INSPIRING THE WORLD’S KITCHEN PROFESSIONAL GAS RANGE COS-EPGR304 IMPORTANT SAFETY INSTRUCTIONS Carefully read the following Important information regarding installation safety and maintenance. Keep these instruction for future reference.
Table of Contents THANK YOU FOR YOUR PURCHASE. Thank you for your purchase. We know that you have many brands and products to choose from and we are honored to know that you have decided to take one of our products into your home and hope that you enjoy it. SAFETY AND WARNINGS ...........................................................5-9 OTHER SAFETY TIPS .................................................................................10-11 GAS SUPPLY REQUIREMENTS ........................................
Safety & Warnings Table of Contents DEFROSTING .......................................................................................................28 CONVECTION DEHYDRATION ............................................................................28 WARNINGS These are the most critical warnings summarized below. BROILER OPERATION...................................................................29 PREHEATING ............................................................................................
Safety & Warnings Safety & Warnings Before You Start ✓ Make sure that the anti-tip device of the range has been properly installed. ✓ Find the model and serial numbers on the CSA label in the bottom righthand corner of the backboard. Write these numbers down for future reference and keep it with this manual. ✓ Read this guide, taking special note of the "Safety and Warnings" section. ✓ Remove all the packaging from the oven(s) and cooktop. Recycle items that you can.
Safety & Warnings Safety & Warnings Explosion Hazard Poisoning Hazard ✓ If you smell gas, do not use the appliance. Open a window or door to let the gas escape, then follow the instructions on the inside front cover of this manual. ✓ Do not use water on grease fires. A violent steam explosion may result. ✓ Turn all burners off, then smother fire or flame with a dry chemical or foam-type extinguisher. Do not try to smother with flammable blankets. ✓ Do not heat unopened food containers such as cans.
Safety & Warnings Safety & Warnings Other Safety Tips ✓ Read instructions before use: Read all the instructions ✓ Protect oven gasket: Do not clean the oven gasket before using the appliance. Use the appliance only for its intended purpose as described in these instructions. or use any oven-cleaning products on it. It is essential for a good seal, which ensures that the oven operates efficiently. Care should be taken not to rub, damage or move it.
Dimension & Clearance Dimension & Clearance WARNING Gas Supply Requirements Installation of this range must conform with local codes, or in the absence of local codes, with the national Fuel Gas Code ANSIZ223.1 / NFPA 54. ✓ The appliance cannot be used for space heating. This information is based on safety considerations. In Canada, installation must conform to the current natural Gas Installation / code, CAN 1-1.1-M81 and with local codes where applicable.
Dimension & Clearance Dimension & Clearance BTU Design The maximum depth of cabinets installed above cooking tops must be 13 in. (330mm).
Dimension & Clearance Dimension & Clearance Top Hood and Cabinet Specifications Condition 30” Gas Range Clearance Clearance between the top of the cooking surface and the bottom of an unprotected wood or metal cabinet for any model other than EPGR486G (NOTE: This will apply to most installations).
Dimension & Clearance Dimension & Clearance Overlay Overlay Overlay Electric Power Supply Requirements Your range must be electrically grounded in accordance with local codes or, in the absence of local codes, in accordance with the National Electrical Code (ANSI/NFPA 70, latest edition). In Canada, electrical grounding must be in accordance with the current CSA C22.1 Canadian Electrical Code Part 1 and/or local codes.
Connect Range to Gas Supply Connect Range to Gas Supply Electrical Grounding Instructions WARNING 1. Install male 1/2” or 3/4” (3/4” for 48 inch gas range only) flare union adapter to the NPT internal thread of the manual shut-off valve, taking care to secure the shut-off valve to keep it from turning. This indoor gas cooking appliance is equipped with a three-prong (grounding) plug for your protection against shock hazard and should be plugged directly into a properly grounded three pronged receptacle.
Cooktop Safety Guidelines Cooktop Safety Guidelines ✓ Keep handles out of the way. Turn handles so that they don’t extend over the edge of the range or on a burner that is on. First Use Conditioning the oven Conditioning will burn off any manufacturing residues and ensure that you get the best results right from the start. Follow these steps to condition your new stove’s oven: 1. Insert all the shelves. a.
Cooktop Safety Guidelines Oven Burner Use / Oven Safety Guidelines NOTE: When one burner is turned to the “HI” position, the burner igniters will spark. Do not attempt to disassemble or clean around any burner while another burner is on. Do not touch any burner cap, burner base, or igniter while the igniters are sparking. Oven burner use Simmer and Boil A smaller flame will give the best simmer results.
Oven Functions Oven Safety Guidelines ✓ Do not place water, ice, or any dish or tray directly on the oven floor, as this will irreversibly damage the enamel. ✓ Do not cover the slotted grid of the broil/roast pan with aluminum foil. This will catch the grease and could cause fire. ✓ Do not use plastic wrap or wax paper in the oven. ✓ For food safety reasons, do not leave food in the oven for longer than two hours before and after cooking or defrosting.
