Coyote Stainless Steel Gas Grill Use & Care Manual For Liquid Propane and Natural Gas Models Coyote 28” Grill Free-Standing & Built-In C1C28LP-FS / C1C28NG-FS Free-Standing Conforms to ANSI STD Z21.58-2015 Certified to CSA STD 1.6-2015 Outdoor Cooking Gas Appliance C1C28LP / C1C28NG Built-In FOR OUTDOOR USE ONLY PUT SERIES NO.
Welcome & Congratulations Congratulations on your purchase of a new grill! We are very proud of our product and we are completely committed to providing you with the best service possible. Your satisfaction is our #1 priority. Please read this manual carefully to understand all the instructions about how to install, operate and maintain your grill for your safety and for optimum performance and longevity. We know you’ll enjoy your new grill and thank you for choosing our product.
Table of Contents & Critical Safety Warnings Safety Instructions…. ......................... 3 Limited Warranty…………………………….5 Grill Models....................................... 7 Locating the Grill............................... 8 Gas Requirements ………………………….12 Liquid Propane Gas Supply………..12 Natural Gas Supply.......................16 Connecting Electrical Transformer…..18 Operation of your Grill...................…..19 Lighting Your Grill ………………………….20 Using Your Burners & Grilling Safely………………………………....
Important Warnings and Safety Instructions Improper installation, adjustment, alteration, service, maintenance or use can cause injury or property damage. Read the installation, operating and maintenance instructions thoroughly before installation or servicing of this equipment. General Safety Instructions 1. 2. 3. 4. 5. 6. 7. 8. 9. 10. 11. 12. 13. 14. 15. 16. 17. For Outdoor Use Only.
18. 19. 20. 21. 22. 23. 24. 25. 26. 27. 28. 29. 30. occurs, turn off the fuel supply immediately. After the grill has cooled, determine the cause of the dripping and correct it. After cleaning the valve, hose and regulator, perform a soapy water leak test before continuing use. If a leak is discovered, call a qualified technician for service. NEVER heat any unopened glass or metal container of food on the grill.
Limited Warranty TO THE MAXIMUM EXTENT PERMITTED BY LAW, THIS LIMITED WARRANTY AND THE REMEDIES SET FORTH BELOW ARE EXCLUSIVE AND IN LIEU OF ALL OTHER WARRANTIES, REMEDIES AND CONDITIONS, WHETHER ORAL OR WRITTEN, EXPRESS OR IMPLIED. TO THE MAXIMUM EXTENT PERMITTED BY LAW, COYOTE OUTDOOR LIVING, INC. ALSO SPECIFICALLY DISCLAIMS ANY AND ALL IMPLIED WARRANTIES, INCLUDING, WITHOUT LIMITATION, WARRANTIES OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE. Coyote Outdoor Living, Inc.
defective, Coyote Outdoor may approve your claim and elect to replace such parts without charge. In every instance, the customer is responsible for shipping and handling of replacement parts. Component repair or replacement is the exclusive remedy under this limited warranty and Coyote Outdoor shall not be liable for any incidental or consequential damages.
Grill Models C1C28LP-FS / C1C28NG-FS Free-Standing C1C28LP / C1C28NG Built-In Model No.
Locating the Grill Check your local building codes for the proper method of installation. In the absence of local codes, this unit should be installed in accordance with the National Fuel Gas Code No. Z223.1-1998 USA or CAN/CGA-B149.1/.2 Natural Gas/Propane Code (Canada) latest edition or the National Electrical Code ANSI/NFPA No. 70 or the Canadian Electrical Code CSA C22.1, 1990 or latest version.
• or other outdoor structure. This can cause the control panel and knobs to get hot to the touch and possibly even burn your fingers, not to mention that it can melt all rubber gaskets on the valves and damage the ignition system to where it will need full replacement. Ventilation and typical wind direction and conditions must always be considered when planning your outdoor cooking island.
