Product Specifications

MODEL
Output
BatteryType
CX1215
CX1225 CX1235 CX1250
CX1280
Input
Protection
OverVoltage
Environment
WorkingTemp.
WorkingHumidity
StorageTemp.,Humidity
Temp.Coefficient
Vibration
-20~50°C(refertode-ratingcurve)
20~90%RHnon-condensing
-40~+85 ,20~90%RH°C
±0.03%(0~50°C)
10~500Hz,2G10min./1cycleperiodfor60min.eachalongX, Y,Zaxes
Safety& EMC
IsolationResistance
EMCStandards
WithstandVoltage
I/P-O/P:4242VDC,I/P-FG:1768VDC,O/P-FG:700VDC
I/P-O/P:100MOhms/500VDC
Others
Packing
1.6kg 1.7kg 1.9kg 3.1kg 4.0kg
Dimension (WxHxD)
183x72x mm243 183x72x243mm 183x72x263mm 213x77x272mm 213x77x312mm
Note
CertifiedEN55022;EN61204-3;EN55014-1
CertifiedEN55024;IEC61000-4-2,3,4,5,6,8,11;ENV50204;EN61000-6-1;EN55014-2
CertifiedEN61000-3-2,-3-3;EN61204-3;EN61000-6-3
Lead Acid/ Gel/ AGMLi-ion/
StandardBoostChargeVoltage
Standard FloatChargeVoltage
14.4V/14.7V(SelectbyS1-1)
13.8V/13.5V (SelectbyS1-2)
MainRatedCurrent
CurrentRange
MainOutput
BatteryChargingMode
15A 25A 35A 50A 80A
0~15A 0~25A
0~35A
0~50A 0~80A
1 2
2 3
3
3-stagechargingcapability(IUOU)
VoltageRange
PowerFactor(Typ.)
FrequencyRange
ACCurrent(Typ.)
LeakageCurrent
Efficiency(Typ.)at230VAC
90~264VAC (refertode-ratingcurve)
PF>0.92atfullload
47~63Hz
87% 87% 87%
87%
87%
2.5 A /100VAC
1.07A /240VAC
4.1 A /100VAC
1.8A /240VAC
6.2 A /100VAC
2.8A /240VAC
8.24 A /100VAC
3.6A /240VAC
13.3 A /100VAC
5.4A /240VAC
Forearth<1mA /240VAC
ShortCircuit
OverTemperature
Currentisreducedto<1A continued30sec.,fanwilloperate30secondsthenturnoff
17.5V 1%,± Protectiontype:Shutdownoutput(recoveryafterresetting ACpoweron)
Charger 100±5°CdetectedbyheatsinkOver Temperature
BatteryOver Temperature 52±5°C(Optionaldevice-COTEKtemperaturesensor),connectonCN3
Function
AlarmSignal
NC./NO.Relaycontactoutput( )Pleaserefertopage5 AlarmsSignal&FanControl
TemperatureCompensation
ChargingSleepMode
By andS1-4DIP switch( )RemoteController Pleaserefertopage4~5
-10mV/0.5°CwithCOTEKtemperaturesensor
1. Allparametersnotspeciallymentionedaremeasuredat230VACinput,ratedloadand25 ofambienttemperature.
2. Thechargerisconsideredacomponentwhichwillbeinstalledintoafinalequipment. Thefinalequipmentmustbere-confirmedthatitstillmeetsEMC
directives.
3.Beforecharging,makesurethebatterychargerandbatteryspecifications compatible.
4.Whenusingsleepmode, refertocharging
5.
°C
are
please currentvs. Ambienttemperaturede-ratingcurve.
OptionalRemoteController(CR-1).
SingleOutputCurrentLimit
15A 25A 35A 40A 40A
Note.4
Remote Controller
SupportCOTEKRemoteControllerCR-1settingFunction(CN3orCN4)
ESBOutput
1 1
1
ESBOutputVoltage/Current
13.8V/2A 13.8V/2A
1
13.8V/2A
— —
— —
SafetyStandards
CertifiedEN60335-1,EN60335-2-29
Note.2
Protectiontype: Autorecoveryafterheatsinktemperaturegoesdownto50°C
AdvancedBatteryCharger
CX12xx
CompatiblewithLead Acid,Li-ion,Geland AGMbatteries
Universal ACinputwithactivePFC
Voltage/temperaturecompensationwithbatterytemp.sensor(Optional)
Drycontactforalarm
2-stagefanspeedcontrol
Highefficiencyandhighreliability
Protection:ShortCircuit/OverVoltage/OverTemperature/ Brown-out
Built-inbatteryrescuefunction
Built-inEngineStartBattery(ESB)outputfunction
Features:
Withstand2Gvibrationtest
Support optionalremotecontroller(CR-1)
Note.5
PowerMode
Supply13.2V Currentlimitoutputvoltage
RS-232communicationinterface
OutputpowerOKsignal
REV. A9
1
16/04/15