DOME HAS TURNED A WHITISH GREY, YOU’RE READY TO COOK. Open-Door Cooking Open-door cooking is used to cook pizzas and other foods that require medium to high temperatures. Keep the fire going in the back of the Oven. Sweep out the front of the Hearth with a wire brush and you’re ready to cook. The Oven will become hot enough and the small fire on top will generate radiant heat.
Frequently Asked Questions What besides pizza can I cook in my wood burning brick oven? What types of ovens are better— refractory concrete, clay or brick? There is no limit to what you can cook in your CBO wood-fired brick oven. Anything you can cook in your home oven, you can cook in your CBO Oven—whole turkeys, bread, grinders, chicken, steaks, chops, vegetables, stews, empanadas, desserts and more. We’re partial to refractory and brick ovens because of their look and durability.
Limited Warranty Chicago Brick Oven, a manufacturer of wood-fired gas ovens, warrants the products to be free from defects in materials and workmanship for a period of one (1) year from the date of shipment. Local regulations about wood burning equipment should be consulted.
For more information, visit www.chicagobrickoven.com Chicago Brick Oven 1020 Davey Road Suite 300 Woodridge, IL 60517 (877) 730-7758 © 2018 Chicago Brick Oven. All rights reserved.
