Owner's Manual CRI FTSMIIN° 16.0 HE 42" Mower Electric Start 6 Speed Transaxle Model No. 917.273352 [_ differently built engines. Before operates you start the This productfrom haspreviously a mowemission engine which engine, read and understand this Owner's Manual. For answers to your questions about Read and follow all Safety Rules and instructions before this product, Call: operating this equipment. Sears Craftsman Help Line 5 am o 5 pm, Men o Sat 1_800-659°5917 Sears, Roebuck and Co.
Maintenance.........................................17 Service andAdjustments......................21 Storage................................................. 27 Troubleshooting....................................28 Repair Parts.......................................... 32 Sears Service.........................Back Cover Warranty................................................. 2 SafetyRules ........................................... 3 ProductSpecifications............................
mMPORTANT: This cutting machine is capable of amputating hands and feet and throwing objects. Failure to observe the following safety instructions could result in serious injury or death. _IWARNmNG: In order to prevent accidental starting when setting up, transporting, adjusting or making repairs, always disconnect spark plug wire and place wire where it cannot contact spark plug. dHLWARNING: Do not coast neutral, you may lose control down a hill in of the tractor.
DO: * Never carry children. They may fall off and be seriously injured or interfere with safe machine operation. Never allow children to operate the machine. Mow up and down slopes, not across. Remove obstacles such as rocks, tree limbs, etc. Watch for holes, ruts, or bumps. Uneven terrain could overturn the machine. Use extra care when approaching blind corners, shrubs, trees, or other objects that may obscure vision. Taft grass can hide obstacles. Use slow speed.
Be sure the area is clear of other people before mowing. Stop machine if anyone enters the area. Never carry passengers or children even with the blades off. Do not mow in reverse unless absolutely necessary. Always look down and behind before and while backing. Never carry children. They may fall off and be seriously injured or interfere with safe machine operation. Keep children out of the mowing area and under the watchful care of another responsible adult. Be alert and turn machine enter the area.
PRODUCT SPECIFICATmONS Gasoline 1.25 Capacity and Unleaded Type: Regular Oil Type SAE 30 (above32°F) IAPFSG-SL): SAE 5W-30(below Oil Capacity: 3.0 Pints Spark (Gap: Champion Plug: .030") 32°F RC12YC 1.1 1.4 2.2 3.4 4.3 5.5 1.7 Tire Pressure: Front: Rear: 14 PSI 12 PSI Charging 3 Amps 5 Amps Speed System: Battery: Blade 27-35 REPAmR 28 230 U1R Ft. Lbs. CONGRATULATmONS on your purchase of a new tractor.
Steering Wheel Steering Wheel Insert
Your new tractor has been assembled at the factory with the exception of those parts left unassembbd for shipping purposes. To ensure safe and proper operation of your tractor all parts and hardware you assemble must be tightened securely. Use the correct tools as necessary to insure proper tightness. Review the video cassette before you begin. TOOLS REQUIRED ASSEMBLY A socket wrench easier. Standard are listed below.
5. 6. Pivot seat and pan forward and assemble adjustment knob and fiat washer loosely. Do not tighten. Lower seat into operating position and sit in seat. 7. Slide seat until a comfortable position is reached which atlows you to press clutch/brake pedal all the way down. 8. Get off seat without moving its adjusted position. 9. Raise seat and tighten adjustment knob securely. Seat NOTE: You may now roll or drive your tractor off the skid.
CHECK TIRE PRESSURE The tires on your tractorwere overinfiated at the factoryfor shipping purposes. Correcttire pressure is importantfor best cutting performance. Reducetire pressureto PSI shown in "PRODUCTSPECIFICATIONS"section of this manual. V"CHECKMST Before you operate and enjoy your new tractor, we wish to assure that you receive the best performance and satisfaction from this Quality Product. Please review the following checklist: ,/All assembly instructions have been completed.
These symbols may appear on your tractor Learn and understand their meaning. or in literature R N H L I\1 REVERSE NEUTRAL HIGH LOW CHOKE supplied with the product.
KNOW YOUR TRACTOR READTHINS OWNER'SMANUAL AND SAFETY RULES BEFOREOPERATmNG YOUR TRACTOR Comparethe illustrationswith your tractorto familiarizeyourselfwith the locationsof various controls and adjustments. Savethis manualfor future reference.
The operation of any tractor can result in foreign objects thrown into the eyes, which can result in severe eye damage. Always wear safety glasses or eye shields while operating your tractor or performing any adjustments or repairs. We recommend a wide vision safety mask over spectacles or standard safety glasses. HOW TO USE YOUR TRACTOR mMPORTANT: Leaving the ignition switch in any position other than "STOP" will cause the battery to discharge and go dead.
