INSTASTART™ Electronic Ignition Propane Rotisserie/Oven Instructions for use © 2006 The Coleman Company, Inc. www.coleman.com ® ANSI Z21.58a-2006/CSA 1.6a-2006 Outdoor Cooking Gas Appliances 9987 Series This unit is an accessory for Coleman® Propane Grill Models 9993 and 9998. Also read the additional instructions and warnings that are provided in the manual that came with your Coleman® Grill.
DANGER If you smell gas: 1. Shut off gas to the appliance. 2. Extinguish any open flame. 3. Open lid. 4. If odor continues, keep away from the appliance and immediately call your gas supplier or your fire department. Failure to follow these instructions could result in fire or explosion which could cause property damage, personal injury or death. DANGER 1. Never operate this appliance unattended. 2. Never operate this appliance within 10 feet (3.05 m) of any other gas cylinder. 3.
Only persons who can understand and follow the instructions should use or service this outdoor rotisserie. If you need assistance or outdoor rotisserie information such as an instruction manual or labels, contact The Coleman Company, Inc. DANGER DANGER indicates an imminently hazardous situation which, if not avoided, will result in death or serious injury. WARNING WARNING indicates a potentially hazardous situation which, if not avoided, could result in death or serious injury.
DANGER DANGER • EXPLOSION - FIRE HAZARD • CARBON MONOXIDE HAZARD • Never store propane near high heat, open flames, pilot lights, direct sunlight, other ignition sources or where temperatures exceed 120 degrees F (49°C). • Propane gas is heavier than air and leaking propane will sink to the lowest level possible. It can ignite by ignition sources including matches, lighters, sparks or open flames of any kind many feet away from the original leak. If you smell gas, leave the area immediately.
Electrical Attachments The maximum sum total amperage rating of electrical accessories attached to the 9993 or 9998 Series Coleman Grills must not exceed 10 amps. When using an electric attachment with the grill, follow the specification and warning statements accompanying the attachment.
WARNING CAUTION • SERVICE SAFETY • Keep all connections and fittings clean. Inspect propane cylinder and rotisserie propane connections for damage before attaching. • During set up, check all connections and fittings for leaks using soapy water. Never use a flame. Bubbles indicate a leak. Check that the connection is not cross-threaded and that it is tight. Perform another leak check. If there is still a leak, remove the cylinder and contact Coleman for service or repairs.
Rotisserie Assembly 3. Engage the locks by firmly pushing the tabs into the slots (Fig. 4). Be sure to engage two locks on the Side Rotisserie. Attach the Rotisserie to the Grill NOTE: This Side Solution™ Rotisserie attachment is designed for use only when properly attached to Coleman® grill models 9993 and 9998. Attempted use or setup in a manner not described in this manual is prohibited and will void the warranty. ■ Remove the components from the carton and discard all packing components.
10. Slide the motor downward over the bracket and push firmly into position (Fig. 10). Rotisserie Assembly 6. Push the fuel hose connection through the opening in the side grill panel (Fig. 7). Fig. 10 11. Plug the rotisserie cord into the outlet in the back of the grill. Setup Fig. 7 1. Slide the grease tray into the rails below the rotisserie (Fig. 11). 7. Open the door to reveal the Quick Coupler in the upper corner. Retract the Collar on the Quick Coupler before attaching to the male fitting (Fig.
3. Insert the pointed end of the spit rod into the opening in the motor and rest the collar on the frame (Fig. 13). The spit rod should freely turn when the motor is turned on. Burner and Orifice 1. Proper location of the burner with respect to the venturi and orifice fitting is important. To verify the proper factory installation of the burner and venturi, look at the unit from below and locate the burner and venturi.
Leak Testing (cont.) Operation DANGER CAUTION Inspect the gas supply hose before each use. Look underneath the grill to inspect the hose assembly below the grill. If there are cuts, damage, excessive abrasion or wear, replace the hose prior to operating the appliance. During assembly of the grill and when attaching or replacing the L.P. gas cylinder, insure that the gas supply hose is free of kinks and/or damage and is at least three inches away from hot surfaces such as the grill housing.
Rotisserie Burner Lighting (cont.) INSTASTART™ Electronic Ignition Rotisserie: 1. Open the lid. 2. Make sure all valves are OFF. 3. Turn on the cylinder valve. 4. Push in and turn on the Rotisserie Control Knob counterclockwise to HIGH, then repeatedly press the igniter switch until the flame ignites (Fig 19). 5. If ignition does not occur in 5 seconds, turn the Rotisserie Control Knob off, wait 5 minutes, and repeat the lighting procedure. 6.
■ A good flame should be blue with minimal yellow tip. Some yellow tips on flames are acceptable as long as no carbon or soot deposits appear (Fig. 23). BAD GOOD Blue Yellow Yellow Blue Holes in Burner Fig. 23 NOTE: If the burner flame is accidentally extinguished, turn off the control knob and wait 5 minutes before relighting the appliance. To Turn Off Turn off the control knob (Fig. 24). Fig.
Care, Maintenance and Cleaning CAUTION All cleaning and maintenance should be done only when the rotisserie and grill are cool and with the fuel supply turned off at the cylinder. Cleaning the Burner: WARNING Spider’s nests or wasp’s mud inside the burner tube may cause fire at the valve. If a fire occurs, immediately turn off the gas supply at the L.P. cylinder valve (see representative illustration in Fig. 25).
Parts List No. Part Number Description 1 2 3 4 9987-5031 “Please Call” 9987-5151 9987-2521 Lid Assembly Window Assembly Burner Assembly Grease Tray No.
Warranty Limited One Year Warranty The Coleman Company, Inc. (“Coleman”) warrants that for a period of one year from the date of original retail purchase, this product will be free from defects in material and workmanship. Coleman, at its option, will repair or replace this product or any component of the product found to be defective during the warranty period. Replacement will be made with a new or remanufactured product or component.
The Coleman Company, Inc. • 3600 North Hydraulic • Wichita, KS 67219 U.S.A. 1-800-835-3278 • TDD: 316-832-8707 © 2006 The Coleman Company, Inc. All rights reserved. Coleman® and are registered trademarks and INSTASTART™ is a trademark of The Coleman Company, Inc. www.coleman.