Oven Functions Broiler Operation Convection Roast Broiler Operation For best results use the broiler pan. The pan is used to catch grease spills and has a cover to prevent grease splatter. Note: Door must be closed during broiler operation. The convection fan circulates heated air around the food being roasted, sealing juices quickly for a moist and tender product while, at the same time, creating a rich goldenbrown exterior.
Cleaning Instructions Broiler Operation To set the oven to Broil: Cleaning Instructions 1. Place the broiler pan insert on the broiler pan. Then place the food on the broiler pan insert. Do’s 2. Arrange the interior oven rack and place the broiler pan on the rack. Be sure to center the broiler pan and position directly under the broil burner. If preheating the broil burner first, position the broiler pan after the broil burner is preheated. 3. Turn selector knob to Broil.
Cleaning Instructions Cleaning Instructions Cleaning the cooktop Cleaning bake and broil burners 1. Before cleaning the cooktop, ensure that all burners are turned off and that all components are cool enough to safely touch 1. Do not clean these parts. They self-clean during normal use. 2. To avoid electrical shock or burns, turn off controls and ensure the cooktop is cool before cleaning. 3.
Removing the Oven Door Removing the Oven Door Removing and replacing the oven door Replacing the oven door Do not lift the oven door by its handle. Doing so may damage the door. 1.) Hold the door firmly in an approximately open position. Make sure the oven and the door are cool before you begin to remove the door. 2.) Insert the hinge tongues into the slots, making sure that the notches on both sides drop into place, as shown.
Oven Knob Installation Oven Knob Installation 1. Check the design 2. Check the quantity of knobs • Big Oven Thermostat Knob: 1 pc • Surface Valve Knobs: 5 pcs *For any damaged or missing parts, please contact: Cosmo Customer Support +1-888-784-3108. ①Big Oven Thermostat Knob ②Griddle/Small Oven Thermostat Knob 3. Find the right knob for each shaft on the range. Push the knob in to fully attach the shaft and make sure there’s no friction between knobs and bezels.
Oven Knob Installation Oven Handle Installation 1.) Check your installation kit for door handles. EPGR304 • Handle (For 18”, 30” or 36” Oven): 1 pcs ①②③④⑤⑥ • Door handle holder: 2 pcs • Installation Wrench: 1 pc EPGR304 (From Left to Right): ①: Big Oven Thermostat Knob 2.) Connect door handle holders to each side of the handle. ② ③ ④ ⑤ ⑥: Surface Valve Knob Your range may have a handle that needs to be installed. Please use the following procedures for oven door handle installation. 3.
Rubber Pad Installation on Back Panel Oven Handle Installation In order to meet the clearance requirement for the back of your range, please install the two (2) rubber pads included in your installation kit, using the following instructions: 1.) Check your installation kit for the rubber pads. • Screws: 2 pcs • Rubber pad: 2 pcs 4.) Use the wrench to tighten the door handle holders. 2.) Install the two (2) rubber pads as shown above. 5.) Check if the oven door handle is level and stable.
Troubleshooting Guide - Cooktop If you are unable to solve an issue even after referring to the Troubleshooting section of this manual, or if the issue cannot be fixed, please contact Cosmo Customer Support at: 1-888-784-3108. Problem Probable causes Solution Some burners will not light. Burner parts or igniters may be wet, dirty or misaligned. Check that the burner parts are clean, dry, and correctly assembled. Check that the igniters are clean and dry. See "Cleaning instructions", Pages 3132.
Troubleshooting Guide - Oven Troubleshooting Guide - Oven Oven will not heat. Problem The oven doesn’t work (No heating). Probable causes • No power supply (Oven light and halos are non-operational as well). • No gas supply (Gas ovens). One of the oven lights does not come on, but the oven works. The light bulb is loose, or has blown. Solution • Check that the circuit breaker hasn’t tripped and there is no power outage in your area.
IMPORTANT Do Not Return This Product To The Store If you have a problem with this product, please contact Cosmo Customer Support at +1(888)784-3108 DATED PROOF OF PURCHASE, MODEL #, AND SERIAL # REQUIRED FOR WARRANTY SERVICE IMPORTANT Ne pas Réexpédier ce Produit au Magasin Pour tout problème concernant ce produit, veuillez contacter le service des consommateurs Cosmo Customer Support au +1(888) 784-3108 UNE PREUVE D’ACHAT DATEE EST REQUISE POUR BENEFICIER DE LA GARANTIE.
Cosmo is constantly making efforts to improve the quality and performance of our products, so we may make changes to our appliances without updating this manual. Electronic version of this manual is available at: www.cosmoappliances.
