Datasheet

Cisco UCS Cisco UCS C220 M3 High-Density Rack Server (Small Form Factor Disk Drive Model)

SUPPLEMENTAL MATERIAL

CPU Removal and Installation (“pick n place”) Tool Set

The Pick n Place tool set includes two tools:

■ Pick and pull cap tool - used to pull off the plastic protective cap covering an empty CPU socket and

to remove or lift a CPU processor without touching it

■ Pick and place tool - used to install a CPU in its socket without damage. Must be used each time a

CPU is installed in a UCS “M3” server.

Instructions for using this tool set are found at the following link:

http://www.cisco.com/en/US/docs/unified_computing/ucs/c/hw/C220/install/replace.html#wp1233864

Thermal Grease (with syringe applicator) for CPU to Heatsink Seal

Thermal grease must be applied to the top of the CPU where it comes in contact with the heat sink.

Instructions for applying thermal grease are found at:

http://www.cisco.com/en/US/docs/unified_computing/ucs/c/hw/C220/install/replace.html#wp1233864

Air Baffle Replacement Kit

Air baffles are designed to direct airflow through the server to maintain server temperature at a safe

operating level. These baffles must always remain installed during server operation. The Air Baffle

Replacement Kit includes the air baffles needed for one UCS C220 M3 server.

NOTE: When you purchase a spare CPU, the Pick n Place Toolkit is included.

CAUTION: Use only the thermal grease specified for this server

(UCS-CPU-GREASE2=). This thermal grease comes in a red-tipped syringe

and is to be used only in the C220 M3 and C240 M3 servers. Other servers

use thermal grease in a blue-tipped syringe (UCS-CPU-GREASE=).

Thermal grease for other systems may have different thermal

conductivity properties and may cause overheating if used in the C220 M3

or C240 M3 servers.

DO NOT use thermal grease available for purchase at any commercial

electronics store. If these instructions are not followed, the CPU may

overheat and be destroyed.

NOTE: When you purchase a spare CPU, the thermal grease with syringe applicator

is included.