SEARS MODEL NUMBER 917.252532 OWNER'S MANUAL oAssembly ®Operation Customer Responsibilities o Service and Adjustments Repair Parts CAUTION: Read and follow all safety rules and instructions before operating this equipment.
SAFETY Practices RULES for Ride-On Safe Operation Mowers IMPORTANT: THiS CUTTING MACHINE iS C,.APABLE OF AMPUTATING HANDS AND FEET AND THROWING OBJECTS. FAILURE TO OBSERVE THE FOLLOWING SAFETY INSTRUCTIONS COULD RESULT iN SERIOUS iNJURY OR DEATH I.
PRODUCT CONGRATULATIONS on your purchase of a Sears Tractor. it has been designed, engineered and manufactured to give you the best possible dependability and performance. Should you experience any problem you cannot easily remedy, please contact your nearest Sears Authorized Service Center/Departmento We have competent, waif trained technicians and the proper tools to service or repair this tractor.. Please read and retain this manual.
TABLE OF CONTENTS SAFETY RULES ............................................................ 2 PRODUCT SPECIFICATIONS ...................................... 3 CUSTOMER RESPONSIBILITIES ..................... 3, 17-21 WARRANTY ...................... ;........................................... 3 TABLE OF CONTENTS ................................................. 4 INDEX ............................................................................ 4 TRACTOR ACCESSORIES ...........................................
ACCESSORIES AN ATTACHMENTS == = = = These accessories end attachments were available through most Sears retail outlets and service centers when the tractor was purchased. Most Sears stores can order these items for you when you provide the model number of your tractor MAINTENANCE ENGINE SPARK PLUG GAS CAN ENGINE OIL FUEL STABILIZER AIR FILTER % BLADES t BELTS PERFORMANCE Sears offers a wide variety of attachments that fit your tractor. you.
CONTENTS _1 ,,,H, ,=n,,,n, Parts Bag contents I OF HARDWA PAC '= shown full size Parts packed separately in carton Seat Mulcher Plate Metal (2) Screws Sheet #10q6 x t/2 O Steering Boot (1) Locknut 3/8-24 (1) Large Flat Washer Steering Wheel Video Cassette (1) Shoulder Bolt 5/16-18 @ (1) Washer (2_) (1) Hex Bolt 1/2-13 x 1 Manual ............ #10 x 5/8 ,, ,,,,, ,,,,,,,,, ,,,,,,, Parts bag contents , , (1) Leek Washer @ (2) Lock Washers , ==,, , =, ==..........
ASSEMBLY iiiiiiiillllllll ................. Your new tractor has been assembled at the factory with exception of those parts left unassembled for shipping purpose& To ensure safe and proper operation of your tractor all parts and hardware you assemble must be tightened securely, Use the correct tools as necessary to insure proper tightness. TOOLS REQUIRED FOR ASSEMBLY A socket wrench set will make assembly easier.
,,w,,,ll, l,,ri,lUll,,,llll ¸ ,,i ii ,ll,U ASSEMBLY CONNECT BATTERY (See Figs, 2 and 3) CAUTION: Do not short battery terminals. Before connecting battery, re- SEAT PAN bands, rings, etc+ move metal bracelets, wristwatch Positive terminal must be connected first to prevent sparking from accidental grounding+ Ull,i i,,11 ,,, = Remove cardboard packing from seat pan and lift seat pan to raised position. o Open battery box door.
ASSEMBLY = = = CHECK TIRE PRESSURE ASSEMBLE GAUGE DECK (See Fig. 5) The tires on your tractor were overinflated at the factory for shipping purposes. Correct tire pressure is important for best cutting performance. - DECK LEVELNESS FOR PROPER POSITION OF ALL See the figures that are shown for replacing motion and mower blade drive belts in the Service and Adjustments section of this manual Verify that the belts are routed correctly.
INSTALL MULCHER PLATE DEFLECTOR (See Figs. 6 & 7) . Instalf two latch hooks to mulcher plate using screw, washer, lock washer, and weld nut as shown., NOTE: Re-assemble weld nut to latch hook by inserting weld nut from the top with hook pointing down° o Tighten hardware securely., ° . . Raise and hold deflector shield in upright position,.