• • A minimum of two ventilation holes in the enclosure, of at least 20 sq. inches in size (per vent), must be present to help release any leaking gas from the enclosure. As Propane is heavier than air, for propane grills locate your vents at the tank valve height or lower As Natural Gas is lighter than air, for natural gas grills locate your vents at the gas connection height or higher The counter should be flat and level relative to the floor.
Cut out Dimensions Figure A Vent Width Depth Vent Height Vent Vent Minimum of 2 vents, but optimally 4 vents, per cabinet that has any sort of gas supply or connection. Each vent must be at least 20 sq in in size and have access to outside/fresh air. Two vents on each side will facilitate and improve airflow and ventilation.
Gas Requirements NOTE: Coyote strongly recommends that a qualified service technician perform the initial installation and all conversions or modifications to the gas supply. Never attach an unregulated gas line to the appliance. Connection to an unregulated gas line can cause excessive heat or fire and the risk of property damage, bodily injury, or death. IMPORTANT: Before connecting grill to gas source, make sure grill control knobs are in the “OFF” position.
• • • • • • • • in pools and low areas. In its natural state, propane has no odor. For your safety, an odorant typically is added. ALWAYS purchase or refill your propane tanks from a reputable propane gas supplier. Contact with propane can cause freeze burns to the skin. NEVER use a propane cylinder with a damaged body, valve, collar or footing. A dented or rusted propane cylinder may be hazardous. Always keep LP cylinder securely fastened in an upright position.
The system has a flow limiting device which, when activated, will limit the flow of gas to 10 cubic feet per hour. NEVER use grill without leak testing this connection. • • LP (Propane) Gas Supply Connection 1. The tank valve should be in the “OFF” position. If not, turn the knob clockwise until it stops. 2. Make sure all burner valves are in the “OFF” position. 3.
proceeding by calling the Coyote Customer Service line at 855-520-1559. 7. If no rushing sound, brush soapy solution onto areas where bubbles are shown in LP tank (see picture). 8. If “growing” bubbles appear, there is a leak. Close LP tank valve immediately and retighten connections. If leaks cannot be stopped, do not try to repair the regulator, or tank valve, by yourself and contact the Coyote Customer Service line at 855-520-1559. 9.
Large Capacity Propane Tanks and Homes: • If your entire house is plumbed for propane gas use, and you have an exterior connection for such use, then a standard LP grill from Coyote can be connected to such outdoor propane connection, but you must be aware of the following: o Coyote does not supply any gas fittings or lines, other than the regulator needed within the grill box o All Coyote LP Grills come with a 20lb tank regulator. This regulator cannot be used or modified to work on any other setup.
3. 4. 5. 6. Mix a solution of equal parts mild detergent or liquid soap and water. Turn all grill control knobs to OFF. Ensure that the connections from the regulator to the grill and tank are tight and secure. Completely open the shut-off valve. If you hear a rushing sound, turn gas off immediately. There is a major leak at the connection. Correct before proceeding by calling the Coyote Customer Service line at 855-520-1559. 7. If no rushing sound, brush soapy solution onto all connection points. 8.
3. 4. 5. 6. 7. 8. 9. 10. a. You will find these locking pins at the back of the unit. If built in to an island, you can slide the grill forward and reach these pins. If the grill is located in a cart, then you ca simply reach through the opening in the back and remove the pins. Remove all of the burners from the grill Using a 6mm nut driver, remove the orifice at the end of each valve Locate the new orifices from the conversion kit and apply pipe thread sealant to the threads on each orifice.
Operating the Grill • Failure to open the lid prior to igniting the barbecue’s burners, or not waiting 5 minutes to allow the gas to clear if the barbecue does not light, may result in an explosive flame-up which can cause serious bodily injury or death. • • • NEVER use the grill if gas odor is present. NEVER stand with head, body, or arms over the grill when lighting. ALWAYS inspect the hose before using the grill.
Lighting Instructions for your Gas Grill Using the Grill’s Built-In Ignition System: 1. Open the canopy. 2. Keep your body, arms and face as far away from the burners and cooking surface as possible. Never stand with your head directly over the Grill when preparing to light the grill, to prevent possible bodily injury. 3. Select the burner that you want to ignite. Depress and rotate the knob corresponding to that burner counter-clockwise to the "High" position. a.
