Troubleshooting Manual
Table Of Contents
- Table of Contents
- Machine Will Not Start………………………….…….………...2
- Wash Pump Runs – Timer Will Not Cycle………….………...3
- Machine Cycles, Normal Wash Pump Will Not Run………...4
- Machine Will Not Turn Off……………………………………...5
- Dishwasher Will Not Drain, Drain Bill Not Lifting…………….6
- Drain Will Not Close, Drain Ball Will Not Fall………………...7
- Chemical Pumps Will Not Run …………………..….………...8
- Machine Will Not Fill With Water – Machine Runs ………….9
- Machine Only Fills During The Wash Cycle ………………..10
- Machine Only Fills When Fill Switch is Used…………...…..11
- Fill Valve Only Runs During the Wash Cycle……………....12
- Machine Only Fills When Fill Switch is Used…………...….13
- Fill Water Will Not Shut Off… ……………………………..…14
- Wash Tank Heater Is Not Getting Hot……………………....15
- Booster Heat Not Getting Hot (Final Rinse)……………...…16
- Machine Will Not Start
- Wash Pump Runs – Timer Will Not Cycle
- Machine Will Not Turn Off
- Dishwasher Will Not Drain, Drain Bill Not Lifting.
- Drain Will Not Close, Drain Ball Will Not Fall
- Chemical Pumps Will Not Run
- Machine Will Not Fill With Water – Machine Runs
- Machine only Fills During The Wash Cycle
- Machine Only Fills When Fill Switch is Used
- Fill Valve only Runs During the Wash Cycle
- Fill Water Will Not Shut Off
- Wash Tank Heater Is Not Getting Hot
- Booster Heat Not Getting Hot (Final Rinse)
Machine Will Not Fill With Water – Machine Runs
Machine Will Not Fill with Water
Machine Runs
Check Water Supply at Wall
Check Line Strainer in Ball Valve
Check Voltage at Water Valve Coil
Replace Coil If Needed
Repair Wire
Connection as needed
To check Coil Without Meter: Remove coil From
Valve, Insert Screwdriver into Armature Hole of Coil.
Depress the Start-Fill Switch, a Magnetic Field Will
Pull Screwdriver in.
If Screwdriver The Doesn’t Move
Check for poor Wire
Connection at
If Screwdriver Move’s
Check Diaphragm
Clean/ Debris
Replace
Diaphragm Kit
&
Plunger / Spring Kit
As Needed
Replace
Spade Connector
Or
Coil
As Needed
Spade Connector
Clean/Remove Debris
Parts and Service Manuals Are Available At:
www.cmadishmachines.com/products.html