Installation Guide & User's Manual ISLAND MOUNT RANGE HOOD COS-668ICS SERIES This manual is made with 100 % recycled paper. Electronic version of this manual is available at: www.cosmoappliances.
Thank You Thank you for your purchase. We know that you have many brands and products to choose from and we are honored to know that you have decided to take one of our products into your home and hope that you enjoy it. Our appliances are designed according to the strictest safety and performance standard for the North American market. We follow the most advanced manufacturing philosophy. Each appliance leaves the factory after thorough quality inspection and testing.
STAINLESS STEEL BAFFLE FILTERS About Your New Filters Stainless Steel Baffle Filters do not need linings or mesh inside of the filters and are completely constructed out of stainless steel. The stainless steel construction allows them to be used again after being cleaned or going through the dishwasher. How do Baffle Filters Work? They function by forcing the grease filled air to quickly and continuously change direction as it passes through the filter.
IMPORTANT SAFETY INSTRUCTIONS Read all instructions before using this appliance. Save these instructions for future references Approved for residential appliances For residential use only CAUTION FOR GENERAL VENTILATING USE ONLY. DO NOT USE TO EXHAUST HAZARDOUS OR EXPLOSIVE MATERIALS OR VAPORS. CAUTION WARNING GROUNDING INSTRUCTIONS This appliance must be grounded.
TABLE OF CONTENTS PARTS DIAGRAM 05 INSTALLATION REQUIREMENTS 06 INSTALLATION PROCEDURES 07 DIMENSIONS 09 OPERATING INSTRUCTIONS 11 MAINTENANCE 12 TROUBLESHOOTING 13 14 WARRANTY AND SERVICE 4
PARTS DIAGRAM Ceiling Mount MAIN PARTS Inner Chimney Outer Chimney Upper Support Frame Lower Support Frame Vent pipe Blower Assembly Glass Stainless Steel Baffle Filters 5
INSTALLATION REQUIREMENTS 1. Do not install the range hood where there are many open doors or windows.This will cause reduced performance. (Fig. 1) 2. Install the range hood right above the cooktop. The optimal distance between the cooktop and lower edge of the range hood is 24” to 36”. (Fig. 2). Install at the height appropriate to your ceiling. Make sure the chimney can still reach the ceiling.
INSTALLATION PROCEDURES INSTALLATIO N PROCEDURES CAUTION: HOOD MAY HAVE VERY SHARP EDGES; PLEASE WEAR PROTECTIVE GLOVES WHENEVER IT IS NECESSARY TO REMOVE ANY PARTS FOR INSTALLING, CLEANING OR SERVICING. This Island Range Hood has an adjustable height. Measure from the ceiling to a height of 24” to 36” above your cooktop. Install at a height appropriate to your ceiling. Make sure the chimney can still reach the ceiling.
Step 4: Determine desired height of hood. Based on your measurements, connect upper support frame to lower support frame using 16 screws and nuts. 16 pcs screws 16 pcs nuts Inner Chimney Cover Outer Chimney Cover Step 5: Ceiling Mount Sllide the inner and outer chimney covers over the blower assembly box. Then pull the duct up to the level of the inner chimney cover.
Screws Step : Inner Chimney Cover Slide the Inner chimney cover up to the ceiling.Screw the inner chimney cover into the ceiling mount using the predrilled holes. DIMENSIONS 11 . 8 1 " .4" 25"-47.64" 12 2.95" 23.
RECIRCULATING CHARCOAL FILTERS Skip this page if you are installing a Ducted Range Hood. Charcoal Filters are only included with Ductless Models Installing Recirculating Filters (For Ductless Installation Only) 1. Remove the Baffle Filters 2. Locate the Motor 3. Place a Carbon Filter on one side of the motor and align with the clips. 4. Twist and Lock into Place. 5. Repeat steps 2-4 for the other side of the motor. 6. Place the Baffle Filters back into place. 7.
OPERATING INSTRUCTIONS Soft Touch Controls Timer setting: Press once to add 1 minute delay auto shut-off. The maximum is 59 minutes. Press once for high speed, twice for middle speed, and three times for low speed, and recycle. Press to turn on or turn off the light. When the motor is working, press one to enter into 1 minute delay auto shut-off mode. Press again to turn off the motor immediately. To set the clock: Touch and hold the timer setting symbol for approximately 3 seconds.
MAINTENANCE CAUTION : NEVER PUT YOUR HAND INSIDE OF THE UNIT WHILE ITS OPERATING . FOR THE BEST PERFORMANCE CLEAN YOUR RANGE HOOD REGULARLY . CLEANING 1. Use only mild soap or cleaning solutions to clean the range hoods outer surface. Dry surfaces using a soft cloth. 2. Stainless Steel cleaner may be used on the external surface. 3. Cleaning the Baffle Filters : For daily cleaning, use hot, soapy water and a soft cloth. Wipe dry and finish with a damp micro-fiber cloth.
TROUBLESHOOTING CAUTION:ALWAYS UNPLUG UNIT FROM POWER BEFORE SERVICING PROBLEM SOLUTION TOOLS My range hood is noisy. A. Check inside the range hood for any loose debris and remove. Phillips Screwdriver My range hood has poor performance.. A. The range hood and cooktop are too far away from each other. Optimal distance is 24” to 36” Phillips Screwdriver B. There are too many open windows or doors in the area. Close some doors or windows. C. The motor performance has decreased due to wear.
WARRANTY AND SERVICE For full warranty details or registering warranty on this product, please visit: www.cosmoappliances.