Service Manual

Page 73
oTc Wiring (WiTh The door oPen liMiT SWiTch)
1 AMP
REMOTE
DOOR DETECTOR
CONTROLLER PWR
1 AMP
1 AMP
Nuetral
Safety
Ignition
Hot
FUSE PANEL
(BEHIND GLOVE BOX)
BK (20 GA. X 3)
*
NC
NO
COM
2
3
1
COM
NO
NC
1
2
3
J2
J1
RAMP DN
RAMP UP
KNL DN
KNL UP
RAMP
ENABLE
ROLLX VANS ONE TOUCH CONTROLLER WIRING DIAGRAM
N/C
1
14
DASH
RESET SWITCH (8/21/06)
DOWN LIMIT
UP LIMIT
RELAY BOARD #OTCV8 RELAY BD
2
D
N
R
P
BK
LG / WT (20 GA.)
RD / DB (20 GA.)
YL / BK (20 GA.)
YL / RD (20 GA.)
RD / BK (20 GA.)
RD (20 GA.)
YL / WT (20 GA.)
YL / DG (20 GA .)
RD / WT (20 GA.)
RD / DG (20 GA.)
VT / YL (20 GA.)
OR / RD (20 GA.)
DG (20 GA.)
DB (20 GA.)
WT / RD (20 GA.)
RD (8 GA.)
ROLLX VANS USER / RESET SWITCHES
(ASM #03220-005)
DASH
C-PILLARD-PILLAR
RD / DG (20 GA.)
YL / DG
KNEEL DISABLE (ON / OFF) SWITCH
(ASM #03220-001)
WT / RD (20 GA.)
BK
BK
BK
BK (12 GA.)
RD (12 GA.)
BK (12 GA.)
YL (12 GA.)
RD (10 GA.)
BK (20 GA.)
RD (14 GA.)
RD / WT (20 GA.)
BK (8 GA.)
BK (20 GA.)
BK (20 GA.)
DB (20 GA.)
DB (20 GA.)
DB / YL (20 GA.)
BK (20 GA. X 3)
BL (20 GA.)
OUT
IN
ITF RAMP OVERRIDE SWITCH
(DRIVER SIDE B PILLAR) #05175-001
RD (12 GA.)
RD (12 GA.)
YL (12 GA.)
BLACK
BLACK
BLACK
BK
DB
BK (20 GA.)
N/C
1
16
BLACK
RAMP MOTOR
OUTPUTS INPUTS
DOOR DISABLE
POWER OVERRIDE BUS
N/C
N/C
N/C
WT / RD (20 GA.)
OR (20 GA.)
RD (20 GA.)
BL (20 GA.)
RD (20 GA.)
OR (20 GA.)
#310-1059
RD (-)
YL (+)
ITF RAMP
OUTPUTS
INPUTS
PWR OVERRIDES
FUSE
BK
DB
BK
DB
BK
DB
ANTENNA RUNS
UP PASSENGER
“D” PILLAR
D
G
(
2
0
G
A
.
)
VT
BK
RAMP LIMIT SWITCHES
(#6X284)
BK
KNEEL SYSTEM
KNEEL LIMIT SWITCHES
(#6X284)
UP
LIMIT
DOWN
LIMIT
BK
WT / RD (20 GA.) X 3
40A
N/C
N/C
BK (20 GA.)
VT (20 GA.)
AUX I/O
DB / YL (20 GA.)
*
*
*
* = For pictures of location see
Important Information and Location
Section in Service Manual
Italic Font = OEM Wire
YL (12 GA.)
RD/DB
YL / BK
YL/RD
RD / BK
RD
1
BLACK
SHUNT, 2005 HONDA
CAN BUS
#WM4814-ND-H ASM
YL / WT
1N4007
DIODES
66
GY
(+)
BK
(-)
WT / RD (20 GA.)
GN/DB
DB (20 GA.)
N/C
BACK SIDE
BACK SIDE
16
1
4
Neutral Safety
12/27/12
# 08044-002
BK
ASM #03220-005
CM6200
ASM #03295-003
Compustar Remote
11DQ05-ND
DIODE
N/C
1
4
1
6
5
10
(OEM CAV #4)
OR (20 GA.)
(OEM CAV #1)
OEM B-PILLAR SWITCH
(Rollx Vans uses this to
operate the door)
PASSENGER DOOR MODULE
(Rollx Vans uses this to
unlock the door)
NC
NO
COM
2
3
1
A
B
COM
NO
NC
1
2
3
1
4
8
13
17
21
3
7
23
20
16
(OEM CAV 9)
*(To Inition Hot)
located under
steering column
Rollx Vans Remote Reciever
BK (20 GA.)
12
1
8
7
14
TIPM
(Fuse box
under hood)
C309
WT/OR (CAV 5)
WT/GY (CAV 12)
CUT
D M R R
Door Module Right Rear
VT/YL (CAV 11)
Passenger’s side Door snake
(B-Pillar)
Twisted pairs run down B-Pillar
WT/GY
WT/GY
WT/OR
WT/OR
COM
NO
NC
1
2
3
-
+
DOOR OPEN LIMIT SWITCH
(Passenger side lower door track)
(Door Closed Limit)
(Chrysler Door Ajar Circuit)
(Door Open Limit)
(Neutral Safety)
(Unlock Output)
(Unlock Output)
(User switch)
BK (10 GA.)
OR/RD (20 GA.)
RD (10 GA.)
BK (10 GA.)
GND (To Body)
DB
1
12
BACK SIDE
ITF Harness V6/ OTC Board V8 MOD E-F ( )W/ Limit Switch
08330-001 INITIAL RELEASE. 11/25/2008
REVISION HISTORY:
COPYRIGHT 2008
CHECKED BY:
Rollx Vans, Inc.
6591 West Highway 13
Savage, MN 55378
952.890.7851
SCALE:
DRAWING #: 12361
REVISION:
NONE
V-8.00 My11 Chrysler
DRAWN BY:
Jason Hodgkins
Lynn Ringdahl