Use and Care Manual

Page 1 (cover) Page 2 (inside)
Page 3 (inside) Page 4 (back)
Black border shows
page size and should
not print
Black border shows
page size and should
not print
11.0"
8.50"
Features:
•Adjustable Thermostat
•Two Settings:
High 1500 watts (5120 BTUs)
Low 750 watts
•Top Mounted Control Panel
•Power Indicator Light
•Safety Overheat Protection
•Safety Tip-Over Protection
•Silent Operation
•Sturdy Metal Body
•120V A.C. / 60Hz. 12.5A
®
Electric Baseboard Heater
Model #CZ600
USAGE:
HEATER OPERATION: Always operate the heater in
the upright position following all instructions and
recommendations listed in this manual HEATER
LOCATION: Place the heater in the area of the room that
is coldest. HEATER CONNECTION: Plug heater directly
into 120 volt A.C., 60 Hz wall outlet. Be sure plug fits
tightly in outlet. A loose connection may cause
overheating and damage to the plug or heater. NOTE:
To prevent overloading a circuit, do not plug the
heater into a circuit that is servicing other electrical
needs.
POWER INDICATOR LIGHT: This heater is equipped
with a Power Indicator Light. The power light will
illuminate when the unit is plugged in.
TURNING HEATER ON: To start the heater, turn the
Power Control dial from the OFF position to the LOW
or HIGH setting. Then rotate the Thermostat Control
clockwise to the HIGH THERMOSTAT position as
described below. (During the heaters initial use, you
may experience a slight odor or smoking. This is the
result of the heating element lubrication “burning off”.
This is normal and will go away after a few minutes of
use.)
POWER CONTROL DIAL: This heater has two heat
settings: High and Low. Use the higher setting (1500
watt) to raise the room temperature quickly. When the
desired temperature is reached use the Low setting. It
is usually sufficient to maintain a comfortable
temperature.
SETTING THERMOSTAT: After heater has been turned
on and the room has reached the desired temperature,
slowly rotate the thermostat knob counter-clockwise
until the heater shuts off (you should hear a faint
“click”). By leaving the thermostat at this setting it will
automatically maintain this temperature. To lower
temperature, rotate the knob further counter-clockwise
(towards the LOW position). To raise the temperature,
rotate the thermostat knob clockwise (towards the
HIGH position).
TURNING OFF: Turn the Power Control dial to the
OFF position before unplugging or plugging in the
heater. Heater should be unplugged when not in use.
IMPORTANT SAFETY FEATURES
The power indicator light, located near the control
panel, lights whenever the heater IS plugged in. The
heater is equipped with an automatic overheat
protection device located inside the body of the
heater. If the heater grill is obstructed, or if the heater
gets too hot for any reason, the automatic overheat
protection device will turn the heater off. To reset the
heater, simply turn power off and unplug the heater
for 10 minutes until it cools down and you may plug in
and restart the heater. Be sure that the heater is on a
smooth level surface with no obstructions. The heater
is also equipped tith a safety tip-over switch. This
switch will shut the heater off when the heater is
tipped over. It will reset when the heater is placed
upright.
CARE AND MAINTENANCE
CLEANING: CAUTION-Before cleaning the heater be
sure to disconnect power cord and allow the heater to
cool completely. Clean the outside surface with a
clean damp cloth. Do not use harsh chemical or
abrasive cleaners. DO NOT IMMERSE THE HEATER
IN WATER. Allow heater to dry completely before use.
REPAIR: DO NOT OPERATE THE HEATER WITHOUT
THE GRILL IN PLACE. DO NOT USE THE HEATER IF
IT HAS MALFUNCTIONED OR BECOME DAMAGED
IN ANY WAY.
STORAGE: Keep original carton for storage of the
heater. Coil and tie the power cord to avoid damage
during storage.
LIMITED WARRANTY
Products manufactured by Comfort Zone® are warranted to the original consumer to be free of
defects in material and workmanship for twelve (12) months from the original date of purchase. The
warranty does not cover products modified outside our factory, damage or failure caused by acts of
God, abuse, misuse, abnormal usage, faulty installation, failure to follow suggested maintenance
procedures enclosed with this product (as defined by Magnuson-Moss Warranty-Federal Trade
Commission lmprovement Act) This unit is guaranteed to the original retail purchaser against defects
in quality or workmanship for a period of one year from the date of original purchase. If this unit fails
because of a manufacturing defect within 30 days of purchase, return the unit, with your receipt, to the
retailer. After 30 days, but within the warranty period, if the unit was purchased within the continental
united States, return it, freight prepaid, to Comfort Zone®. for repair or replacement. If the unit was
purchased outside the continental united States, return the unit to the place of purchase. This
warranty does not cover damage due to accidents, operation on other than 120 volts, 60 hertz, AC.
current, or any other abuse. All implied warranties, including the warranties of merchantability and of
fitness of purpose, if applicable, are hereby limited in duration to the period of one year from the date
of original retail purchase. Some states do not allow limitations on how long an implied warranty lasts,
so the above limitations may not apply to you. Incidental or consequential damages arising from a
breach of either express or implied warranties are hereby disclaimed and excluded. Some states do
not allow the exclusion of limitation of incidental or consequential damages, so this limitation or
exclusion may not apply to you.
