Service Manual

Page 75
oTc Wiring (WiTh The door deTecTor)
(VT/YL)
Twisted pairs run down B-Pillar
WT/OR (20GA.)
WT/GY (20GA.)
LB/WT (20GA.)
LB/VT (20GA.)
Solder
1 AMP
REMOTE
DOOR DETECTOR
CONTROLLER PWR
1 AMP
1 AMP
Nuetral
Safety
Ignition
Hot
FUSE PANEL
(BEHIND GLOVE BOX)
BK (20 GA. X 3)
*
NC
NO
COM
2
3
1
COM
NO
NC
1
2
3
J2
J1
RAMP DN
RAMP UP
KNL DN
KNL UP
RAMP
ENABLE
ROLLX VANS ONE TOUCH CONTROLLER WIRING DIAGRAM
N/C
1
14
DASH
RESET SWITCH (8/21/06)
DOWN LIMIT
UP LIMIT
RELAY BOARD #OTCV8 RELAY BD
2
D
N
R
P
BK
LG / WT (20 GA.)
RD / DB (20 GA.)
YL / BK (20 GA.)
YL / RD (20 GA.)
RD / BK (20 GA.)
RD (20 GA.)
YL / WT (20 GA.)
YL / DG (20 GA .)
RD / DG (20 GA.)
VT / YL (20 GA.)
OR / RD (20 GA.)
DG (20 GA.)
DB (20 GA.)
RD (8 GA.)
ROLLX VANS USER / RESET SWITCHES
(ASM #03220-005)
DASH
C-PILLAR
D-PILLAR
YL / DG
KNEEL DISABLE (ON / OFF) SWITCH
(ASM #03220-001)
WT / RD (20 GA.)
BK
BK
BK
BK (12 GA.)
RD (12 GA.)
YL (12 GA.)
RD (10 GA.)
BK (20 GA.)
RD (14 GA.)
RD / WT (20 GA.)
BK (8 GA.)
BK (20 GA.)
DB (20 GA.)
DB / YL (20 GA.)
BK (20 GA. X 3)
BL (20 GA.)
OUT
IN
ITF RAMP OVERRIDE
SWITCH
(DRIVER SIDE B
PILLAR) #05175-001
RD (12 GA.)
RD (12 GA.)
YL (12 GA.)
BLACK
BK
DB
BK (20 GA.)
N/C
1
16
BLACK
RAMP MOTOR
OUTPUTS
INPUTS
DOOR DISABLE
POWER OVERRIDE BUS
N/C
N/C
N/C
OR (20 GA.)
RD (20 GA.)
BL (20 GA.)
RD (20 GA.)
OR (20 GA.)
#310-1059
RD (-)
YL (+)
ITF RAMP
OUTPUTS
INPUTS
PWR OVERRIDES
FUSE
BK
DB
BK
DB
BK
DB
ANTENNA RUNS
UP PASSENGER
“D” PILLAR
D
G
(
2
0
G
A
.
)
VT
BK
RAMP LIMIT SWITCHES
(#6X284)
BK
KNEEL SYSTEM
KNEEL LIMIT SWITCHES
(#6X284)
UP
LIMIT
DOWN
LIMIT
BK (20 GA.)
40A
N/C
N/C
BK (20 GA.)
VT (20 GA.)
DB / YL (20 GA.)
*
*
*
YL (12 GA.)
RD/DB
YL / BK
YL/RD
RD / BK
RD
BLACK
SHUNT, 2005 HONDA
CAN BUS
#WM4814-ND-H ASM
YL / WT
1N4007
DIODES
66
GY
(+)
BK
(-)
GN/DB
DB (20 GA.)
N/C
BACK SIDE
BACK SIDE
16
1
Neutral Safety
9/23/2013
# 08044-002
BK
ASM #03220-005
CM6200
ASM #03295-003
11DQ05-ND
DIODE
N/C
1
4
1
6
5
10
(OEM CAV #4)
OR (20 GA.)
(CAV #1)
OEM B-PILLAR SWITCH
(Rollx Vans uses this to
operate the door)
PASSENGER DOOR MODULE
(Rollx Vans uses this to
unlock the door)
NC
NO
COM
2
3
1
1
4
8
13
17
21
3
7
23
20
16
(OEM CAV 9)
*(To Inition Hot)
located under
steering column
Rollx Vans Remote Reciever
12
TIPM
(Fuse box
under hood)
CUT
D M R R
Door Module Right Rear
Passenger’s side Door snake
(B-Pillar)
COM
NO
NC
1
2
3
-
+
(Door Closed Limit)
(Door Open Limit)
(Neutral Safety)
(Unlock Output)
(Door Control)
(User switch)
BK (10 GA.)
RD (10 GA.)
BK (10 GA.)
GND (To Body)
DB
N/C
1
8
7
14
C309
WT/GY (CAV 12)
VT/YL (CAV 11)
(Chrysler Door Ajar Circuit)
Solder
12
BACK SIDE
WT/OR (CAV 5)
(GND)
(V BAT)
BL (20 GA.)
(QUAD A + IN)
PK (20 GA.)
1
4
VT (20 GA.)
(QUAD B + IN)
LOCATION:
Passengers D-PILLAR
LOCATION:
Passengers B-PILLAR
LOCATION:
Passengers B-PILLAR
LOCATION:
Passengers C-PILLAR
LOCATION:
Passenger front door
LOCATION:
On the transmission
LOCATION:
Passenger’s side D-Pillar
1
12
BACK SIDE
BLACK
BLACK
WT / RD (20 GA.)
1
4
N/C
N/C
1
LOCATION:
Back side of the lower slider door track
P S D M R
Power Sliding Door Module Right
(Door Open Status out)
BL/YL (20 GA.)
BK (20 GA.)
OR/RD (20 GA.)
(Reset)
(GND)
(Door Closed Status In)
1
4
ITF Harness V6/ OTC Board V8 MOD F (W/ Door Detector)
*UNIVERSAL DOOR
DETECTOR
(13104-001ASM)
* = For pictures of location see
Important Information and Location
Section in Service Manual
Italic Font = OEM Wire
08330-001 INITIAL RELEASE. 11/25/2008
REVISION HISTORY:
COPYRIGHT 2008
Rollx Vans, Inc.
6591 West Highway 13
Savage, MN 55378
952.890.7851
Effective Stock # 47397
DRAWING #: 13266
Jason Hodgkins
DRAWN BY:
Effective Start Date: 8/26/2013
ECN # 13196