Operator's Manual I RA MAN 1 27 Ton Hydraulic Log Splitter Model No. 247.77466 CAUTION: Before using this product, read this manual and follow all Safety Rules and Operating Instructions. • • • • • Safety Assembly Operation Maintenance Parts • Espa_ol Sears, Roebuck and Co., Hoffman Estates, IL 60179, U.S.A. Visit our Sears website: www.sears.com/craftsman Printed in U.S.A. FORM NO.
Content Page Content Page Warranty 2 Service and Adjustments 12 Safety 3 Storage 14 Assembly 5 Troubleshooting 15 Operation 7 Parts List 18 Maintenance 10 Espahol 27 Limited Warranty on Craftsman Log Splitter For one (1) year from the date of purchase, if tills Craftsman Equipment is maintained, lubricated, and tuned up according to the instructions to the operator's manual, Sears will repair or replace free of charge any parts found to be defective in material or workmanship.
WARNING: This symbol points out important safety instructions which, if not followed, could endanger the personal safety and/or property of yourself and others. Read and follow all instructions in this manual before attempting to operate this machine. Failure to comply with these instructions may result in personal injury. When you see this symbol - heed its warning.
8, 9. Use your log splitter in daylight or under good artificial light. To avoid personal injury or property damage use extreme care in handling gasoline. Gasoline is extremely flammable and the vapors are explosive. Serk)us personal injury can occur when gasoline is spilled on yourself or your clothes which can ignite. Wash your skin and change immediately. a. Use only an approved gasoline container. b. Extinguish all cigarettes, cigars, pipes, and other sources of ignition. c.
IMPORTANT:Your logsplitteris shippedwithmotoroil intheengine•However, youMUSTchecktheoillevel beforeoperating• Becarefulnottooverfill. NOTE:Reference to right or left hand side of the log splitter is observed from the operating position. RemovingUnitFromCarton AttachingThe T0ague (See Figere 2) With the log splitter still standing upright, remove two hex bolts, lock washers, and hex nuts from the tongue assembly.
Disconnect the log cradle from the beam on the side of the control valve. Lift and slide the cylinder up to the top of beam and into the weld brackets. Attach the dislodger over the wedge assembly and secure with the hardware previously removed to the weld brackets. See Figure 4. Once the six hex screws are tightened, there may be a slight gap between the dislodger and the weld brackets. This gap is allowable.
Know Your Log Splitter Read this operator's manual and safety rules before operating your log splitter. Compare the illustrations below with your equipment to familiarize yourself with the location of various controls and adjustments. Save this manual for future reference. The operation of any log splitter can result in foreign objects being thrown into the eyes, which can result in severe eye damage.
Choke Control The choke control is used to choke off the carburetor ,_ and assist in starting the engine. Starter Handle The starter handle is located on the engine. Pull the starter handle to start engine. ToStopEngine GasAnd0il Fill-up Push stop switch to OFF. Disconnect spark plug wire and ground it to the post to prevent accidental starting while the equipment is unattended. IMPORTANT:Your log splitter is shipped with motor oil in the engine. However, you MUST check the oil level before operating.
Nevnr: Vertical Position Use when fluid is below 20 ° F or above 150 ° F. Use a solid engine/pump coupling. Operate through relief valve for more than several seconds. Attempt to adjust unloading or relief valve settings without pressure gauges. Operate with air in hydraulic system. Use teflon tape on hydraufic fittings. Attempt to cut wood across the grain. Attempt to remove partially split wood from the wedge with your hands. Fully retract wedge to dislodge wood with Jogdislodger.
MAINTENANCE SCHEDULE _ _ubdcate _ Lu "_ Beam and Wedg_ Change Hydraulic Fluid Change Hydraulic Check Reservoir Check Engine Filter Fluid Oil Change Engine Oil Service Air Cleaner Service Spark Z Z uJ Clean Plug Engine GENERALREC0MMENDATIONS Always observe maintenance. safety rules when performing drain the fluid into a suitable any NOTE: The warranty on this log splitter does not cover items that have been subjected to operator abuse or negligence.
To Service Air Filter Engine Maintenance CheckEngine Oil Stop engine and wait several minutes before checking oil level. Remove oil fill dipstick. Check oil level on dipstick. With engine on level ground, the oil must be to FULL mark on dipstick. Replace dipstick and tighten. 32°F -)_ screw from cover. from hinge. cleaner cover screw, but Swing do not cover down to as Clean inside of body and cover thoroughly and remove cartridge. Reassemble new cartridge in the body.
HoseClamps adjustments stopping WARNING: Do without not at any first time make any engine, disconnecting spark plug wire, and grounding it against the engine. Always wear safety glasses during operation or while performing any adjustments or repairs. Check the hose clamps on the suction hose (attached to side of the pump) for proper tightness before each use. Check the hose clamps on the return hose at least once a season.
