Installation Guide & User's Manual WALL MOUNT RANGE HOOD COS-63175 COS-63190 COS-63175S COS-63190S COS-668WRC75 COS-668WRC90 COS-668WRCS75 COS-668WRCS90 COS-668A750 COS-668A900 COS-668AS750 COS-668AS900 This manual is made with 100 % recycled paper. Electronic version of this manual is available at: www.cosmoappliances.
1
SEE PAGE 13 FOR INSTRUCTIONS ON INSTALLING FILTERS 2
burned. Always leave safety grills and filters in place. Without these components, operating blowers could catch onto hair, fingers and loose clothing. The manufacturer declines all responsibility in the event of failure to observe the instructions given here for installation, maintenance and suitable use of the product. The manufacturer further declines all responsibility for injury due to negligence and the warranty of the unit automatically expires due to improper maintenance.
SAFETY INSTRUCTIONS _______________________________________ 3 PARTS DIAGRAM ___________________________________________ 5-6 INSTALLATION REQUIREMENTS ________________________________ 7 PARTS LIST _________________________________________________ 8 RANGE HOOD INSTALLATION _______________________________ 9-11 BAFFLE FILTER INSTALLATION ________________________________ 12 DUCTLESS CONVERSION FILTERS _____________________________ 13 INSTALLING THE OIL CUP _____________________________________ 14 PUSH BUTTON C
1" 21.5"-39.2" 12.8" (Units with Glass Visor) 11. 7" 12.5" 13.6" 7" 18.5 " 1. Top Chimney (Inner Chimney) A 2. Bottom Chimney (Outer Chimney) B 3. Exhaust Pipe 4. Core Unit 5. Tempered Glass C 5 6.
6.81" 6.7 5" 25.6"-39.4" 8.25" 11.18" 6.89" 19 .75 " 1. Top Chimney (Inner Chimney) A 2. Bottom Chimney (Outer Chimney) B 3. Exhaust Pipe 4. Core Unit C 5.
24"-36" 1. Do not install the range hood near open doors and windows to avoid reduced performance. (Fig.1) 2. Install the range hood directly above the cooktop. The optimal distance between the cooktop and lower edge of the range hood is 24" to 36". (Fig.2) Install at the height appropriate to your ceiling. Make sure the chimney reaches the ceiling. If your ceiling leaves the hood a few inches higher or lower than 24" to 36" you can still install it without a major loss of performance. 3.
(outer chimney) E. (inner chimney) H. G A. 11 pcs 2/8" x 1 3/8" Plastic Anchors B. 11 pcs 1/8" x 1 7/8" Screws (48mm) C. 4 pcs 1/8" x 3/8" Screws (35mm) D. Core Unit Bracket (Main Body) E. Outer Chimney Cover Bracket F. 6 in. Round Aluminum Duct G. Oil Cup H. Inner Chimney Cover Bracket Note: Hardware, number of screws, anchors and accessories will vary based on product model.
WALL MOUNT RANGE HOOD INSTALLATION Preparing Your Wall / Mounting Instructions Place the range hood on the wall and mark the position where you want to install. A height of 24" to 36" from the cooktop is recommended for optimal performance. Install at the height appropriate for your ceiling. You may install higher if needed. Make sure the chimney can still reach the ceiling.
Locate the 6" round aluminum duct (F) and attach it to the top air outlet on the main body of the range hood with HVAC foil tape (not included). Make sure it is connected tightly. Place the bottom of Outer Chimney into Core Body's seating located near vent hole. Then Insert the Inner Chimney cover into the Outer Chimney Cover. Note that the Inner Chimney cover must slide into the Outer Chimney cover's orientation slot.
Extend the 6" Duct to the vent pipe of your building or outside. For optimal performance try to minimize bending of the duct. Mount outer chimney bracket (E) to the wall appropriate to the height of the outer chimney. Use the hooks on bracket to mount bottom chimney. Extend Inner Chimney until it touches the ceiling. Align sides with Inner Chimney Mounting Bracket (H)(already mounted to wall) and firmly screw sides of Inner Chimney to bracket with 3/8" screws (C in parts list).
Press Button in and down 12
Press the center of the filter firmly. While pressing firmly twist and lock into place.
14
15
COS-668WRCS75, COS-668WRCS90 COS-668AS750, COS-668AS900 COS-63175S , COS-63190S Note: When Fan is ON + or - will increase or decrease fan speed.
17
My range hood is noisy A. Check inside the range hood for any loose debris and remove. If your range hood is still noisy after checking, please call 1-888-784-3108. My range hood has poor performance A. The range hood and cooktop are too far away from each other. Optimal distance is 24" to 36" B. There are too many open windows or doors in the area. Close some doors or windows. C. The motor performance has decreased due to wear. Replace motor. D.
19