Coyote Stainless Steel Gas Grill Use & Care Manual For Liquid Propane and Natural Gas Models C-Series 34" - C2C34 S-Series 30" - C2SL30 S-Series 30" - C2SL30-FS C-Series 36" - C2C36 C-Series 42" - C2C42 S-Series 36" - C2SL36 S-Series 42" - C2SL42 Conforms to ANSI STD Z21.58-2015 Certified to CSA STD 1.6-2015 Outdoor Cooking Gas Appliance FOR OUTDOOR USE ONLY PUT SERIES NO.
Welcome & Congratulations Congratulations on your purchase of a new grill! We are very proud of our product and we are completely committed to providing you with the best service possible. Your satisfaction is our #1 priority. Please read this manual carefully to understand all the instructions about how to install, operate and maintain your grill for your safety and for optimum performance and longevity. We know you’ll enjoy your new grill and thank you for choosing our product.
Table of Contents & Critical Safety Warnings Safety Instructions…. ......................... 3 Limited Warranty…………………………….5 Grill Models....................................... 7 Locating the Grill............................... 8 Gas Requirements ………………………….12 Liquid Propane Gas Supply………..12 Natural Gas Supply.......................16 Connecting Electrical Transformer…..18 Operation of your Grill...................…..19 Lighting Your Grill ………………………….20 Using Your Burners & Grilling Safely………………………………....
Important Warnings and Safety Instructions Improper installation, adjustment, alteration, service, maintenance or use can cause injury or property damage. Read the installation, operating and maintenance instructions thoroughly before installation or servicing of this equipment. General Safety Instructions 1. 2. 3. 4. 5. 6. 7. 8. 9. 10. 11. 12. 13. 14. 15. 16. 17. For Outdoor Use Only.
18. 19. 20. 21. 22. 23. 24. 25. 26. 27. 28. 29. 30. occurs, turn off the fuel supply immediately. After the grill has cooled, determine the cause of the dripping and correct it. After cleaning the valve, hose and regulator, perform a soapy water leak test before continuing use. If a leak is discovered, call a qualified technician for service. NEVER heat any unopened glass or metal container of food on the grill.
Limited Warranty TO THE MAXIMUM EXTENT PERMITTED BY LAW, THIS LIMITED WARRANTY AND THE REMEDIES SET FORTH BELOW ARE EXCLUSIVE AND IN LIEU OF ALL OTHER WARRANTIES, REMEDIES AND CONDITIONS, WHETHER ORAL OR WRITTEN, EXPRESS OR IMPLIED. TO THE MAXIMUM EXTENT PERMITTED BY LAW, COYOTE OUTDOOR LIVING, INC. ALSO SPECIFICALLY DISCLAIMS ANY AND ALL IMPLIED WARRANTIES, INCLUDING, WITHOUT LIMITATION, WARRANTIES OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE. Coyote Outdoor Living, Inc.
defective, Coyote Outdoor may approve your claim and elect to replace such parts without charge. In every instance, the customer is responsible for shipping and handling of replacement parts. Component repair or replacement is the exclusive remedy under this limited warranty and Coyote Outdoor shall not be liable for any incidental or consequential damages.
Grill Models Whether you are in need of a slimmer 3 Burner grill for your patio, or are in need of a larger 42” grill that can entertain and bring style to any size party, Coyote has the grill for you! C-Series 34" - C2C34 S-Series 30" - C2SL30 S-Series 30" - C2SL30-FS C-Series 36" - C2C36 S-Series 36" - C2SL36 C-Series 42" - C2C42 S-Series 42" - C2SL42 Model No.
Locating the Grill Check your local building codes for the proper method of installation. In the absence of local codes, this unit should be installed in accordance with the National Fuel Gas Code No. Z223.1-1998 USA or CAN/CGA-B149.1/.2 Natural Gas/Propane Code (Canada) latest edition or the National Electrical Code ANSI/NFPA No. 70 or the Canadian Electrical Code CSA C22.1, 1990 or latest version.
