SWARS operator's manual MODEL 6.5 NO. 143.016502 HORSEPOWER 12 CUBIC INCH (195 cc) DISPLACEMENT SOLID STATE IGNITION ENGIN CAUTION: • Operating Read RULES for Safe OPERATION and INSTRUCTIONS Carefully A, • Maintenance • Repair Parts WARNING: California Proposition 65 known to the State of California The engine exhaust from this product contains to cause cancer, birth defects or other reproductive harm. chemicals Sold by SEARS, ROEBUCK AND CO., CHICAGO, IL 60684 U.S.A. and SEARS CANADA, INC.
OIL FILL AND DIPSTICK Bill IIIll IIIIIIIlllll STARTER FUEL FILL CAP HANDLE MODEL AND D.0.M. DECAL COOLING OIL FILL PLUG AND DIPSTICK AIF SCREEN > (/._77,:7W'_G,<7 AIR CLEANER SPARK PLUG WlRE PRIMER LEVERS & LINKAGE SPARK PLUG MUFFLER Figure THIS SYMBOL POINTS OUT ENDANGER THE PERSONAL BoTroM IMPORTANT SAFETY INSTRUCTIONS WHICH SAFETY AND/OR PROPERTY OF YOURSELF FOLLOW ALL INSTRUCTIONS IN THIS MANUAL AND ANY PROVIDED THIS ENGINE IS USED BEFORE AITEMPTING TO OPERATING.
EFORE STARTING BEFORE (Continued) NSTALL STARTER ROPE: A. Pull at least 2 feet of starter rope out of starter and tie a slip knot at starter to prevent starter rope from rewinding back into starter. B. Slide rope stop (see Figure 2) onto starter rope and feed starter rope through rope guide on mower handle (see Figure 3). C, Feed starter rope through starter handle (see Figure 4) and tie a left hand knot, leaving 1/2 inch to 1 inch of starter rope extending beyond left hand knot.
STARTING MAINTENANCE _ WARNING TEMPERATURE OF MUFFLER AND NEARBY AREAS MAY EXCEED 150°F (65°C). AVOID THESE AREAS. ,_L. NEVER RUN ENGINE INDOORS OR IN ENCLOSED, POORLY VENTILATED AREAS. ENGINE EXHAUST CONTAINS CARBON MONOXIDE, AN ODORLESS AND DEADLY GAS (CARBON MONOXIDE IS ALSO PRESENT IN ENGINE EXHAUST FROM LIQUID PETROLEUM (LPG) AND NATURAL GAS FUEL SYSTEMS). CHECK 1 i OIL LEVEL: Check oillevelevery five(5) operatinghoursor each time engine is used.
MAINTENANCE (_ SPARK (Continued) STORAGE PLUG (see Figure7): A NEVER STORE ENGINE WITH FUEL IN TANK INDOORS OR IN I ENCLOSED, POORLY VENTILATED AREAS, WHERE FUELI FUMES MAY REACH AN OPEN FLAME, SPARK OR PILOT I LIGHT AS ON A FURNACE, WATER HEATER, CLOTHES DRYER OR OTHER GAS APPLIANCE. IF ENGINE IS TO BE UNUSED FOR 30 DAYS OR MORE, PREPARE AS FOLLOWS: NOTE: This spark ignitionsystemmeets all requirementsof the Canadian ,_ Interference-Causing EquipmentRegulations.
TROUBLESHOOTING THE FOLLOWING MAY HELP AVOID A DELAY IN YOUR WORK SAVE THE EXPENSE OF A SERVICE CALL. OR ENGINE FALLS TO START OR STARTS WITH DIFFICULTY CAUSE REMEDY Controls not in start position. Move ENGINE CONTROL or equipment control to "HI" or START postion. See "STARTING" instructions in this manual. Spark plug wire disconnected from spark plug. Connect SPARK PLUG WIRE to SPARK PLUG. Spark plug fouled. Remove SPARK PLUG and clean it.
SEARS, ROEBUCK ANDCO. Federal and California Emission Control Systems Limited Warranty Small Off-Road Engines CALIFORNIA & US EPA EMISSION CONTROL WARRANTY STATEMENT B. GENERAL EMISSIONS WARRANTY COVERAGE: Sears, Roebuck and Co. warrants to the original, end-use purchaser of the new engine or equipment and to each subsequent purchaser that each of its small off-road engines is: The U. S.
CRAFTSMAN 4-CYCLE ENGINE MODEL:143.016502 ,, oo 261 -370A _301 9OO '300 260 370R / _0.,_ _" 292 400 135 290 7 130 126 _1\ 292 101 120 119 416 125 4_ _,_186 / r" / ii i 41/a 46 r\ 179 • 305 182 185 /_178 370C Page 7 181-1254-11
CRAFTSMAN Ref. No. Part No.
CRAFTSMAN Ref. No. Part No. 380 390 640262 590739 400 416 36792B 36O85 417 650821 4-CYCLE ENGINE MODEL: Ref. No. Part Name Carburetor (Incl. 184) Rewind Starter (NOTE: This engine could have been built with 590702 starter). Gasket Set (Incl. Items Marked *) Spark Arrestor Kit (Incl. 417) (Optional) Screw, 10-32 x 1/2" (Optional) Part No. 900 143.
REWIND STARTER NO. 590739 Ref. No. 12 13 STARTER Part No. 3 6 7 8 11 590739 590740 590616 590617 590618A 590638 12 590535 13 14 590701 590760 Part Name Rewind Starter Retainer Starter Dog Dog Spring Pulley & Rewind Spring Ass'y Starter Housing Ass'y (40 degree grommet) Starter Rope (Length 98" x 9/64" dia.) Starter Handle SprLng Clip NO. 590702 Ref. No.
How to ORDER Repair Parts SEARS operator's manual MODEL 6,5 The Model Number can be found on a decal on the blower housing (See Figure 1). Always mention the Model Number when requesting service or repair parts for your Craftsman Engine. All parts listed herein may be ordered from any SEARS, ROEBUCK AND CO. or SEARS CANADA, INC. retail or catalog store.