OPERATION These symbols may appear on your product or in literature supplied with the product, Learn and understand their meaning, E3 BATTERY CAUTION OR WARNING REVERSE FORWARD FAST SLOW ENGINE ON ENGINE OFF OIL PRESSURE CLUTCH LIGHTS ON LIGHTS OFF FUEL CHOKE MOWER HEIGHT DIFFERENTIAL LOCK PARKING BRAKE LOCKED UNLOCKED L REVERSE MOWER LIFT NEUTRAL ATTACHMENT CLUTCH ENGAGED HIGH LOW PARKING BRAKE ATTACHMENT CLUTCH DISENGAGED HYDROSTATIC DANGER, KEEP HANDS AND FEET AWAY IGNITION F
KNOW YOUR TRACTOR READ THIS OWNER'S MANUAL AND SAFETY RULES BEFORE OPERATING YOUR TRACTOR Compare the illustrations with yourtractor to fami!iarize yourself with the locations of various controts and adjustments. this manual for future reference° AMMETER IGNITION SWITCH Save LIFT LEVER PLUNGER THROTTLFJCHOKE CONTROL ATTACHMENT LIFT LEVER CLUTCH CLUTCHtBRAKE PEDAL LEVER PARKING HEIGHT ADJUSTMENT KNOB BRAKE MOTION CONTROL LEVER APPROXo SPEED 3 MPH 2 MPH 1MPH FREEWHEEL CONTROL FIG.
OPERATION ,,,111INIII,IIIII1,11111111 ii ii i i The operation of any tractor can result in foreign objects thrown into the eyes, which can result in severe eye damage. Always wear safety glasses or eye shields while operating your tractor or performing any adjustments or repairs. We recommend a wide vision safety mask over the spectacles or standard safety glasses. HOW TO USE YOUR TRACTOR TO SET PARKING BRAKE = (See Fig. 9) Your tractor is equipped with an operator presence switch,.
OPEFIATmON TO OPERATE MOWER TO OPERATE (See Fig. 10) ON HILLS i i Your tractor is equipped with an operator presence sensing switch. Any attempt by the operator to leave the seat with the engine running and the attachment clutch engaged will shut off the engine.
iiiiirlrr IIIIIIHIHI IIHIIHIIIIII, II,HIIIlll HI H I Illl,llll,lll HI II Ill II I OPERATION BEFORE CHECK o STARTING ENGINE THE ENGINE OIL LEVEL (See Fig. 9) The engine in your tractor has been shipped, from the factory, aiready filled with summer weight oil. Check engine oil with tractor on level ground.
,J,l,,J,l=t.l= OPEBATJO ,nni,un nn,,,uu = , = MOWING , = .... n , , u = ,,H,,i,i,uuu,,u TIPS MULCHING o Tire chains cannot be used when the mower housing is attached to tractor. o Mower should be properly leveled for best mowing performance_ See'q'O LEVEL MOWER HOUSING" in the Service and Adjustments section of this manual The left hand side of mower should be used for trimming.
i i i i,iiiiii,UlUUi CUSTOMER i .... lU,i Ul i i iiii i RESPONSiBiLiTIES i MAINTENANCE SCHEDULE .... REGUtaR SERVICE _ ,_ .....
CUSTOME mLITI TRACTOR TO SHARPEN Always observe safety rules when performing any maintenance Care should be taken to keep the blade balanced An unbalanced blade will cause excessive vibration and eventual damage to mower and engine, BRAKE OPERATION If tractor requires more than six (6) feet stopping distance at high speed in highest gear, then brake must be adjusted.
CUSTOMER BILITiES RESPON = H,u um, um, BATTERY ENGINE Your' tractor has a battery charging system which is sufficient for normal use_ However, periodic charging of the battery with an automotive charger will extend its life. LUBRICATION • Keep battery and terminals clean. • Keep battery bolts tight, • Keep small vent holes open (See "CONNECT BATTERY" in the Assembly section of this manual), • Recharge at 6 amperes for 1 hour.
AIR FILTER CLEAN (See Fig. 18) AIR SCREEN (See Fig. 19) Your engine will not run properly using a dirty air filter. Clean the foam pre-cleaner after every 25 hours of operation or every season.. Service paper cartridge every t00 hours of operation or every season, whichever occurs first, Air screen must be kept free of dirt and chaff to prevent engine damage from overheating.
