Coyote Stainless Steel Side Burner Use & Care Manual For Liquid Propane and Natural Gas Models Slide-in Models Coyote S Series –CDSB-LP/CDSB-NG Coyote C Series –CSSB-LP/CSSB-NG Dual Slide in Side Burner LP/NG Single Slide in Side Burner LP/NG Conforms to ANSI STD 21.58a-2008 Certificated to CSA STD 1.6a-2008 XXXXXX For Outdoor Use Only PUT SERIES NO.
Welcome & Congratulations Congratulations on your purchase of a new side burner! We are very proud of our products and we are completely committed to providing you with the best service possible. Your satisfaction is our #1 priority. Please read this manual carefully to understand all the instructions about how to install, operate and maintain for optimum performance and longevity. We know you’ ll enjoy your new side burner and thank you for choosing our product.
Table of Contents Safety Instructions ..................... 2 Side Burner Models ..................... 4 Gas Requirement ........................ 5 Locating the Side burner ............ 9 Pre Operation Leak Testing ....... 11 Parts List ................................... 12 Light the Side burner ................... 14 Operation and Features ............. 16 Care & Maintenance .................. 17 Troubleshooting Your Burner .... 19 Limited Warranty ........................
Safety Instructions WARNING: Improper installation, adjustment, alteration, service or maintenance can cause injury or property damage. Read the installation, operating and maintenance instructions thoroughly before installing or servicing this equipment. General Safety Instructions 1. 2. 3. 4. 5. 6. 7. 8. 9. 10. 11. 12. 13. 14. 15. 16. For Household Outdoor Use Only –DO NOT use indoors or in any type of enclosed area such as a garage, shed or breezeway. Keep clear of trees and shrubs.
17. 18. 19. 20. 21. 22. 23. 24. 25. placed away from walkways to avoid tripping hazard. Keep gas supply lines as short as possible. Never move the side burner when hot. DO NOT use while under the influence of drugs or alcohol. DO NOT store a spare gas cylinder under or near your side burner. Grease is extremely flammable. Let hot grease cool down before attempting to handle or dispose of it. In the event that a burner goes out, turn burner knobs to the full OFF position.
Side Burner Models (Need to describe their main characteristic what a feature that helps to identify or describe recognizably; a distinguishing mark or trait) Coyote S Series –CDSB-LP/CDSB-NG Coyote C Series –CSSB-LP/CSSB-NG Dual Slide in Side Burner LP/NG Single Slide in Side Burner LP/NG Model No.
Gas Requirement NOTE: Always have a qualified service technician perform difficult conversions or modifications. WARNING: Never attach an unregulated gas line to the appliance. Connection to an unregulated gas line can cause excessive heat or fire. IMPORTANT: Before connecting side burner to gas source, make sure burner control knobs are in “OFF”position. Verify the type of gas supply to be used, either natural or LP, and make sure the marking on the appliance rating label agrees with that of the supply.
- - - - and 18 inches high. The maximum fuel capacity is 80% and is approximately 20 pounds of propane. The L.P. cylinder must have a shut-off valve (see picture) terminating in a Type 1 L.P. A Type 1 compatible cylinder with a Type 1 cylinder valve has a back-check valve which does not permit gas flow, until a positive seal has been obtained. The cylinder must be arranged for vapor withdrawal. It must also include a collar to protect the cylinder valve.
control valves on the unit to the “HIGH”position for about 20 seconds to allow the air in the system to purge before attempting to light the burners. WARNING: Always take a leak test before lighting the side burner to prevent a possible fire or explosion. Never store a spare propane cylinder in the vicinity of this side burner, or in the vicinity of any other potential heat source. LP Gas Supply Cylinder Disconnection 1. Turn the burner valves off. 2. Turn the tank valve off. (Turn clockwise to stop). 3.
- Natural Gas Hook-up Always check the rating plate to make sure the gas supply you are hooking up to is the gas type the side burner is manufactured for. This natural gas burner is designed to operate on natural gas ONLY, at a pressure regulated at 4” (101.6mm) water column (W.C.) when equipped with the correct natural gas orifices on the valves and a natural gas regulator on the supply line regulated at the residential meter. IMPORTANT: Never connect the burner to an unregulated gas supply.
Locating the Side Burner Check your local building codes for the proper method of installation. In the absence of local codes, this unit should be installed in accordance with the National Fuel Gas Code No. Z223.1-1998 USA or CAN/CGA-B149.1/.2 Natural Gas/Propane Code (Canada) latest edition or the National Electrical Code ANSI/NFPA No. 70 or the Canadian Electrical Code CSA C22.1, 1990 or latest version.
