Installation Guide

Mod# CH2233
Lighting Instructions
How Your Solar Powered Post Cap Works
• The solar panel converts sunlight energy into electricity during the day. The photocell automatically
turns the light on at night with the electricity stored in the batteries. It requires no wiring, because it
runs off the sunlight energy to recharge the batteries so there is no cost to run the solar cap.
• The number of hours the light stays on depends on your geographical location, weather conditions
and seasonal sunlight availability.
• Easy “Do-It Yourself” installation.
Includes:
1 - Solar Post Cap Light 1 - 2/3 AAA Ni-MH Rechargeable Battery 3 - Adaptors 2 - Mounting Screws
Post Cap Installation
1) To activate, pull the plastic tab out from the bottom of the fixture.
2) Attach the correct size adaptor for your post to the base of the fixture -
turn clockwise until it clicks into place as shown in Fig. 1
3) Secure fixture using the two mounting screws provided
(a 1/16” hole must be predrilled into the post) Fig. 2
4) Allow at least 24 hours of sunlight to fully charge the battery.
To Replace The Battery
(Battery replacement is approximately 1-2 years)
1) Remove the top clear lens by twisting counter clockwise Fig. 3
2) Carefully pry the tabs back to remove the solar panel.
Note: The solar panel can be removed easily, be careful
not to break the plastic tabs holding it in place.
3) Replace with a new AAA - 2/3 1.2 V Ni-MH
rechargeable battery
4) Snap the solar panel back into place and replace the top
clear lens by twisting clockwise until it clicks into place. Fig. 3
5) Allow the fixture to receive 24 hours of sunlight to fully charge the battery.
Troubleshooting
If the light does not turn on at dusk after 24 hours of charging:
•
Check the batteries to make sure they are making secure contact with the terminal.
•
Be sure the solar fixture is in a relatively sunny location.
•
Make sure the light’s photocell is not affected by other light.
Maintenance
Periodically clean light fixture with soft cloth and warm soapy water.
One Year Limited Warranty
This product is warranted to be free from defects in workmanship or materials at the time of purchase
for one year, (excluding batteries). Should a defect occur, please contact our customer service line at
1-866-460-4604 for service. Should any evidence of defects in material or workmanship appear within the
warranty period after the date of purchase, Classy Caps Mfg. Inc. will either repair or replace the product
at its option. Classy Caps Mfg. Inc. is not responsible for injury, property damage, or other consequential
damages or damages to third parties arising directly or indirectly from an actual or alleged defect in material
or workmanship of the product.
Classy Caps Mfg. Inc.
Kingsville, Ontario, Canada
www.fencecaps.com
Fig. 2
Fig. 3
Fig. 1
Post
Top Clear Lens
Solar Panel
Battery
Adaptor
TM
TM
MC