The average lawn should be cut to approximately 2-1/2 inches during the cool season and to over 3 inches during hot months. For healthier and better looking lawns, mow often and after moderate growth. For best cutting performance, grass over 6 inches in height should be mowed twice. Make the first cut relatively high; the second to desired height. TO OPERATE If slowing is necessary, move throttle control lever to slower position.
ADD GASOUNE Fill fuel tank to bottom , of filler neck. Do not overfill. Use fresh, clean, regular unleaded gasoline with a minimum of 87 octane. (Use of leaded gasoline will increase carbon and lead oxide deposits and reduce vah!e life). Do not mix oil with gasoline. Purchase fuel in quantities that can be used within 30 days to assure fuel freshness. choke _CAUTmON: Wipe off any spilled oil or fuel. Do not store, spill or use gasoline near an open flame.
MOWING TIPS If grass is extremely tall, it should be mowed twice to reduce load and possible fire hazard from dried clippings. Make first cut relatively high; the second to the desired height. Do not mow grass when it is wet. Wet grass will plug mower and leave undesirable clumps. Allow grass to dry before mowing. Always operate engine at full throttle when mowing to assure better mowing performance and proper discharge of material.
AS YOU COMPLETE REGULAR SERVICE /_J/_'_ Check Tire BrakePressure Operation Check _1_ T Check Operator Presence Interlock Systems R Check for Loose Fasteners A Sharpen/Replace C Lubrication 0 Check Battery a Clean Mower E R VICED I_ and If If I_s Blades If Level If 1_4 Battery and Terminals I_ If i/ Cooling Check V-Belts I_ Check Engine Oil Level I_ Change Engine Oil (with oil filter) Engine Oil (without E Change N Clean Air Filter G Clean Air Screen I Inspect
TRACTOR Alwaysobserve safety ruleswhen performing any maintenance. BRAKE OPERATmON If tractor requiresmore than five (5) feetto stop at highest speed in highestgear on a level,dry concreteor pavedsurface,then brakemust be checked and adjusted.(See "TOADJUST BRAKE"in the Serviceand Adjustmentssection of this manual). TmRES Maintain properair pressure in all tires (See "PRODUCTSPECIFICATIONS" sectionof this manual). Keeptires free of gasoline,oil, or insect controlchemicalswhich can harm rubber.
BATT E RY NOTE: Although multi-viscosity oils (5W30, 10W30 etc.) improve starting in cold weather, the oils will resuJt in increased oil consumption when used above 32°R Check your engine oil level more frequently to avoid possible engine damage from running low on oil. Change the oil after every 25 hours of operation or at least once a year if the tractor is not used for 25 hours in one year. Check the crankcase oil leveJ before starting the engine and after each eight (8) hours of operation.
ENGmNE OraLFmLTER Replacethe engine oil filter every season or every other oil change if the tractor is used morethan 100 hours in oneyear. AIR FILTER Yourenginewill not run properly using a dirty air filter. Replacepre-cleanerafter every 25 hours of operationor every season. Service paper cartridge every 100 hoursof operationor every season, whicheveroccurs first. Service air cleaner moreoften under dusty conditions. 1. Pull up on air filter cover handleand rotate towardsengine. 2. Removecover. 3.
We do not recommend using a garden hose or pressure washer to clean your tractor unless the engine and transmission are covered to keep water out. Water in engine or transmission will shorten the useful life of your tractor. Use compressed air or a leaf blower to remove grass, leaves and trash from tractor and mower. Clean engine, battery, seat, finish, etc. of all foreign matter. Keep finished surfaces and wheels free of all gasoline, oil, etc. Protect painted surfaces with automotive type wax.
2. Slide mower under tractor with deflec- FRONT-TO-BACK ADJUSTMENT mMPORTANT: Deck must be level side-to tor shield to right side of tractor. 3. Lower lift lever to its lowest position. 4. Connect front links to mower deck and 5. side. If the following front-to-back adjustment is necessary, be sure to adjust both front links equally so mower will stay level side4o-side. secure with retainer springs.
TO REPLACE I_OWER BLADE DRmVE BELT The mower blade drive belt may be replaced without tools. Park the tractor on level surface. Engage parking brake. BELT REMOVAL 1. 2. 3. 2. 3. Measure distance between brake operating arm and nut "A" on brake rod. 3. If distance is other than 1-1/2", loosen jam nut and turn nut "A" until distance becomes 1-1/2". Retighten jam nut against nut "A". 4. Road test tractor for proper stopping distance as stated above. Readjust if necessary.