Set.010"to.060"clearance betweenthenylon "spider"andtheenginecouplinghalfbyslidinga matchbook coverbetween thenylon"spider"and theenginecouplinghalfandmovingpumpcoupling halfasneeded.Securepumpcouplinghalfwithset screw.SeeFigure11. NOTE: Make certain proper before tightening setscrew. Gear clearance Tires See sidewall of tire for recommended pressu re. Maximum tire pressure under any circumstances is 30 p.s.i. Equal tire pressure should be maintained on all tires. is obtained ,_ Pump Figure 11 13 p.
Prepare season your log splitter or if the for storage log splitter at the Never use engine or carburetor cleaner products in the fuel tank or permanent damage may occur. Use fresh fuel next season. end of the will not be used for 30 days or more. WARNING: Remove spark plug, pour approximately 1/2 oz. of engine oil into cylinder and crank slowly to distribute oil.
Problem Cylinder rod will not move Possible Cause Corrective Action 1. Broken drive shaft. 1. Return unit to Sears service center. 2. Shipping plugs left in hydraulic 2. Disconnect hydraulic hose, remove shipping plugs, and reconnect hose. Refer to adiustment section of this manual and adiust the couplers. Correct engine/pumpalignment. Return unit to Sears service center. Return unit to Sears service center. Flush and clean hydraulic system. Check oil level. Refill if necessary.
Trouble-Shooting Guide Problem Engine fails to start Engine runs erratic. Engine overheats Possible Corrective Causes 1. Dirty air cleaner. 1. 2. 3. 4. 5. Fuel tank empty, or stale fuel Choke lever not in CHOKE position. Blocked fuel line. Spark plug wire disconnected. 2. 3. 4. 5. 6. Faulty spark plug. 6. 1. 2. Unit running on CHOKE. Spark plug wire loose. 1. 2. 3. Blocked fuel line or stale fuel. 3. 4. Dirty air cleaner. 4. 5. Carburetor out of adjustment 5. 1. 2.
Safety & Decorative Labels: Location and Part Number 777D07398 (Warning 777S32422 On Top of Tongue Near Coupler Facing Engine Side (Left Side) of unit 777120739 On Engine Bracket {Not facing Area Adjacent Ram Control Engine) 777S32061 On front of Dislodger 17 Lever) to
Sears Craftsman 6.5 H.P. Log Splitter Model 247.77466 1 / 2 \ / \ \ \ \ 81 15 82 !1 _2 16 83 I 32 i _56 57 ld /58 47 48 49 62 41 / 45 53 / : I 18 79 66.
Sears Craftsman Re/. No. Part No. 6.5 H.P. Log Splitter Model 247.77466 Re/. No. Part Description Part No. Part Description 1. 718-0769 Hydraulic Cylinder 42. 736-0116 Flat Washer.635 ID x.93 OD 2. 727-0634 Hydraulic Tube 43. 736-0169 L-Washer 3/8" 3. 710-1018 Hex Cap Screw 1/2-20 x 2.75 44. 712-0798 Hex Nut 3/8-16 4. 5. 737-0192 718-0481 90 Degree Solid Adapter Control Valve 45. 46. 681-0161 781-0686 Frame Assembly 6. 737-0153 Return Elbow 47. 710-3097 7.
Sears Craftsman 6.5 H,P, Engine Model No. 123K02 For Log Splitter Model 247.
Sears Craftsman 6.5 H,P, Engine Model No. 123K02 For Log Splitter Model 247.77466 968 188 443_ 445 615 404 @ 843 /- 163_ 616_ 692 | 977 CARBURETOR GASKET SET 104 ,27 61 7_ 633 @ 633A 276@ 130 95 _ 0 617 121 CARBURETOR OVERHAUL KIT 276 633 G 633A8 lo4%_ 333 334_ 276@ 127 21 .
Sears Craftsman 6.5 H,P, Engine Model No. 123K02 For Log Splitter Model 247.77466 358 ENGINE GASKET SET 3_ 20_ 842_ s24_ /_.
Sears Craftsman 6.5 H,P, Engine Model No. 123K02 For Log Splitter Model 247.77466 Ref. No. 1. 2. 3. 4. 5. 7. 8. 9. 19. 11. 12. 13. 15. 16. 20. 22. 23. 24. 25. 26. Part No. 697322 399269 299819t 493279 691160 692249t 695250 699472 591125 691260 592232_ 690912 591680 691455 399781t 691092 591992 222698 597339 697341 499425 499427 27. 26. 29. 32. 32A. 33. 34. 35. 36. 37. 40. 43. 45. 46. 48. 50. 51. 54. 55. 56. 691866 60. 65. 78. 81. 95. 97. 104. 108. 109. 117. 121. 125. 127. 130.