• or other outdoor structure. This can cause the control panel and knobs to get hot to the touch and possibly even burn your fingers, not to mention that it can melt all rubber gaskets on the valves and damage the ignition system to where it will need full replacement. Ventilation and typical wind direction and conditions must always be considered when planning your outdoor cooking island.
• • A minimum of two ventilation holes in the enclosure, of at least 20 sq. inches in size (per vent), must be present to help release any leaking gas from the enclosure. As Propane is heavier than air, for propane grills locate your vents at the tank valve height or lower As Natural Gas is lighter than air, for natural gas grills locate your vents at the gas connection height or higher The counter should be flat and level relative to the floor.
Cut out Dimensions Figure A Vent Width Depth Vent Height Vent Vent Minimum of 2 vents, but optimally 4 vents, per cabinet that has any sort of gas supply or connection. Each vent must be at least 20 sq in in size and have access to outside/fresh air. Two vents on each side will facilitate and improve airflow and ventilation.
Gas Requirements NOTE: Coyote strongly recommends that a qualified service technician perform the initial installation and all conversions or modifications to the gas supply. Never attach an unregulated gas line to the appliance. Connection to an unregulated gas line can cause excessive heat or fire and the risk of property damage, bodily injury, or death. IMPORTANT: Before connecting grill to gas source, make sure grill control knobs are in the “OFF” position.
• • • • • • • • in pools and low areas. In its natural state, propane has no odor. For your safety, an odorant typically is added. ALWAYS purchase or refill your propane tanks from a reputable propane gas supplier. Contact with propane can cause freeze burns to the skin. NEVER use a propane cylinder with a damaged body, valve, collar or footing. A dented or rusted propane cylinder may be hazardous. Always keep LP cylinder securely fastened in an upright position.
The system has a flow limiting device which, when activated, will limit the flow of gas to 10 cubic feet per hour. NEVER use grill without leak testing this connection. • • LP (Propane) Gas Supply Connection 1. The tank valve should be in the “OFF” position. If not, turn the knob clockwise until it stops. 2. Make sure all burner valves are in the “OFF” position. 3.
proceeding by calling the Coyote Customer Service line at 855-520-1559. 7. If no rushing sound, brush soapy solution onto areas where bubbles are shown in LP tank (see picture). 8. If “growing” bubbles appear, there is a leak. Close LP tank valve immediately and retighten connections. If leaks cannot be stopped, do not try to repair the regulator, or tank valve, by yourself and contact the Coyote Customer Service line at 855-520-1559. 9.
Large Capacity Propane Tanks and Homes: • If your entire house is plumbed for propane gas use, and you have an exterior connection for such use, then a standard LP grill from Coyote can be connected to such outdoor propane connection, but you must be aware of the following: o Coyote does not supply any gas fittings or lines, other than the regulator needed within the grill box o All Coyote LP Grills come with a 20lb tank regulator. This regulator cannot be used or modified to work on any other setup.
3. 4. 5. 6. Mix a solution of equal parts mild detergent or liquid soap and water. Turn all grill control knobs to OFF. Ensure that the connections from the regulator to the grill and tank are tight and secure. Completely open the shut-off valve. If you hear a rushing sound, turn gas off immediately. There is a major leak at the connection. Correct before proceeding by calling the Coyote Customer Service line at 855-520-1559. 7. If no rushing sound, brush soapy solution onto all connection points. 8.
4. Unscrew the 4 bolts holding the faceplate to the body (on the front edge where your cooking grate sits). 5. Unscrew the 2 bolts (on each side) of the manifold and faceplate assembly that holds this entire assembly to the body of the grill. 6. Disconnect all wires and flex lines, from the valves and igniter assembly while paying close attention to their original location. 7. Slide entire control panel and valve assembly out from the grill body. 8.
