SEARS operator's manual MODEL NO. 143.994011 4.0 RESERVE POWER 10 INCH CUBIC DISPLACEMENT SOLID STATE (163 cc) IGNITION ENGIN CAUTION: • Operating Read RULES for Safe OPERATION and INSTRUCTIONS • Maintenance • Repair Parts Carefully [A WARNING: known to the State of California to cause cancer, birth other reproductive harm.contains chemicals CalifomiaProposRion65 Thedefects engineorexhaust from this product I Sold by SEARS, ROEBUCK AND CO., CHICAGO, IL 60684 U.S.A. and SEARS CANADA, INC.
OIL FILL PLUG AND DIPSTICK RECOIL I lllllllll+TllliBfl CAP STARTER FUEL STARTER HANDLE I MODELAND O.o.m. DECAL OIL DRAIN BOTrOM OF ENGINE AIR SPARK PLUG WIRE DRAIN PLUG SPARK PLUG CARBURETOR MUFFLER Figure 1 THIS SYMBOL POINTS OUT IMPORTANT SAFETY INSTRUCTIONS WHICH IF NOT FOLLOWED COULD ENDANGER THE PERSONAL SAFETY ANDIOR PROPERTY OF YOURSELF AND OTHERS.
BEFORE STARTING (Continued) STOPPING (_) FILL FUEL TANKwlth 9asotineas speoitiedinthe preceding "OIL & FUEL RECOMMENDATIONS" item 2. NEVER MIX OIL WITH GASOLINE Neveruse "stale"gasolineleft over from last season or storedfor long pednds. (_ Move ENGINE CONTROL (see Figure 1) to STOP. (_ AFTER d_lL WHEN NEVERENGINE FILL FUEL TANK INDOORS. FILL FUEL WHEN TANK IS RUNNING OR HOT.NEVER DO NOT SMOKE I FILLING FUEL TANK. ,_ ENGINE IS STOPPED: ,_A.
MAINTENANCE (Continued) (_ AIR CLEANER (see Figure4): MAINTENANCE (_) SPARK NEVER RUN ENGINE WITHOUT COMPLETE AIR CLEANER INSTALLED ON ENGINE. PLUG (continued) (see Figure 5): This spark ignitionsystemmeets all requirementsof the Canadian Interference-CausingEquipmentRegulations. This engine complies with all currentAustralianand New Zealand limitations regarding electromagnetic interference. Replace filteronce a year or mere often if used inextremely dusty or dirty conditions.
STORAGE (Continued) ADJUSTMENTS DO NOT MAKE UNNECESSARY ADJUSTMENTS. FACTORY SETTINGS ARE SATISFACTORY FOR MOST APPLICATIONS AND CONDITIONS. IF ADJUSTMENTS ARE NEEDED, PROCEED AS FOLLOWS: (_) CHANGE Changeoilifit hasnotbeenchangedinthe lastthree(3) months. Sea "CHANGEOIL"instructions in "MAINTENANCE"section. (_CARBURETOR _) If you think your carburetor needs adjusting, see your nearest SEARS ROEBUCK AND CO. (OR SEARS CANADA, INC.) SERVICE CENTER.
TROUBLESHOOTING THE FOLLOWING MAY HELP AVOID A DELAY IN YOUR WORK OR SAVE THE EXPENSE OF A SERVICE CALL. ENGINE FAILS TO START OR STARTS WITH DIFRCULTY CAUSE REMEDY Controls not in start position. Move ENGINE CONTROL or equipmentcontrol to "HI"or START postion, See "STARTING" Instructionsin this manual. Sparkplugwiredisconnected fromsparkplug. Connect SPARK PLUG WIRE to SPARK PLUG. Sparkplugfouled. Remove SPARK PLUG and dean it. See 'SPARK PLUG" Instructionsin 'MAINTENANCE" section in this !manual..
SEARS, ROEBUCK AND CO. Federal and California Emission Control Systems Limited Warranty Utility and Lawn and Garden Engines CALIFORNIA & US EPA EMISSION CONTROL WARRANTYSTATEMENT B. GENERAL EMISSIONS WARRANTY COVERAGE: Seam, Roebuck and CO. warrsrds to the Original, end-tree puff_lase_ Of the new engine or equipment and to each subsequent purchaser that each Of its teifify and lawn and garden equipment engines is: The U.
CRAFTSMAN 4-CYCLE ENGINE MODEL:143.994018 0--370K "3gO q__.261 ,.
CRAFTSMAN Ref. No. Pad No.
CRAFTSMAN.4-CYCLE Ref. No. _380 i390 Part No. 640156 590732 400 416 37029A 36085 417 650821 ENGINE Part Name Carburetor (IncL 184) Rewind Starter (NOTE: This engine couldhave been built with 590738 starter). Gasket Set (Incl. Items Marked *) Spark Arrestor Kit (Incl. 417) (Optional) Screw, 10-32 x 1/2" (Optional) MODEL:143.99401 Ref. No. Part No.
REWIND STARTER NO. 590732 Ref. No. Pert No. 1 2 3 4 5 6 7 8 11 590732 590599A 590600 590696 590601 590697 590698 590699 590700 590695 12 13 590535 590701 12 Pert Name Rewind Starter Spdng Pin (Incl. 4) Washer Retalnar Washer Brake Spdng Starter Dog Dog Spdng Pulley Ass'y. (Incl. 9 & 10) Starter Housing Ass'y, (40 degree grommet) Starter Rope (Length 98" x 9/64" die,) StaRer Handle Bin5 STARTER NO. 590738 _14 Ref. NO. 3 6 7 8 11 12 13 12 13 14 II Pert No.
How to ORDER SE/AR$ operator's manual Repair Parts The Model Number can be found on a decal on the blower housing (See Figure 1). Always mentionthe Model Numberwhen request_ ing service or repair parts for yourCraftsman Engine. All parts listedherein may be orderedfrom any SEARS, ROEBUCK AND CO. or SEARS CANADA, INC. retail or catalog store. If the parts you need are not stockedlocally,your order willbe electronicallytransmittedto a Sears Repair Parts Distdbution Center for expeditedhandling.