Surge Arresters Effective September 2013 Supersedes April 2013 S235-55-1 15, 25, and 35 kV class standard M.O.V.E. and POSI-BREAK™ M.O.V.E.
DISCLAIMER OF WARRANTIES AND LIMITATION OF LIABILITY The information, recommendations, descriptions and safety notations in this document are based on Eaton Corporation’s (“Eaton”) experience and judgment and may not cover all contingencies. If further information is required, an Eaton sales office should be consulted.
Contents safety information Safety Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . iv product information Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 Acceptance and Initial Inspection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
! Safety for life SAFETY FOR LIFE ! SAFETY FOR LIFE Eaton’s Cooper Power Systems products meet or exceed all applicable industry standards relating to product safety. We actively promote safe practices in the use and maintenance of our products through our service literature, instructional training programs, and the continuous efforts of all Eaton’s Cooper Power Systems employees involved in product design, manufacture, marketing, and service.
caution Pulling Eye High Voltage. Eaton's Cooper Power Systems M.O.V.E. Arrester is designed to be operated in accordance with normal safe operating procedures. These instructions are not intended to supersede or replace existing safety and operating procedures. The M.O.V.E. Arrester should be installed and serviced only by personnel familiar with good safety practices and the handling of high voltage electrical equipment.
Installation procedure Installation on an energized or de-energized system warning Application The M.O.V.E. Elbow Arrester should be installed only on systems where the power frequency voltage at the arrester does not exceed the maximum continuous operating voltage. (MCOV) values published. See Table 2. All Eaton's Cooper Power Systems M.O.V.E. Elbow Arresters must be installed or removed from an energized bushing with a clampstick. caution High Voltage.
WARNING The operator should always use personal protective equipment (insulated gloves, clampstick, and eye protection) whenever operating the elbow. The operator should always be in the best possible operating position, providing firm footing and enabling a secure grasp of the clampstick, while maintaining positive control of the elbow before, during, and immediately after operation. If there is any question regarding the operator's operating position, de-energize the elbow before operation.
! SAFETY FOR LIFE Eaton 1000 Eaton Boulevard Cleveland, OH 44122 United States Eaton.com Eaton’s Cooper Power Systems Business 2300 Badger Drive Waukesha, WI 53188 United States Cooperpower.com © 2013 Eaton All Rights Reserved Printed in USA Publication No. S235551 Rev 3 (Supersedes S235551Rev 2) Eaton, Cooper Power Systems, and POSIBREAK are valuable trademarks of Eaton, in the U.S. and other countries. You are not permitted to use these trademarks without the prior written consent of Eaton.