Using Your Burners and Grilling Safely Your grill is designed to reach a temperature that you set by adjusting a valve that in turn adjusts the amount of gas that goes through each burner. This valve is located behind your knob and is the key to your heat and fuel consumption. Furthermore, the way to ignite the burners is through the valves, so please understand the importance of the valves/knobs and the position/care taken with respect to them.
Be sure to engage in safe food handling and preparation. Coyote is not responsible for any injury or illness resulting from either under-cooking or over-cooking of meats, poultry, or other food. Preparing Food for the Grill Always observe safe food-handling and safe food-preparation practices when using this Grill, to prevent food-borne illnesses. • • • • • • Always cook foods adequately. Undercooked foods can retain bacteria, especially if thawed or exposed to warm conditions prior to cooking.
Care & Maintenance All cleaning and maintenance should be done only when grill is cool & with the fuel supply turned off at the cylinder or source. DRIP TRAY The drip tray located below the grill should be cleaned periodically to prevent buildup of debris. NOTE: Allow the drip tray to cool before attempting to clean. IMPORTANT: Do not leave the grill outside during inclement weather unless it is covered (cover sold separately).
Stainless Steel Care and Maintenance It is a common misconception that stainless steel will maintain its original factory shine with little help from the consumer. Unfortunately, this is not true. Stainless steel will not stain, discolor, corrode or rust as fast as other types of steel, but it is not fully stain or weather proof. If it is not properly maintained, all grades of stainless steel can face surface discoloration, corrosion and eventually rust.
Ways to Avoid Rust on your Grill: 1. Purchase a Coyote Grill cover for your unit. This will ensure that your cover is a correct fit and breathable, while providing the protection needed to keep contaminants off of the surface. 2. When installing the unit, make sure to keep the unit covered when any masonry work is being performed. If any mortar or dust does come into contact with the stainless, make sure to wipe it off as soon as possible and use a stainless steel polish immediately afterward. 3.
9. Reconnect to gas source and observe burner flame for correct operation. IMPORTANT: You should NOT line the bottom of the grill housing with aluminum foil, sand or any other grease absorbent substance. Grease will not be able to drip into the drip tray and a grease fire may occur. MAINTENANCE GUIDELINES 1. Keep outdoor cooking gas appliance area clear and free from combustible materials, gasoline and other flammable vapors and liquids. 2. Do not obstruct the flow of combustion and ventilation air. 3.
TROUBLESHOOTING If the grill does not function properly, use the chart below to assist in diagnosing the problem. Troubleshooting is for general purposes only. ALWAYS ERR ON THE SIDE OF SAFETY. If the problem still exists, contact our Coyote Customer Service line at 855-520-1559. Problem: Possible Causes and Solutions: Grill will not light when the igniter • Is your gas supply turned on? button is pushed. • If this is an L.P. grill, is there gas in your tank? Check your gas level.
Fire at any connection. an adjustable wrench and replace damaged parts. Perform a leak test on all connections before cooking on grill again. • Venturi may be misaligned and needs to be lined up over orifice. • If you cannot find the reason, call Customer Service at 855-520-1559 for assistance. IMMEDIATELY shut off cylinder valve and allow grill to cool. • Gas is leaking from a faulty connection. Tighten connections with an adjustable wrench and replace damaged parts.
Parts List Coyote C1C28 Cart 29
Coyote C1C28 LP/NG 30
C1C28 (LP & NG) Parts Listing Cart Picture # Description Grill Part Number Picture # C1C280001 15 Description 1 Side Shelf Holder 2 Top Rear Panel C1C280002 16 Thermometer C1C280016 3 Side Plate C1C280003 17 Hood Handle C1C280017 4 Partition Panel C1C280004 18 Handle Holder C1C280018 5 Top Rail C1C280005 19 Cooking Grate C1C280019 6 Side Shelf C1C280006 20 Lower Hood C1C280020 7 Transformer Box C1C280007 21 Wiring Harness for Lights C1C280021 8 Handle C1C280008
