645 Lemonwood Dr. Santa Paula, CA 93060 USA Toll Free: 1 (800) 253-2363 Tel: 1 (805) 933-9970 Fax: 1 (805) 933-9160 www.thecoolboss.com Cool Boss™ Portable Evaporative Air Cooler Installation and Operation Manual Revision B — March 2017 — P/N 5900140 Models: • CB-30L • CB-30H ⚠ DANGER Always operate this equipment as directed; failure to do so may cause injury or death. Read the entire contents of this manual prior to installation or operation. Make sure all other operators also read this manual.
Manual. Cool Boss Portable Evaporative Air Cooler, Installation and Operation Manual, P/N 5900140, Rev. B, March 2017. Designed and engineered by BendPak Inc. in the USA. Made in China. Copyright. Copyright © 2017 by BendPak Inc. All rights reserved. No part of this manual can be reproduced, adapted, translated, or transmitted by any means, electronic or mechanical, for any purpose or in any form, without prior written permission of BendPak Inc. Trademarks.
Table of Contents Introduction 3 Maintenance 8 Shipping Information 4 Troubleshooting 9 Safety Considerations 4 Specifications 9 System Components 5 Warranty 10 Setup 7 Wiring Diagram 10 Operation 8 Maintenance Log 11 Introduction This manual describes the CB-30 Cool Boss Portable Evaporative Air Cooler, which keeps your shop or workplace cool and comfortable on even the hottest summer days.
Shipping Information Your equipment was carefully checked before shipping. Nevertheless, you should thoroughly inspect the shipment before you sign to acknowledge that you received it. When you sign the bill of lading, it tells the carrier that the items on the invoice were received in good condition. To protect yourself, do not sign the bill of lading until after you have inspected the shipment.
Hazard Symbols Following are the hazard symbols used in this manual: ⚠ DANGER ⚠ WARNING ⚠ CAUTION Calls attention to an immediate hazard that will result in death or severe injury. Calls attention to a hazard or unsafe practice that could result in death or severe personal injury. Calls attention to a hazard or unsafe practice that could result in minor personal injury, product, or property damage.
The following figure shows the inside of the unit, from the back. The Control Panel The following figure shows the Control Panel. CB-30 Cool Boss Evaporative Air Cooler 6 P/N 5900140 — March 2017 — Rev.
The Remote The following figure shows the remote that comes with the unit (in the box with the casters). Setup To set up the CB-30: 1. Put on the casters. The casters come in a box with the remote. Two casters have brake locks. 2. Find a location. Find a suitable location for the unit. It should be inside, near an appropriate power source, and in a low-traffic and well-ventilated area. Never roll anything heavy over the power cord.
Operation To operate the CB-30: • • Press Power. You can press the power indicator on the Control Panel or the Power button on the remote; either way starts the fan. Check the Control Panel to see current settings. Press Cool. Starts the cooling function; the pump begins circulating water. Make sure there is water in the water tank before pressing Cool; if not, the water pump motor could burn out. • Press Speed. Select between High, Medium, and Low fan speeds.
Troubleshooting This section describes how to troubleshoot your product. Issue Probable Cause Action to Take Control Panel off. • No power. – Check the power supply. • Fuse not working. – Change fuse (250 V, 15 Amps). • Panel is not working – Change the panel. • No power. – Power cycle the unit. • Environmental issue. – Move the unit. Fan not working or moving slowly • Fan is stuck. – Check for blockage. • Fan is broken. – Repair fan. Motor not working • Master control not working.
Power consumption 550 Watts Cooling pad size (width by height by depth) 43.5" by 46" by 4" 1104 mm by 1168 mm by 101.6 mm Warranty The BendPak Cool Boss warranty is more than a commitment to you; it is also a commitment to the value of your new product. For full warranty details and to register your new product, contact your nearest BendPak dealer or visit www.thecoolboss.com/warranty. Wiring Diagram CB-30 Cool Boss Evaporative Air Cooler 10 P/N 5900140 — March 2017 — Rev.
Maintenance Log CB-30 Cool Boss Evaporative Air Cooler 11 P/N 5900140 — March 2017 — Rev.
1645 Lemonwood Drive Santa Paula, CA 93060 USA © 2017 BendPak Inc. All rights reserved. www.bendpak.