This warranty gives you specific legal rights, and you may also have other rights which vary from state
to state. No informal dispute settlement mechanisms are available. This limited warranty is given in
lieu of all other warranties.
Manufactured by:
Comfort Zone®
324A Half Acre Road
Cranbury, NJ 08512 USA
800-221-6895
www.comfortzoneheaters.net
INTENDED USE:
This product is intended for indoor residential, office and
personal shop use only, not for industrial or other
commercial applications. Use only with electrical wiring
that is in good working order and that meets applicable
codes and ordinances. If you have any questions
whether your wiring is adequate, consult a qualified
electrician.
Use your heater only with a working smoke detector
located in the vicinity of your heater.
While using your heater, you should follow the
IMPORTANT INSTRUCTIONS listed below. As part of
those instructions, we have used the word
'WARNING” to indicate the level of hazard:
WARNING indicates a hazard which, if not avoided,
could result in injury or death.
IMPORTANT INSTRUCTIONS
As with all electrical appliances, basic safety
precautions should always be followed to reduce the risk
of electric shock, fire, or injury to persons, including the
following precautions:
•Read all the instructions before using this
heater.
•Use this heater only as described in this
manual. Any other use not recommended by the
manufacturer may cause electrical shock, fire or
amage to persons or property.
•Do not operate the heater with a damaged
power cord or after the heater malfunctions, has
been dropped in any manner.
•Do not leave heater unattended while on. Extreme
caution is necessary when any heater/fan is used by or
near children or invalids and whenever the heater/fan is
left operating unattended.
•Do not place the heater on a small, unlevel,
uneven or any surface which might allow heater to tip
or fall.
•For proper operation, heater should be placed
on a smooth, non-combustible surface. Do not place
on rugs or carpeting.
•Do not leave heater unattended.
•Always unplug heater when not in use.
•Do not operate the heater with heater guards
or any safety device removed.
•Do not use an extension cord because the
extension cord may overheat and cause a risk of fire.
•Do not run power cord under carpeting. Do not
cover cord with throw rugs, runners or the like.
Arrange cord away from traffic area where it will not
be tripped over.
WARNING: SHOCK HAZARD
Use your heater only in dry environments. This heater is
not intended for use in a bathroom, laundry area, or
similar locations, or near sinks, washing machines,
swimming pools or other sources of water. Never locate
heater where it may fall into a bathtub or other water
container. Do not use heater outdoors. Do not use in
damp environments such as flooded basements.
WARNING: HOT SURFACES
Do not touch body of heater when in use. This heater is
hot when in use, to avoid burns, do not let bare skin
touch hot surfaces. If provided, use handles when
moving this heater.
WARNING: FIRE HAZARD
Heater has hot and arcing or sparking parts inside. Do
not use near combustible materials or flammable gases
or sources of heat. DO NOT USE in areas where
gasoline, paint or flammable materials are used or
stored. Keep combustible materials such as furniture,
pillows, bedding, papers, clothes and curtains at least 3
feet (0.9 m) from the front of the heater and keep them
away from the sides and rear. To prevent a possible fire,
do not block air intakes or exhaust in any manner. Do
not use on soft surfaces, like a bed, where openings
may become blocked. Do not place the heater near a
bed because objects such as pillows or blankets can
fall off the bed and be ignited by the heater. Do not
insert or allow foreign objects to enter any ventilation or
exhaust opening as this may cause an electric shock,
fire, or damage the heater
WARNING: ELECTRICAL SHOCK HAZARD
Do not use with damaged cord or plug. Use with
adequate electrical system that is up to code.
The supply cord has a polarized plug. As a safety
feature this plug will fit in a polarized outlet only one
way. To prevent electric shock, match wide blade of
plug to wide slot, fully insert plug. If the plug does not fit
contact a qualified electrician. Never use an extension
cord unless plug can be fully inserted. DO NOT attempt
to defeat this safety feature.
Do not operate any heater with a damaged cord or plug
or after heater malfunctions, has been dropped or
damaged in any manner. Do not operate heater with a
broken heating element or ceramic cone or any visual
imperfections. For repairs covered under warranty, see
warranty statement. For all other repairs contact Comfort
Zone's Customer Service by telephone or mail for
information and assistance.
DO NOT run power cord under carpeting. DO NOT cover
cord with throw rugs, runners or the like. Arrange cord
away from traffic area where it will not be tripped over.
Do not use an extension cords due to risk of fire. Unplug
the heater when not in use. Do not operate heater with
its ventilation obstructed.
Power
Control
Dial
Power
Indicator
Light
Thermostat
Control
Save These Instructions