CUSTOMER RESPONSIBILITIES MUFFLER CLAMP inspect and replace corroded muffler and spark arrester (if equipped) as it could create a fire hazard and/or damage.. SPARK PLUGS Replace spark ptugs at the beginning of each mowing season or after every 100 hours of operation, whichever occurs first. Spark ptug type and gap setting are shown in "PRODUCT SPECIFICATIONS" on page 3 of this manual. IN-LINE FUEL FILTER FUEL FILTER (See Fig. 20) FIG. 20 The fuel filter shoutd be reptaced once each season.
CAUTION: o o o = o BEFORE PERFORMING ANY SERVICE OR ADJUSTMENTS: Depress clutch/brake pedal fully and set parking brake, Place motion control lever in neutral (N) position. Place attachment clutch in "DISENGAGED" position. Turn ignition key "OFF" and remove key. Make sure the blades and all moving parts have completely stopped. Disconnect spark plug wire from spark plug and place wire where it cannot come in contact with plug. ] nn,uu , ,, .H=.............................
................................................... == , nmiHinlnl m,, SERVICE AND ADJUSTMENTS =1 nn,, = = TO LEVEL MOWER == ::::::::::::::::::::: HOUSING ADJUSTMENT (See Figs. 22 and 23) • Raise mower to its highest position, • At the midpoint of both sides of mower, measure height from bottom edge of mower to ground, Distance"A" on both sides of mower should be the same or within 1/4" of each other, o If adjustment is necessary, make adjustment on one side of mower only.
iiil,lll i, i,iii SERVmCE AN i ,ll,i TO REPLACE ii ADJUSTMENTS ii1,11 MOWER BLADE DRIVE WITH PARKING BELT BRAKE "ENGAGED" NUT "A" (See Fig. 26) The mower blade drive belt may be replaced without tools., Park the tractor on level surface. Engage parking brake BELT REMOVAL - Remove mower from tractor (See 'q_O REMOVE MOWER" in this section of this manual). . Work belt off both mandrel pulleys and idler pulleys_ ° Pull belt away from mower.
i i u lUn nlllU,, nl I,IH,, nlUllU nl,llUlJ,L _ SERVICE AND ADJUSTMENTS iii iii i ii Hlnnn TO ADJUST I I iiiiii1,11111 nu nil MOTION CONTROL LEVER (See TO ADJUST Fig. 29) If for any reason the motion control lever will not hold its position while at a selected speed, it may be adjusted at the friction pack located on the right side of transmission. Park tractor on level surface. Stop tractor by turning ignition key to "OFF" position, and engage parking brake.
,=,H !,=r,,,, , = '=,,=,,, ..................... = SERVICE AND ADJUSTMENTS ,=H ................................................ TO START ENGINE (See Fig. 31) =Hu WITH A WEAK uii=,,,, A_, A[ _ ,_ -- 'l H,,, ====,,,Hi,,,u 11,,, TO REPLACE BATTERY ......................... 1,1,, ,i CAUTION: Lead-acid batteries gener_ ateexplosivegases. Keepsparks, flame and smoking materials away from batteries. Always wear eye protection when around batteries. | | | | ! = • .
FINAL SETTING - TO ADJUST THROTTLE (See Fig. 33) CONTROL Start engine and atlow to warm for five minutes. Make final adjustments with engine running and shift/motion control lever in neutral (N) position. = Move throttle control lever to stow (,,=_) position.
' I="'H"= ' = = '== STORAGE 1,,,,11,,1,, = IMPORTANT: IT IS iMPORTANT TO PREVENT GUM DEPOSITS FROM FORMING IN ESSENTIAL FUEL SYSTEM PARTS SUCH AS CARBURETOR, FUEL FILTER, FUEL HOSE, OR TANK DURING STORAGE. ALSO, EXPERIENCE INDICATES THAT ALCOHOL BLENDED FUELS (CALLED GASOHOL OR USING ETHANOL OR METHANOL) CAN ATTRACT MOISTURE WHICH LEADS TO SEPARATION AND FORMATION OF ACIDS DURING STORAGE. ACIDIC GAS CAN DAMAGE THE FUEL SYSTEM OF AN ENGINE WHILE IN STORAGE.
