Troubleshooting Manual
Table Of Contents
- Table of Contents
- Machine Will Not Start………………………….…….………...2
- Wash Pump Runs – Timer Will Not Cycle………….………...3
- Machine Cycles, Normal Wash Pump Will Not Run………...4
- Machine Will Not Turn Off……………………………………...5
- Dishwasher Will Not Drain, Drain Bill Not Lifting…………….6
- Drain Will Not Close, Drain Ball Will Not Fall………………...7
- Chemical Pumps Will Not Run …………………..….………...8
- Machine Will Not Fill With Water – Machine Runs ………….9
- Machine Only Fills During The Wash Cycle ………………..10
- Machine Only Fills When Fill Switch is Used…………...…..11
- Fill Valve Only Runs During the Wash Cycle……………....12
- Machine Only Fills When Fill Switch is Used…………...….13
- Fill Water Will Not Shut Off… ……………………………..…14
- Wash Tank Heater Is Not Getting Hot……………………....15
- Booster Heat Not Getting Hot (Final Rinse)……………...…16
- Machine Will Not Start
- Wash Pump Runs – Timer Will Not Cycle
- Machine Will Not Turn Off
- Dishwasher Will Not Drain, Drain Bill Not Lifting.
- Drain Will Not Close, Drain Ball Will Not Fall
- Chemical Pumps Will Not Run
- Machine Will Not Fill With Water – Machine Runs
- Machine only Fills During The Wash Cycle
- Machine Only Fills When Fill Switch is Used
- Fill Valve only Runs During the Wash Cycle
- Fill Water Will Not Shut Off
- Wash Tank Heater Is Not Getting Hot
- Booster Heat Not Getting Hot (Final Rinse)
Machine Cycles, Normal Wash Pump Will Not Run
Machine Cycles, Normally But
Wash Pump Will Not Run
Check Voltage to Motor
Contactor
Brown to White Coil
Wires
No Voltage
Check wire
Connection
Check Ice-cube
Rela
y
Red Wires
Check Ice-cube
Rela
y
Red Wires
Check Start
Micro Switch
Check Motor
Pause Micro
Switch
Brown Wires
To Top &
Middle
Terminals
Voltage Okay
Motor
contacto
r
Replace Motor
Contacto
r
Check Voltage
Black Wire on
Relay to Wire
No Voltage
Replace Relay
Voltage Okay
Check Voltage
A
t Wash Pump
Wires
No Voltage
Parts and Service Manuals Are Available At:
www.cmadishmachines.com/products.html
Voltage Okay
Re
p
lace Moto
r
Check Wire
Connections