The two top illustrations demonstrate how the slide-in type unit is designed to fit into open- front enclosures, and supported at the Countertop. Do not install this unit under unprotected flammable surfaces. Do not install or use this appliance inside a building, garage, or any other covered area. It must not be used in or on recreational vehicles or boats. INSTALLER NOTE: This unit should be installed so that it can be removed at a later date if factory service is required.
Pre Operation Leak Testing DANGER 1. 2. 3. Do not insert any tool into the valve outlet or safety relief valve. You may damage the valve and cause a leak. Leaking propane may result in explosion, fire, severe personal injury, or death. If a leak is detected at any time or you cannot stop a gas leak, immediately close pipeline valve and call LP gas supplier or you fire department! Check all gas supply fittings before each use and each time the gas supply cylinder is connected to the regulator.
Dual Side Burner Parts List Coyote S Series –CDSB No. Description Qty NG/LP Part No. PARTS LISTING No. 1 Lid Handle 1 C0000013 8 2 Lid-DB 1 CDB00004 9 3 Grate-SB 2 CSB00004 10 4 Burner(Side Burner) 2 C0000001 5 Burner Box-DB 1 6 Main Body-DB 7 Gas Pipe-DB Name Part No.
Single Side Burner Parts List Coyote C Series –CSSB No. Description Qty NG/LP Part No. No. 1 Lid Handle 1 C0000013 8 2 Lid-SB 1 CSB00006 9 3 Burner Box-SB 1 CSB00001 10 4 Grate-SB 1 CSB00004 5 Burner(Side Burner) 1 6 Main Body-SB 7 Gas Pipe-SB PARTS LISTING Description Part No.
Lighting the Side Burner DANGER Failure to open the lid while igniting the burners, or not waiting 5 minutes to allow the gas to clear if the barbecue does not light, may result in an explosive flame-up which can cause serious bodily injury or death. WARNING DO NOT use the burner if gas odor is present. DO NOT stand with head, body, or arms over the burner when lighting. Inspect the hose before using the burner.
Lighting Instructions OPEN LID Control Knob Igniter ENSURING BURNER CONTROLS ARE IN “OFF”POSITION, TURN ON THE GAS SUPPLY VALVE. Control Knob Igniter Be sure a AA battery is inserted inside the igniter. Main Burner Lighting 1. If burner does not light, repeat previous steps, or follow the following instructions. 1. Push and hold the igniter, then turn the Right or Left knob to HIGH position 3-5 seconds to light burner. 2.
Operations and Features When initially bringing turning the burners on, burn the burners to get rid of any odors or debris by operating at “HIGH”setting Preparing Food for the Side Burner WARNING: Always observe safe food-handling and safe food-preparation practices when using this burner, to prevent food-borne illnesses. - Always cook foods adequately. Undercooked foods can retain bacteria, especially if thawed or exposed to warm conditions prior to cooking.
Care & Maintenance CAUTION: All cleaning and maintenance should be done only when side burner is cool & with the fuel supply turned off at the cylinder. If your side burner is set up for use with Natural Gas, turn off gas supply at the system manual shut off valve. DRIP PAN The drip pan located below the burner should be cleaned periodically to prevent heavy buildup of debris. NOTE: Allow the drip pan to cool before attempting to clean.
ANNUAL CLEANING OF BURNER HOUSING Burn-off the barbeque after every cookout will keep it ready for instant use, however, once a year you should give the entire side burner a thorough cleaning to keep it in top operating condition. 1. Shut off gas supply at source and disconnects fuel line. Protect fuel line fitting. 2. Remove and clean the cooking grids and burners. 3. Cover the gas valve orifices with a piece of aluminum foil. 4.
Troubleshooting Your Side Burner GENERAL TROUBLE SHOOTING You should inspect the burners at least once a year or immediately if any of the following conditions occur: •The smell of gas. •Flames appearing mostly yellow. (Some yellow at the tips is OK) •The burners will not get hot enough. •Burners make a snapping noise. •The burners heats unevenly. SPIDER AND INSECT WARNING INSECT WARNING：Spiders and insects can nest in the burners of this and other burners, which could disrupt gas flow.
Note: You will need to remove your cooking grates to see the electrodes. • Check your igniter battery and replace if needed. • Check for loose wire connections to the igniter or electrodes. • Check to see if debris is blocking the electrodes. • If the igniter is not working, can you light the burner with a lighter? Flare-ups • Ensure burner is not placed directly in the path of wind. Be sure drip pan is clean (do not use aluminum foil on drip pan.
Limited Warranty Coyote Outdoor warrants to the original purchaser at the original site of delivery with proof of purchase of each Outdoor Gas grill/Side burner that when subject to normal residential use, it is free from defects in workmanship and materials for the periods specified below. This warranty excludes grills used in rental and commercial applications. It does NOT apply to rust, corrosion, oxidation, or discoloration, which may occur due to moisture or overheating.
