Vacuum 26 Gallon Operator's Manual READ THIS BOOK This book has important information for the use and safe operation of this machine. Failure to read this book prior to operating or attempting any service or maintenance procedure to your Clarke American Sanders machine could result in injury to you or to other personnel; damage to the machine or to other property could occur as well. You must have training in the operation of this machine before using it.
Table of Contents Important Safety Instructions .................................................................................... 3 Specifications ......................................................................................................... 4 Introduction and Instructions ..................................................................................... 4 Operating Instructions ..............................................................................................
IMPORTANT SAFETY INSTRUCTIONS DANGER: Failure to read and observe all DANGER statements could result in severe bodily injury or death. Read and observe all DANGER statements found in your Operator's Manual and on your machine. WARNING: Failure to read and observe all WARNING statements could result in injury to you or to other personnel; property damage could occur as well. Read and observe all WARNING statements found in your Operator's Manual and on your machine.
SPECIFICATIONS Model Voltage CAV 26 120 V Frequency Power 60 Hz 2400 W (800 x 3) Ambient Temp Volume Flow (CFM) -23°F to 86° F 290 (max) Static Lift (inches H2O) Sound Level dB(A) 82 73 Cord Length (ft.) Tank Volume 36 26 gal. Width (in.) Depth (in.) 26 27 Height (in.) Weight (lbs.) 61 143 INTRODUCTION AND INSTRUCTIONS The CAV 26 comes fully assembled. It is specifically designed for dry pick-up of fine dust made from grindings of wood or gypsum.
INTRODUCTION AND INSTRUCTIONS, cont. Features Figure 1, 1 - Control Panel For explanation of controls, see "Controls" section this page. Figure 1, 2 - Inlet This inlet is for installation of vacuum hose and accessories. Figure 1, 3 and Figure 2, 1 - Debris Canister The debris canister should be emptied when the canister is full. To empty canister, lift debris canister lever (figure 3,2). Debris canister will lower until it rests with it's wheels on the floor.
OPERATING INSTRUCTIONS To operate this machine follow these procedures: 1. Position the CAV 26 in a convenient location near a wall outlet and within reach of the working area. If the surface is not level, set the brakes on the casters. CAUTION: Do not use an extension cord with the CAV 26 or you will experience a loss in performance. Should an extension cord be necessary, use one sized 12 AWG and no longer than 50' in length.
OPERATING INSTRUCTIONS 3 4. Install a poly-liner (fig. 7, 1) in the debris canister (fig. 7, 2). To release the debris canister raise the lever (fig. 7, 3) as shown.. The poly-liner provides quick convenient disposal. 5. When the debris canister becomes full, the manometer (fig. 8, 1) reads in the red, deactivating all vacuum motors. 6. Allow time for the dust to settle, then operate the filter cleaning lever (fig. 9, 1) several times. 7. Remove the poly-liner and replace with a new liner. 8.
TROUBLESHOOTING Problem The vacuum fails to start Cause Action 1. Check whether power is reaching the socket. 1. No power. Check whether the plug and cable are in good condition. Ask for assistance from an authorized service technician. The rpm rate of the vacuum increases. 1. Clogged primary filter. 1. Shake the filter. Replace it if this is not sufficient. 2. Suction hose clogged. 2. Check the suction hose / wand and clean it. 1. The filter is torn. 1.
Section II Parts and Service (71114A) Clarke® American Sanders Operator's Manual - CAV 26 Page -9-
Frame Assembly Drawing 2/06 Page -10- Clarke® American Sanders Operator's Manual - CAV 26
Frame Assembly Parts List 5/06 Ref. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 Part No.
Container Unit Assembly Drawing 2/06 Page -12- Clarke® American Sanders Operator's Manual - CAV 26
Container Unit Assembly Parts List 3/06 Ref. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 38 Part No. Ref. Ref. Ref. 8 36028 5 60133 Ref. Ref. 8 17007 8 12013 8 17006 Ref. Ref. Ref. 924004 58413A 58411A 58414A Ref.
Suction Unit Assembly Parts List 2/06 Page -14- Clarke® American Sanders Operator's Manual - CAV 26
Suction Unit Assembly Parts List 6/06 Ref. 1-6 8 9 10 11 12 NI 13 14 16 17 18 19 20 21 23 24 25 26 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 Part No. 8 17324 8 14270 8 12168 8 13162 8 17325 8 54006 839067.115 8 16179 8 17326 8 16243 816381CFM 8 40401 Ref. 8 38036 8 40404 8 14271 8 35049 980646 88208A 88208A 56446A 88208A Ref. Ref.
Filter Group Assembly Drawing & Parts List 3/06 Ref. 1 2 3 4 5 6 Part No. 8 17026 Ref. Ref. Ref. Ref. 8 17749 Description Seal Tie Ring Tie Filter Filter Liner, Polyester Qty 1 6 1 1 1 1 Ref. Items 1 - 5 = Part No.
Control Panel Assembly Drawing & Parts List 6/06 Ref. 1 2 3 4 5 6 7 8 9 10 12 13 15 17 18 19 20 21 22 23 24 25 26 29 30 31 Part No. 8 39531 Ref. Ref. 80065A Ref. 8 39533 8 40403 Ref. Ref. Ref. 8 39526 8 40400 8 39525 8 39529 Ref. 80058A 80058A 920934 924004 980982 980982 924004 58411A Ref. Ref. 8 391160 Description Switch Cover Connection Block Label Screw, 4 x 10 Cables Kit Suppressor Pressure Switch Panel Seal Decal Voltage Indicator Manometer Switch Cable Locking Device Screw, 3.9 x 9.
Electrical Schematic 6/06 (Optional) (Optional) Page -18- Clarke® American Sanders Operator's Manual - CAV 26
CLARKE PRODUCT SUPPORT BRANCHES U. S. A.
Clarke® American Sanders U. S. Warranty This Clarke American Sanders Industrial/Commercial Product is warranted to be free from defects in materials and workmanship under normal use and service for a period of two years from the date of purchase, when operated and maintained in accordance with Clarke American Sanders's Maintenance and Operations instructions. This warranty is extended only to the original purchaser for use of the product.