Sears Craftsman 6.5 H.P. Engine Model No. 123K02 For Log Splitter Model 247.77466 Ref. No. 635. 668. 670. 684. 689. 692. 718. 741. 832. 836. 842. 843. 847. 851. 868. 869. 870. 871. Part No. 56538 493823 692294 690345 591855 690579 690959 691830 499034 690664 691031t 591895 692017 493888 697338 591155 690380 262001 63709 tlncluded ttlncluded Ref. No. Part Description Part No.
(This page applicable Inthe USAa[id Canada 0nly) Sears,Roebuck andCo., U.S.A. (Sears), the California Air Resources Board (CARB) and the United States Environmental Protection Agency (U.S.
NOTES 26
P_gina Materia Materia P_igina Garantia 27 Servicio y ajustes 37 Protecci6n 28 Almacenamienfo 39 Ensamble 30 Gui De Localizaci6n de faNas 40 Funcionamienfo 32 Lista de piezas 18 Mantenimiento 35 Notas 26 Garantia limitada de la cortadora de troncos Craftsman Sears reparara o reemplazara gratis toda pieza que se determine ctefectuosa en material o mano de obra, a partir de un (1) afro de la fecha de cornpra, si este equipo Craftsman se mantiene, lubrica y afina de acuerdo con las
ADVERTENCIA: observan, pueden las inst rucciones Este sfmbolo porter en peligro en este manual pu@d@ r@suItar en lesiones ADVERTENClA: indica importantes la seguridad antes de intentar personales. El escape Cuando instrucciones personal operar esta m_quina. vea este simbolo del motor, algunos de segufidad y/o la propiedad la ¢uales, suya y de terceros. El no cu mplir con estas inst rucciones ohedezca a SLI advert@ncia.
Paraevitarlesiones personales odaf_os alapropiedad sedebesermuyprecavido alrnanejar lagasolina. La gasolina esextrernadamente inflamable ylosvapores p@rsonales el operador o sus ropas ya que puede encenderse. Lavarse la piel y cambiarse de ropas inmediatamente. a. Usar un recipiente aprobado de gasolina SOn explosives.. graves cuando Pueden se derraRla ocu rrir lesiorles gasolin_ sobre solamente. b. c. d. e. f. g. h. Apagar redes los cigarrillos, cigarros, pipas, y otras fuentes de combusti6n.
IMPORTANTE: Estaunidad seenviasingasolina oaceite enelmotor. Antesdeoperar lamaquina, asegurarse de cargar gasolina yaceite seg0nindicado en el manual separado del motor. NOTA: La referenda cortadora de troncos de operacidn. a la derecha o izquierda de la se observa desde la posicidn Fijaci6n de la lengUeta (Vet la Figura 2) Con ]a cortadora de troncos tedavia en posici6n vertical, extraer los dos pemos hexagonales, arandelas de seguddad y tuercas hexagonales del frente de] tanque reservofio.
Levantar ycorrer elcilind rohastaeltopedelavigay dentro delossoportes soldados. Fijarelimpulsor sobre el con Jnto de la cuSa y fijar a Quite la varilla de aceite de dep6sito expresada, que es Iocalizada delante del motor sobre la cima del tanque de dep6sito. Ver la Figura 5. Llene el tanque de deposito de Dexron Ill fluido de transmisi6n autom_tico o 10W el fluido iAH! hidr_ulico Compruebe el nivel fluido que usa la varilla de aceite. Vet la Figura 6.
Informacibn para conocer la maquina cortadora de madera UTILICE GAFAS DE SEGURIDAD VER DE FRENTE ES MEJOR QUE NOVER Lea este manual del operador y las reglas de seguridad antes de poner en funcionamiento b maquina cortadora de madera. Compare las ilustraciones que aparecen a continuaci6n con su equipo para familiadzarse con la ubicaci6n de los distintos controles y ajustes. Guarde este manual para referencias futuras.
Controles del motor Interruptorde detencien Oprima el bot6n para ponerlo en ON (encendido) antes del cebado para el arranque del motor, ponga el bot6n en OFF (apagado) para apagar el motor. Controlde obturacien El control de obturaci6n se utiliza para cebar el caP;_urador y ayudar a que el motor arranque. Manija del arraocador La manija del arrancador esta ubicada sobre el motor. Tire de la manija del arrancador para encender el motor.
NUNCA colocar ]as manos en el extremo entre el tronco y la curia cortadora. S6lo un adulto debe estabilizar el tronco y operar la manija de control, de manera qua el opemdor tenga pleno control sobre la estabilizaci6n del tronco y el movimiento de la curia cortadora. Espere hasta que el raotor funcione suavemente antes de cada ajuste de la obturaci6n. Si falla el motor, coloque la palanca de control en la posici6n CHOKE (obturaci6n), luego lentamente de nuevo hasta la posici6n RUN (funcionamiento).