Operating the Grill • Failure to open the lid prior to igniting the barbecue’s burners, or not waiting 5 minutes to allow the gas to clear if the barbecue does not light, may result in an explosive flame-up which can cause serious bodily injury or death. • • • NEVER use the grill if gas odor is present. NEVER stand with head, body, or arms over the grill when lighting. ALWAYS inspect the hose before using the grill.
Lighting Instructions for your Gas Grill Using the Grill’s Built-In Ignition System: 1. Open the canopy. 2. Keep your body, arms and face as far away from the burners and cooking surface as possible. 3. Select the burner that you want to ignite. Depress and rotate the knob corresponding to that burner counter-clockwise to the "High" position. a. As you are nearing the "High" position, you will notice the valve getting tougher to turn.
Using Your Burners and Grilling Safely Your grill is designed to reach a temperature that you set by adjusting a valve that in turn adjusts the amount of gas that goes through each burner. This valve is located behind your knob and is the key to your heat and fuel consumption. Furthermore, the way to ignite the burners is through the valves, so please understand the importance of the valves/knobs and the position/care taken with respect to them.
For Rotisserie Cooking, Coyote grills utilize the same ceramic burner technology in their sear burner, as their rotisserie burner, along with a motor and spit that will hold and rotate up to 20lbs of food. Never stand with your head directly over the Grill when preparing to light the Rotisserie burner, to prevent possible bodily injury. Be sure to engage in safe food handling and preparation.
i. The center of your spit rod to the top of the hood, equals the same distance from the spit rod to the top of the flavorizers. NOTE: Close hood carefully and align Motor Bracket and Shaft Mounting Bracket so that Rotisserie Rod is in between the hood openings. No. 1 2 3 4 5 6 7 8 9 Qty 1 1 1 2 2 1 1 2 2 Description 110V Motor Motor Bracket Spit Rod Shaft Collar 4-Prong Fork Handle Counterbalance Screw Hexagonal Head Screw Never operate Rotisserie Burner with main burner(s) “ON.
Grilling Tips: • If you pre-cook meat or poultry, do so immediately before grilling. • Refrigerate leftovers within 2 hours of taking food off the grill. • Never let the tray boil dry, as that could be hazardous. Grease from fatty foods that have collected in the • • • • • • • • • • tray could ignite and possibly cause bodily injury or property damage. Use a meat thermometer to be sure food has reached a safe internal temperature.
COOKING GRATES The cooking grates can be cleaned immediately after cooking is completed and after turning off the grill. But, exercise extreme caution because the grates will be very hot if you clean them immediately after cooking. Wear a barbecue mitt and scrub the cooking grates with a damp cloth. If the grill is allowed to cool down, cleaning the grates will be easier if removed from the grill and cleaned with a mild detergent.
Cleaning the Stainless Steel and Polishing 1. Allow grill to cool before cleaning/polishing stainless steel. Do not clean or polish your grill’s stainless steel when the gill is in operation or still hot. 2. To clean the stainless steel, wash off all dirt and debris from the steel with warm water. If you have tough spots to clean, then a third-party degreaser product can be used. 3. Next, rinse and dry the steel thoroughly with a clean towel.
How to Remove Scratches from your Stainless Steel: If your situation is a little more serious and you have obtained scratches in your equipment, then you will need to purchase a third-party stainless steel scratch kit. These kits are popular in retail stores but can be easier to obtain online. With these kits, you will not polish the unit until you are done re-scratching the entire product you are working on.
3. Keep the ventilation opening(s) of the cylinder enclosure free and clear from debris. 4. Visually check burner flames. Burner flames should be blue and stable with no yellow tips or excessive noise. If any of these conditions occur, turn grill off and call our customer service line. 5. Clean outdoor cooking gas appliance, including special surfaces, with recommended cleaning agents, if necessary. 6. Check and clean burner for insects and insect nests. A clogged tube can lead to a fire beneath the grill.