5. 6. FRONT Make sure belt is in all pulley grooves and inside all belt guides and keepers. Install mower (See "TO INSTALL MOWER" in this section of manual). WHEEL The front wheel camber, contact service center. TO REMOVE Center TransaxUe PuUUey be in neutral should NEU- also prevents If steering horizontal positioned ing wheel horizontal. Adjustment STEERmNG WHEEL FOR REPAmRS tire dry rot and corrosion. Washers Ring Axle Cover \, freely, the transaxle is in neutral. 2.
2. Connectone end of the BLACKcable to the NEGATIVE(-) terminal (C) of fully charged battery. 3. Connectthe other end of the BLACK cable (D) to good chassisground, awayfrom fuel tank and battery. TO REMOVECABLES, REVERSE ORDER1. BLACKcable first from chassis and then from the fully charged battery. 2. RED cable last from both batteries. Terminal Cover Keps Nut "-_. Positive (Red) CaMe Hex Bolt Negative (Black) Cable TO REPLACE HEADUGHT BULB 1. Raise hood. 2.
mMPORTANT: Damage to the needle valve and the seat in carburetor may result if screw is turned in too tight. Maintenance, repair, or replacement of the emission control devices and systems, which are being done at the customers expense, may be performed by any non-road engine repair establishment or individual. W]arranty repairs must be performed by an authorized engine manufacturer's service outlet. TO ADJUST THROTTLE PRELIMINARY SETTING - 1.
Immediately prepare your tractor for storage at the end of the season or if the tractor will not be used for 30 days or more. blended fuels (called gasohol or using ethanol or methanol) can attract moisture which leads to separation and formation of acids during storage. Acidic gas can damage the fuel system of an engine while in storage. Empty the fuel tank by starting the engine and letting it run until the fuel lines and carburetor are empty.
TROUBLESHOOTmNG CHART: See appropriate section in rnanuam unmess directed PROBLEi_ CAUSE Wiii not start 1. 2. 3. Out of fuel. Engine not "CHOKED" properly. Engine flooded. 4. 5. 6. 7 Bad spark plug. Dirty air filter. Dirty fuel filter. Water in fuel. 8. 9. Loose or damaged wiring. Carburetor out of adjustment. Engine turn wiii 1. 2. 3. 4. 5. not qualified 1. 2. 3. 4. 5. 8. Engine valves out of adjustment. 8. 1. 1. Depress Clutch/brake pedal not depressed. Attachment clutch is engaged.
TROUBLESHOOTmNG CHART: See appropriate section in manual unless directed to Sears service center PROBLEM Loss of power CAUSE CORRECTION 1. Cutting too much grass/too fast. 2. Throttle in "CHOKE" position. 3. Build-up of grass, [eaves and trash under mower. 1. Raise cutting height/reduce speed. 2. Adjust throttle control. 3. Clean underside of mower 4. 5. 6. Dirty air filter. Low oil level/dirty o1[. Faulty spark plug. 4. 5. 6. 7. 8. Dirty fuel filter. Stale or dirty fuel. 9. Water in fuel. 10.
TROUBLESHOOTmNG CHART: See appropriate PROBLEM Mower blades wiii not rotate section Obstruction mechanism. 2. Worn/damaged mower belt. Frozen idler pulley. Frozen blade mandrel. in clutch speed drive 1. Engine 2. 3. Travel speed Wet grass. 4. 5. Mower deck not level. Low/uneven tire air pressure 6. Worn, 7. 8. Buildup of grass, leaves and trash under mower. Mower drive belt worn. 9. Blades too slow. too fast. bent or loose improperly blades blade. installed. used. 11.
TRACTOR o o MODEL NUMBER 917.273352 SCHEMATmC BATTERY I RED O: REo FUSE I I WH,TE ,© r--I , _,,' i /_ ___( )G II i I I AI( _..... i STARTER , BLBCK SOLENOID (PEDAL UP) WHITE SWITCH WHITE WHITE II _-,-I-A III I I BLACK BLACK JA I (_ I I ........ I (_ BLACK fTTM-E_lf _ L-U].
TRACTOR - - MODEL NUMBER 917.
TRACTOR ° ° MODEL NUMBER 917.273352 ELECTRmCAL KEY PART NO+ NO+ DESCRmPTmON 1 2 8 16 21 22 24 25 26 27 2B 29 30 33 40 41 42 43 45 52 90 Battery Bolt Hex Hd 1/4-20 uric x 3/4 Box Battery Fender Switch, Hnterlock Harness Asm Light W/4152j Bulb Light #1156 CabIe Battery 6 Ga+ 11" red Cabie Battery 6 Ga+w/16 wire red Fuse 20 AMP Nut, Keps Hex 1/4-20 uric Cabte Ground 6 Ga.
