SEARS operator's manual MODEL NO. 143.994016 4.0 RESERVE POWER 10 CUBIC INCH (164cc) DISPLACEMENT l ENGIN SOLID STATE IGNITION CAUTION: • Operating Read RULES for Safe OPERATION and INSTRUCTIONS • Maintenance • Repair Parts Carefully California Proposition 65 known WARNING: to the State of California The engine exhaust from this productcontains chemicals to cause cancer, birth defects or other reproductive I harm. Sold by SEARS, ROEBUCK AND CO., CHICAGO, IL 60684 U.S.A. and SEARS CANADA, INC.
OIL FILL PLUG AND DIPSTICK STARTER, HANDLE MODELANO D.O.M.DECAL SPARK PLUG WIRE CLEANER CONTROL LEVER OIL DRAIN PLUG CARBUERTOR SPARK PLUG ,MUFFLER BOTTOM OF ENGINE / Figure1 THIS SYMBOL ENDANGER POINTS THE OUT PERSONAL IMPORTANT SAFETY SAFETY AND/OR INSTRUCTIONS PROPERTY WHICH IF NOT OF YOURSELF FOLLOWED AND OTHERS. COULD READ ._ AND FOLLOW ALL INSTRUCTIONS IN THIS MANUAL AND ANY PROVIDED WITH THE EQUIPMENT ON WHICH THIS ENGINE IS USED BEFORE A3"rEMFnNG Alt TO OPERATING.
BEFORE STARTING C. BEFORE STARTING (Continued) Slide rope stop (see Figure 2) onto starter rope and feed starer ropethroughropeguideon mowerhandle(see Figure 4). (_ D. Feed starter ropethroughstarterhandle(see Figure5) and tie a lefthand knot,leaving1/2 inchto 1 inchofstarer rope extending beyond left hand knot. DO NOT PULL LEFT HAND KNOT INTO STARTER HANDLE YET. _lb E. With starer handle resting on rope guide (see Figure 4), check starterrope for slack. If there is any slack,pull more F. G. H.
STARTING _ MAINTENANCE NEVER RUN ENGINE INDOORS OR IN ENCLOSED, POORLY VENTILATED AREAS. ENGINE EXHAUST CONTAINS CARBON MONOXIDE, AN ODORLESS AND DEADLY GAS (CARBON MONOXIDE IS ALSO PRESENT IN ENGINE EXHAUST FROM LIQUID PETROLEUM (LPG) AND NATURAL GAS FUEL SYSTEMS). _ CHECK WARNING TEMPERATURE OF MUFFLER AND NEARBY AREAS MAY EXCEED 150°F (65°C). AVOID THESE AREAS. _) + START A. B. C.
•MAINTENANCE (_ SPARK (Continued) STORAGE PLUG (see Figure8): IN ENCLOSED, POORLY VENTILATED AREAS, WHERE FUEL I FUMES MAY REACH AN OPEN FLAME, SPARK OR PILOT I NEVER STORE ENGINE WITH WATER FUEL IN HEATER, TANK INDOORS OR I LIGHT AS ON A FURNACE, CLOTHES DRYER OR OTHER OAR APPLIANCE_ This spark ignition system meets all requirements of the Canadian Interference-Causing Equipment Regulations.
TROUBLESHOOTING THE FOLLOWING MAY HELP AVOID A DELAY IN YOUR WORK OR SAVE THE EXPENSE OF A SERVICE CALL. ENGINE FALLS TO START OR STARTS WITH DIFFICULTY REMEDY CAUSE Controls not in start position. Move ENGINE CONTROL or equipmentcontrolto "HI' or START postion. See "STARTING" instructionsin this manual. Spark plug wire disconnectedfrom sparkplug. ConnectSPARK PLUG WIRE to SPARK PLUG. Spark plugfouled. Remove SPARK PLUG and clean it.
SEARS, Federal and California Utility ROEBUCK Emission AND CO. Control Systems and Lawn and Garden CALIFORNIA & US EPA EMISSION CONTROL WARRANTY STATEMENT The U. S. Environmental Protection Agency ("EPA"), the California Air Resources B_ard ("CARe") and Seam, Roebuck and CO. are pleased to explain the Federal and California Emission Control Systems Warranty on your new utility or lawn and garden equipment engine.
CRAFTSMAN 4-CYCLE ENGINE MODEL:143.994016 0--370K • 3go 298 370C 101 126 120 11g I 125 / 215,_ 204 52 182 185/.
CRAFTSMAN Ref. No. Part No.
CRAFTSMAN Ref. No. 380 390 Part No. 640156 590737 400 416 37029A 36085 417 650821 4-CYCLE ENGINE Part Name Carburetor (Incl. 184) Rewind Starter (NOTE: This engine could have been built with 590694 starter). Gasket Set (Incl. Items Marked *) Spark Arrestor Kit (Incl. 417) (Optional) Screw, 10-32 x 1/2" (Optional) MODEL:143.994016 Ref. No. Part No.
REWIND STARTER NO. 590737 Ref. No. \ II t2 STARTER Part No. Part Name 3 6 7 8 11 590737 590740 590616 590617 ;590618A 590687A 12 590535 13 14 590701 590760 Rewind Starter Retainer Starter Dog Dog Spring Pulley & Rewind Spring Ass'y Starter Housing Ass'y (40 degree grommet) Starter Rope (Length 98' x 9/64" dia.) Starter Handle Spring Clip NO. 590694 12 Ref. No. / 13 m 8 7__=;=;--7 6 (___ B_ O _ part No.
How to ORDER Repair Parts The Model Number can be found on a decal on the blower housing (See Figure 1). Always mention the Model Number when requesting service or repair parts for your Craftsman Engine. SEARS All parts listed herein may be ordered from any SEARS, ROEBUCK AND CO. or SEARS CANADA, INC. retail or catalog store. If the parts you need are not stocked locally, your order will be electronically transmitted to a Sears Repair Parts Distribution Center for expedited handling.