PROGRAMA DE MANTENIMIENTO 0 t_ Lubricar viga y cufa O ?-am biar el liquido ¢ _ 4' -_ hidraulioo 3ambiar el filtro Mdrfulico /2 Cambiar el liquido del reservodo Inapeccionar el aceite del motor Cambiar el aceite del motor _) Limpiar el flltro de aire Umpiar Ja bujia Umpiar el motor Transporte de la cortadora de troncos Para mantener bien su equipo, deben efectuarse aiustes peri6dieamente. Seguir el programa de mantenhniento.
cionamiento el motor sin haber montado ADVERTENCIA: No ponga nunca en funtotalmente el filtro de afro. trabajar con querosen. Es un liquido ADVERTENCIA: Ser muy precavido al extremadamente inflamable. Cambiar el filtro bidrauiico cada 50 horas de Hagale un servicio al caducho coda 25 heros de funcionamiento o todas los temporadas. Realice el servicio del cartucho con mas frecuencia si operaci6R. Usar un filtro hidraulico de 10 micrones esta expuesto Filtrohidr ulico solamente. polvo.
Acopleflexibledela b0mba ajuste sin para primero el motor, desconectar ADVERTENCIA: Nunca efectuar ning_n el cable de la bujia y conectar]o a tierra col'_tra el motor. ,_ El acople flexible de la bomba es una inserci6n de nil6n de tipo "ara_a", ubicado entre la bombay el eje del motor. Con el tiempo, el acople se endurece y deteriora. Se necesita reemplaza r si se detecta vibraci6n o ruido proveniente del Area entre eJ motor y la bomba.
Bombadeengranajes Tornillo de engranajes / x i ! Insercion de la "arabia" de nil6n Mitades de acople Motor Figure 11 Neum ticos Leer la pared lateral del neumatico pot la presi6n recomendada. La presi6n m_xima del neumatico en todas las circunstancias es de 30 p.s.i. Debe mantenerse una presi6n igual en todos los neum_ticos.
AIfinaldelatemporada osilacortadora detroncos noseva a usarpot30diaso mas,prepararla paraalmacenamiento.
Problema Elcilindmnosemueve Causa Accibn correctiva posible 1 Eie_utodelim_lso/ 2 Lostapollesdeenvlosehalldeiadoell las manguerashidr_licas 3 Lostor_illosdegosici6_enelacople_o seha_ a_stadobien 4 Acoplefloio deleie 5 SeccionesdaEiadas delengra_aie 6 V_lvulade escapedaEiada 7 Tuber_sh]d_licas bloqueadas 8 N]veldeace_ incorrecto 9 V_lvuladi_ccionalda_adao bloqueada 1 _evolverla_nidadalCen_ro deSe_icioSears 2 [}es/:onec_ f I_ in_Rg_e/_ IlitJr_lica, ext[3_ lOS _a_ones (_ ellvlo y leconec_a[ la i_all_
Problema Causas ElmoloNunciona er{_ticamellte El EllOlO_CalieRla exeosptalfiellte NOcosta llOflco$ correctiva Filtro de aile s_cio 1 kimpiar el filtro de aile siguielldo las ]fistf u¢cioEl_$ eella Secoio_d_ ma£18R]mieRto 2 Tanque de combustiNe vac% o combustible raflcio 3 4 5 El _gulatJo f no esl_ en laI_osici6n OFF T_ber fa (Ie combustible bloqueada Cable(re b_ila desconectado 2 3 4 5 6 Ue£a__1taE]qlJecol_¢onlDifsl]_le l_s¢o M_e_ el regula(fo_a ON Umpia_ la luberia de cornbuslible Co_ectarel
(Estap_glnaesapllcableQ_flcamen_e enEstadosU_fldos deAmericay Oanad_) Senrs, Roebuck and Co., U.S.A. (Sears), Junta de Recursos Am bientales de Califor nin (CARB) y Agencin de Protection Ambiental de los Estndos U nidos (U.g.
Repair Protection Agreements Acuerdo Congratulations on making a smart purchase.Your new Craftsman® product is designed and manufactured for years of dependable operation. But like all products, it may require repair from time to time. That's when having a Repair Protection Agreement can save you money and aggravation.
Your Home For repair-in your home-of all major brand appliances, lawn and garden equipment, or heating and cooling systems, no matter who made it, no matter who sold it! For the replacement parts, accessories and owner's manuals that you need to do-it-yourself. For Sears professional installation of home appliances and items like garage door openers and water heaters, 1-800-4-MY-HOME Call anytime, _ (1-800-469-4663) day or night (U.S.A. www.sears.com and Canada) www.sears.