PROBLEM CAUSE Will not start t 2, 3 4 5 6 7 CORRECTION Out of fuel Engine not "CHOKED" Engine flooded Bad spark plug Dirty air filter, Dirty fuel filter Water in fueL 1 2 3 4 5 6 7 properly Fill fuet tank See "TO START ENGINE" in Operation section, Wait several minutes before attempting to start Replace sparkplug Clean!replace air filter Replace fuel lilter Drain fuel tank and carburetor, refill tank with fresh gasoline and replace fuel filter Check afl wiring Contact an authorized service center/de
=['ROUBLESHOOTmNG PROBLEM CAUSE Engine continues to run when operator leaves seat with attachment clutch engaged 1 = .. CORRECTION ,1, ===..m.=..rl,.u. Faulty operator-safety Mower blades will not rotate Poor grass discharge t presence control system ,,,,,,,H= , ,,=,=,=,===,,i,,,======,= 1 2.. Worn, bent or ]oose blade Mower deck not level. 3. 4 Buildup of grass, leaves, and trash under mower.
TRACTOR -- MODEL NUMBER 917.252532 SCHEMATIC SLACK RED BATTERY RED ' RED ' FUSE 30 AMP. AMMETER STARTER 8LACK 2_- -r-2_- WHITE D 'O;Of S5&-.Oi-D' CLUTCH 1BRAKE (PEDAL UP) I WHITE IGNITION SWITCH _._ _ 1_ _(_1 (NOT OCCUPIED) SEAT SWITCH 1 q /';, i_c" t k ' I F I BLACK F H 8LACK IGNITION UNIT AFTER FIRE SOLENOID CONNECTOR GROUNDING ! t.__..____O CHARG1NG SYSTEM OUTPUT 3 AMP DC @ 3600 RPM SPARK PLUG 28VOLTSAC MIN.
REPAIR PARTS TRACTOR - - MODEL NUMBER 9!7.252532 ELECTRICAL 22 21 26 42 36 36 35 34 32 3'1 \ 32 39
REPAIR PARTS TRACTOR - - MODEL NUMBER 917.252532 ELECTRICAL KEY NO. PART NO.
REPAIR PARTS TRACTOR CHASSIS - - MODEL NUMBER 917.
REPAIR PARTS TRACTOR CHASSIS - - MODEL NUMBER 917.252532 AND ENCLOSURES KEY NO. PART NO.
REPAIR PARTS TRACTOR"" MODEL NUMBER 917.
REPAIR PARTS TRACTOR -- MODEL NUMBER 917.252532 DRIVE KEY NO.
REPAIR PARTS TRACTOR STEERING - - MODEL NUMBER 917.
REPAIR PARTS TRACTOR STEERING -- MODEL NUMBER 917.252532 ASSEMBLY KEY NOo PART NO.
REPAIR PARTS TRACTOR -- MODEL NUMBER 917.252532 SEAT ASSEMBLY W 6 22 21 23 KEY NO. PART NO. 1 2 3 4 5 6 7 8 9 10 12 13 t4 140123 140551 STD523710 19131610 145006 STD541437 124t81X 17490616 19131614 140552 121246X 121248X 72050411 DESCRIPTION Seat Bracket, Pivot, Seat Bolt Washer 13/32 x I x 10 Gauge Clip, Pushqn Hinged Nut Spring, Seat Screw, Thd,, Roll,, 3/8-16 x 1 Washer t3/32 xt x 14 Gauge Pan, Seat Bracket, Switch Mounting Bushing, Snap Bolt, Carriage t14-20 x 1-3/8 KEY NO. PART NO.
REPAIR PARTS TRACTOR -- MODEL NUMBER 917.252532 23 DECALS 13 9 t5 6 t 3 18 7 18 19 4 16 7 2 2 5 11 10 8 \ 22 13 2O 17 KEY NO. 1 2 3 4 5 6 7 8 9 10 11 !2 13 14 PART NO. 138955 149917 143735 143736 132674 t33644 142235 133178 128314 137537 4900J 146046 138145 136832 DESCRIPTION KEY NO. Decal, Decal Decal Decal Decal Decal Decal Decal Decal Decal Deca Decal, Decal, Decal, 15 16 17 18 19 20 2! 22 23 ------ Operating Instruction Fend Auto Trans Srs Wht Hood, RIH. Hood, L.
