Manual

10
- Thesystemhasathermalelementthatwillshutofftheflowofgasintheeventofafire.
- Thesystemhasaflowlimitingdevicewhich,whenactivated,willlimittheflowofgasto10cubicfeetper
hour.
- NEVERusesideburnerwithoutleaktestingthisconnection.
LP(Propane)GasSupplyConnection
1. The tank valve should be in the “OFF” position. If not, turn the knob
clockwiseuntilitstops. 
2. Makesureallburnervalvesareinthe“OFF”position. 
3. Alwaysconnectthegassupplyregulatorasfollows: 
Inserttheregulatorinletintothetankvalveandturnthecoupling nut
clockwiseuntilthecouplertightensup(seepicture).Donotover‐tightenthe
coupler.Turnthemaintankvalveon,andturntheburnercontrolvalveson
theunittothe“HIGH”positionforabout20secondstoallowtheairinthe
systemtopurgebeforeattemptingtolighttheburners. 
Pre‐OperationLeakTesting

1. Donotinsertanytoolintothevalveoutletorsafetyreliefvalve.Youmaydamagethevalveandcausea
leak.Leakingpropanemayresultinexplosion,fire,severepersonalinjury,ordeath. 
2. Ifaleakisdetectedatanytime,oryoucannotstopagasleak,immediatelyclosethetank’sshut‐offvalve
(gassupplyfromLPtanktotheSideburner)andcallLPgassupplieroryourfiredepartment! 
3. Checkallgassupplyfittingsbeforeeachuseandeachtimethegassupplycylinderisconnectedtothe
regulator.Haveaqualifiedservicetechnicianleaktestthesideburneranytimeapartofthegassystemis
replaced.

Neverattempttoattachthissideburnertotheself‐containedLPgassystem.Donotusethesideburneruntil
leaktestinghasbeencompleted.

LeakTestingValves,HoseandRegulator
1.  NEVERsmokewhileleaktesting.
2. Extinguishallopenflames.Neverleaktestwithan
openflame. 
3. Mixasolutionofequalpartsmilddetergentorliquid
soapandwater. 
4. TurnallsideburnercontrolknobstoOFF.
5. Ensurethattheconnectionsfromtheregulatortothe
side burner and tank are tight and secure (see
picture). 
6. Completely open LP tank valve by turning cylinder