Specifications

," %- r....
PROBLEM
Wgl not start
Hard to start
Engine will not turn over
Engine cricks but will net
start
- • ' ,,, ,,i
Excessive vibration
, H,,plm ,H,H mill rail mH
TROUBLESHOOTING POINTS
CAUSE
!: Oui oHueL t
2 Engine not "CHOKED" propedy 2
3 Engine fl_sd 3,
4 Bad_pad_ p{ug _ 4
5 Dldy alr fillar 5:
6 Dirty _a! rater 6.
7 Weter In fuel 7
8 Loses or d0magsd wldng B
9 Carburetor out ef adjustment 9
t0 Engine vaivee out of adjuslmen :
4.
6
7
1 Clulchroreke pods!netdepressed
2 Attachment clutch Is sngsged
3. Weak or dead b0_ery,
4: Blown fuss. '
_ Corroded batte_ far.rials
6 Loose ordamaged wiring
7 Faulty Ignition swileh:
g Faulty solsn0ld or stealer:
g Feugy opemlor presence switch(so)
f0
Dilly air filter "_
Bad sperk ptUg'r 2
' Week or d_ad battery 3.
Dirty fusi lifter 4
Slate or dldy fuel 5
Loose or demaged wiring, 6
Carb0retor outer ad us_'aant 7
Engine vsiv_s out el edluslment B
u i ,Jl mmHH N, m,
f
2,
3.
4
5
6
7.
8.
9
1 Weakordsadbatfsry
2 : Corroded bsitery terinlnels
3 Loose or damaged wldng
4 Faulty solenoid or starter
I CUlling to0.much gr0se,loo fast
1
3
4
1
2 ThrottleIn"CHOKE" postttbn, 2
3 Buil_i-up of grass, leeves an_ trash under mower. 3:
4 Dirty air rifler. 4,
5 Low ell levePdldy oil 5
CORRECTION
Faulty spark plug
, Dldy _dal filler
9 Stale or dirty fuel
9 Water In fuel
10, Spark plugwire 10osa.
11, Dirty engine sir ssrssn/ens
12 Dlrltylclogg_d_nulger
13 Loose or damaged wiring
! 4 Carburetor a_t of adjustment
15 Engtnsvanes outof edJuetn_aht
_, Worn, banlorlooseblade
2 Rent b{ademandrel
3 Loose/damaged part(s),
Ftfi lust tank
See "TO START ENGINE" in Operalten section
Walt several minutes befsre attempting to start.
Replace spark plug.
Cle_nJreplacs alrfilter,
Replace,fuel filter'
Drain fuel tank end carburalar, refill tank with fresh
gasoline end replace fuel fillar
Check all wldng,
See "TO Adjust Carburetor" tn Se^,iseAdjustments
SeCtiOn.
Contact an aulhorized servicecanlar/depadment
Clash/replace sir fliter
Raplans spa_k plug
Recharge or rephlco battery
Replace fuel f}_lar
Drain fuet tank end letlll with fresh gasoline
Check sit wiring,
See "To Adjust Carburetor" in Service Adjustments
section, '
Contact erl eulhorizsd service canlar/depsdmenL
i
Depress dutchferaks pedal
Disengage attachment clUlch
Recharge or replace baffery
Replace/usa
Clean battery larmlnois:
Check all wtdng
CbecWreplace tgnlllon switch
ChsckJreptace solenoid or slader
Contact an eulh0dzed servicecenlarldspedment
Rectmrgs or replace battery
Cfean bettery terminals
CIlack sii wiring.
Chbek/replans sotanold or starlet
Set la "Higher Cut" position/reduce speed
Adjust throttle control
Clean underside of mower houstng
Clean/replace air filter
Check ol_levsiichangs oil
6 Ctoan end regap or change spa_k plug;
7 Replace fuel filler.
8 Dra!n fuel tank end _ef_llwi_hIresh gasoline,
g Drain fuel tank.end carburetor, refill lank wlth flesh
gasoline and replace fuel filter •
'iO Connect and tighten spark pIug Wire.
'i1 Clean engine sir screen/fins,
!2 Cteentreplace muffler
t3 Choc k allwiring,
14 See "To Adjust Carburetor" in Service AdJuslmenls
section.
15 Contact _n authorized service cenlar/depa_nent
f. Replace blade Ttgt_tenblade bolt
2. Replace blade mandrel
3, Tighten loose pad(s) Replace damaged paris
2g