REPAIR PARTS TRACTOR - - MODEL NUMBER 917.252532 ENGINE 3 72 62 81 13 14 , 15 44 / 38 78 46 33 1 37 40 33 23 29 \ OPTIONAL EQUIPMENT Spark Arrester 42
REPAIR PARTS TRACTOR -- MODEL NUMBER 917.252532 ENGINE KEY NO_ PART NO. 1 2 132759 17720410 3 150458 4 13 14 15 16 23 24 29 31 32 33 37 38 137352 272293 13280324 13200300 STD551237 128953X STD601005 t37180 I09202X t23549X 123487X 137040 --- 40 44 124028X 174904t2 46 62 72 78 81 1909'1416 STD55113t 71070512 17490620 128861 NOTE: DESCRIPTION Control, Throttle Screw, Hex Head, Thread Cutting 1/4-20 x 5/8 Engine, B&S, 15Hp Platinum Model No. 28N707, Type NO..
REPAIR PARTS TRACTOR MOWER - - MODEL NUMBER 917.252532 LIFT 28 27 26 25 24 23 22 5 21 3O 6 12 13 19 20 13 15 161718 ,_ 2O 32 \ 19 15 13---_ 32 44 20
REPAIR PARTS TRACTOR MOWER - - MODEL NUMBER 917.252532 LIFT KEY NO. PART NO.
REPAIR PARTS TRACTOR-MOWER MODEL NUMBER 917.252532 DECK 76 77 68 "" 40 105 102 34 33 32 58 1 113 111 \ 14 'il \ 117 119 _223 24 2 118 28 " 27 29 18
REPAIR PARTS TRACTOR MOWER - - MODEL NUMBER 917.
REPAIR PARTS TRACTOR HYDRO GEAR TRANSAXLE - - MODEL NUMBER - MODEL NUMBER 917.
REPAIR PARTS TRACTOR HYDRO GEAR TRANSAXLE - - MODEL NUMBER - MODEL NUMBER KEY PART NO. NO.
REPAIR PARTS BRIGGS & STRATTON TRACTOR - - MODEL NUMBER ENGINE NUMBER - MODEL 28N707, 917.252532 TYPE NUMBER 0173-01 230 552 614 230 9 @_ 634A o 307 635 337 f "k REQUIRES SPECIAL TOOLS TO INSTALL.
REPAIR PARTS BRIGGS & STRATTON TRACTOR - - MODEL NUMBER ENGINE - MODEL NUMBER 95 117 634 28N707, 917.252532 TYPE NUMBER 0173-01 i1,, 127 138 106 987 illlll 634B 104 142 I 1 105 147 "'741 1033 VALVE OVERHAUL ilpl , 130 __ 95 .......... _123 KIT iiii ii_llU _UIII !l 147 98 I 634B _ I N i 137 51 REQUIRES SPECIAL TOOLS TO INSTALL.
REPAIR PARTS BRIGGS TRACTOR -- MODEL NUMBER ENGINE NUMBER & STRAI-f'ON 3 523 - MODEL = i HI=IIII,Ill ....................... 20 634A 917.252532 28N707, TYPE NUMBER 0173-01 ,, =l H 842 524 868 868A 467 284A ,842 537 171 2 9 358 GASKET SET 137 977 CARBURETOR GASKET SET _224 304 L 305_ ....................
REPAIR PARTS TRACTOR BRIGGS & STRATTON ENGINE - - MODEL NUMBER - MODEL NUMBER 917.
REPAIR PARTS TRACTOR BRIGGS & STRATTON KEY PART NO. NO.
REPAIR PARTS BRIGGS & STRATTON KEY PART NO. NO.
SUGGESTED GUIDE FOR SiGHTiNG SLOPES FOR SAFE OPERATION ONLY RIDE UP AND NOT ACROSS HILL SIGHTING GUIDE SIGHT AND HOLD THIS LEVEL WITH SKY LINE OR TREE. U'l (O 15 ° MAX. Operate your Tractor up and down the face of siopes"(not _ ........ I greater than 15 tipping ), never oracross face. Make turnsextreme gradually to prevent loss ofthe control. Exercise I! caution when changing direction ,I jill iiiiiiiiiiii on slopes.
£RRFTSMRN® OWNER'S MANUAL MODEL NO. 917.252532 15.0 HP ELECTRIC START 3 in One Convertible 42" MOWER AUTOMATIC (HYDROSTATIC) DRIVE LAWN TRACTOR Each tractor has its own model number. its own model number_ Each engine has The model number for your tractor will be found on the model plate located under the seat. The modeE number for your engine will be found on the blower housing of the engine.