- If you hear a snapping sound, can you see a spark at the electrodes? Note: You will need to remove your cooking grates and flavorizers to see the electrodes. The electrodes should have a 1/8” to ¼” gap between the electrode and contact point. Flare-ups • Check for loose wire connections to the igniter or electrodes. • Check to see if debris is blocking the electrodes.
C2C34 Exploded Parts View 30
C2C34 Parts Listing No. Name Qty Part No.
C2C36 Exploded Parts View 32
C2C36 Parts Listing No. Name Qty Part No.
C2C42 Exploded Parts View 34
C2C42Parts Listing No. Name Qty Part No.
C2SL30 & C2SL30-FS Exploded Parts Diagram 36
C2SL30 Parts Listing No. Name Qty Part No.
C2SL30 Parts Listing 36 NG Regulator- C1 Models 1 C1000038 37 LP Regulator 1 C0000030 38 3-Burner Light Wire 1 C30000011T 39 Motor Bracket 1 C0000016 40 Rotisserie Kit - 30 1 CROT0030 41 Transformer - SL 1 C0000055 42 Smoker Box 1 C0000020 43 IR Burner Lighting Electrode 1 C0000950 44 Thermocouple-30 1 C3600018 45 Stainless Steel Corrugated Hose 1 C0000031 46 Motor 1 C0000015 47 Logo Badge 1 CH500019 48 LED Light Ring 4 C00000411T 49 LED Wiring Harness -
39
C2SL30-FS Parts Listing No. Name Qty Part No.
C2SL30-FS Parts Listing 36 NG Regulator- C1 Models 1 C1000038 37 LP Regulator 1 C0000030 38 3-Burner Light Wire 1 C30000011T 39 Motor Bracket 1 C0000016 40 Rotisserie Kit - 30 1 CROT0030 41 Transformer - SL 1 C0000055 42 Smoker Box 1 C0000020 43 IR Burner Lighting Electrode 1 C0000950 44 Thermocouple-30 1 C3600018 45 Stainless Steel Corrugated Hose 1 C0000031 46 Motor 1 C0000015 47 Logo Badge 1 CH500019 48 LED Light Ring 4 C00000411T 49 LED Wiring Harness
C2SL36 Exploded Parts View C2SL36 Parts Listing No. Name Qty Part No.
C2SL36 Parts Listing 15 IR Burner-36 1 C3600011 16 Flavorizer Bracket-36 1 C2360004 17 Warming Rack-36 1 C3600008 18 Grate (1pc) 19 Bar 1 CSG00019 19 Grate (1pc) 20 Bar 1 CSG00020 20 Flavorizer-36 3 C2360009 21 Sear Burner 1 C1000019 22 Infinity Burner 3 C1SL0001 23 Firebox Bottom Cover 1 C2000048 24 Firebox-36 1 C2360003 25 Safety Valve (IR Burner) LP 25 Safety Valve (IR Burner) NG 26 Sear Burner Valve LP 26 Sear Burner Valve NG C1S00013 1 1 C1S00014 C1S0001
C2SL42 Exploded Parts View C2SL42 Parts Listing No. Qty Part No.
C2SL42 Parts Listing 16 Flavorizer Bracket-42 1 C2420004 17 Warming Rack-42 1 C4200008 18 Grate (1pc) 15 Bar 3 CSG00015 19 Flavorizer-42 4 C2420009 20 Sear Burner 1 C1000019 21 Infinity Burner 4 C1SL0001 22 Firebox Bottom Cover 1 C2000048 23 Firebox-SL42 1 C2420003 24 Safety Valve (IR Burner) LP 1 C1S00013 24 Safety Valve (IR Burner) NG 1 C1S00014 25 Sear Burner Valve LP 1 C1S00015 25 Sear Burner Valve NG 1 C1S00016 26 Standard Valve LP 4 C2SL0012 26 Stan
