Operating instructions

ManualsBrandsCleveland ManualsFryerSGM-30-TR

Operators Manual

TR Gas Braising Pan

Installation & Operation

For units built after August 2011

SE95033 Rev. 8

June 2012

SGL-30-TR

SGM-30-TR

SGL-40-TR

SGM-40-TR

Cleveland

™

1333 East 179th St., Cleveland, Ohio, U.S.A. 44110

Ph: 216.481.4900 Fx: 216.481.3782

www.clevelandrange.com

Model # & Serial #.

(Open front panel to view rating label.)

For your future reference.

Model # ______________________________________

Serial # _______________________________________

Read the manual thoroughly.

Improper installation, operation or

maintenance can cause property

damage, injury or death.

TABLE OF CONTENTS

For your safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-2

Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-5

Operating Instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6

Cleaning Instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7

Preventative Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

Summary of content (9 pages)

PAGE 1
Operators Manual TR Gas Braising Pan Installation & Operation For units built after August 2011 SGL-30-TR For your future reference. SGM-30-TR Model # ______________________________________ SGL-40-TR Serial # _______________________________________ SGM-40-TR ! Model # & Serial #. (Open front panel to view rating label.) ™ Cleveland 1333 East 179th St., Cleveland, Ohio, U.S.A. 44110 Ph: 216.481.4900 Fx: 216.481.3782 www.clevelandrange.com ! Read the manual thoroughly.
PAGE 2
FOR YOUR SAFETY / POUR VOTRE SÉCURITÉ / PARA SU SEGURIDAD FOR YOUR SAFETY POUR VOTRE SÉCURITÉ PARA SU SEGURIDAD Do not store or use gasoline or any other flammable liquids and vapours in the vicinity of this or any other appliance. Ne pas entreposer ou utiliser d'essence ou d'autres liquides ou vapeurs inflammables à proximité de cet appareil ou de tout autre appareil. No guarde ni use gasolina o cualesquiera otros líquidos o vapores inflamables en las cercanías de éste o cualquier otro aparato.
PAGE 3
FOR YOUR SAFETY / POUR VOTRE SÉCURITÉ / PARA SU SEGURIDAD Hazard warnings are for your safey. Absence of a warning does not mean the hazard is not present. Unforeseen actions may result in unanticipated hazards. / Les avertissements de danger sont pour votre sécurité. L’absence d'un avertissement ne signifie pas que le danger n'est pas présent. Les actions imprévues peuvent entraîner des dangers imprévus. / Las advertencias sobre los peligros son para su seguridad.
PAGE 4
INSTALLATION UNCRATING GENERAL Insure gas and electrical supplies match rating plate. CAUTION: The rating plate is located directly behind the upper front panel (left side). For easy access, remove the two screws securing the upper front panel and hinge the lower front panel downwards. Gas type, burner ratings and electrical requirements are stated on the plate. ! Straps under tension and will snap when cut. Carton may contain staples and skid contains nails.
PAGE 5
POSITIONING GAS ENSURE THE GAS SUPPLY MATCHES THE KETTLE'S REQUIREMENTS AS STATED ON THE RATING PLATE. Installation must conform, with local codes or in the absence of local codes, with the National Fuel Gas Code ANSI Z223.1/NFPA 54, or the Natural Gas and Propane Installation Code, CSA B149.1 and B149-2 (Canada). The appliance and its individual shut-off valve must be disconnected from the gas supply piping system during any pressure testing of that system at test pressures in excess of 1/2 psi (3.
PAGE 6
ELECTRICAL CLEANING ENSURE THE ELECTRICAL SUPPLY MATCHES THE UNIT'S REQUIREMENTS AS STATED ON THE RATING LABEL. After installation the unit must be thoroughly cleaned and sanitized prior to cooking A cord and plug are supplied with the 115 volt unit. Simply plug the unit into any grounded outlet rated for a minimum of 10 amps.
PAGE 7
OPERATING INSTRUCTIONS WARNING: 3 If ignition fails and/or the control system goes into lockout, set power switch to the 'OFF" position. ! 2 Wait 5 minutes then repeat steps 1 through 3. If the problem persists, have a qualified serviceman check the system. 1 4 # 10 9 5 DESCRIPTION OPERATING THE UNIT 1. 2. 3. 4. 5. 0 6. 7. On-Off Switch Power Indicator Light (Red) Heat Indicator Light (Yellow) Temperature Dial Power Tilt Switch Manual Tilt Override Tangent Draw-Off Valve (not shown) 8.
PAGE 8
0 CLEANING INSTRUCTIONS CLEANING INSTRUCTIONS 1. Turn unit off. 2. Remove drain screen (if applicable). Thoroughly wash and rinse the screen either in a sink or a dishwasher. 3. Prepare a warm water and mild detergent solution in the unit. 4. CARE AND CLEANING Cooking equipment must 0be cleaned 0 5. regularly to maintain its fast, efficient cooking performance and to ensure its continued safe, reliable operation.
PAGE 9
0 PREVENTATIVE MAINTENANCE FOR MAINTENANCE AND REPAIRS CONTACT YOUR AUTHORIZED MANITOWOC SERVICE AGENCY AND HAVE A QUALIFIED SERVICE TECHNICIAN MAINTAIN YOUR EQUIPMENT. Ensure kettle is at room temperature 0 Shut off power at main and pressure gauge is showing zero fuse disconnect prior or less prior to removing Cleveland Range equipment requires little 0preventative maintenance. Weany do fittings. however provide the following to servicing.