TRACTOR - - MODEL CHASSmS AND ENCLOSURES NUMBER 917.273352 29 212 / 28 39 166 31 @/5 @/5 209 208 209 208 6O 6O ,209 37 _,209 209 14 208 74 chassis-Laser 34 -It.
TRACTOR oo MODEL NUMBER 917.273352 CHASSmS AND ENCLOSURES KEY PART NO. NO. DESCRiPTiON 1 2 5 9 10 11 13 14 17 18 26 28 29 30 31 37 38 39 60 64 74 142 143 144 145 166 206 207 208 209 212 --- Chassis Stamping Drawbar Bumper Hood/Dash Dash Bolt, Carriage 3/8-16 x 1 Panel, Dash, L.H= Panel, Dash, R.H.
TRACTOR GROUND DRIVE 4 o o MODEL NUMBER 917.273352 150 5 48 151 .
TRACTOR o o MODEL NUMBER 917.273352 GROUND DRmVE KEY NO. PART NO.
TRACTOR o o MODEL NUMBER 917.273352 STEERINGASSEMBLY _ 38 1 It T_--42 67 J 67 46 47 67 65 / , 26 'l j, _ 40 _ 10 steering pl.
TRACTOR STEERmNG ASSEMBLY o o MODEL NUMBER 917.273352 KEY PART NO. NO. DESCRiPTiON 1 2 3 4 5 6 7 8 9 10 11 12 13 15 17 26 28 29 30 32 36 37 38 39 40 41 42 43 44 46 47 51 54 65 67 68 71 82 88 91 95 Steering Wheel Axle Assembly STMP Dropped STL SpindIe Assembly, L=H= Spindle Assembly, R=H. Bearing, Race, Thrust, Hardened Washer 25/32 x 1-5/8 x 16 Ga.
TRACTOR o o MODEL NUMBER 917.273352 ENGmNE 2 3 /m.\ 72 1 81 13 4 78 38 14 33 31 29 23 OPTIONAL EQUIPMENT Spark Arrester engine-bs.lcyl KEY PART NO. NO.
TRACTOR ° ° MODEL NUMBER 917.273352 SEAT ASSEMBLY 10 22 21 5 \ 11 17 12 seat It.knob 9 KEY NO. PART NO. DESCRIPTION 1 2 3 4 5 6 7 8 9 10 11 12 188716 180166 71110616 19131610 145006 STD541437 124181X 17000616 19131614 180186 166369 121246X Seat Bracket, Pivot, Seat Bolt Washer 13/32 x 1 x 10 Ga. Clip, Push-In Hinged Nut Spring, Seat Screw 3/8-16 x 1-1/2 Washer 13/32 x 1 x 14 Ga. Pan, Seat Knob Seat Bracket, Switch Mounting KEY NO, PART NO.
TRACTOR o o MODEL NUMBER 917.273352 DECALS 6 11 7 14 10 14 KEY NO. PART NO. DESCRIPTION 1 2 3 4 6 7 9 10 11 156368 189244 171704 179128 133644 189263 163204 149516 156439 Decal Fender Opt.
TRACTOR o o MODEL NUMBER 917.273352 UFT ASSEMBLY 7 3 13 2 5 11 4 13 19 \ 19 Fift-rh=lpiece KEY NO. PART NO. DESCRIPTION 1 2 3 4 5 6 7 8 11 12 13 15 159460 159471 105767X 12000002 19211621 120183X 125631X 122365X 139865 139866 STD624008 173288 Lift Lever hner Wire Assembly Shaft Assembly, Lift Pin, Groove E-Ring Washer 21/32 x 1 x21 Ga= Bearing, Ny!on Grip, Handle, Fluted Button, PEunger, Red Link, Lift, L.H= Link, Lift, R.H. Retainer Spring Link, Front KEY NO. PART NO.
TRACTOR o o MODEL NUMBER 917.
TRACTOR oo MODEL NUMBER 917.273352 MOWERDECK KEY PART NO. NO. 1 2 3 4 5 6 8 9 10 11 --13 14 15 16 18 19 20 21 23 24 25 26 27 28 29 30 31 32 33 34 36 KEY PART NO. NO. DESCRiPTiON 165892 STD533107 138017 165460 STD624008 178024 850857 STD551137 140296 Mower Deck Assembly, 42" Bolt Bracket Assembly, Sway Bar, Front Bracket Sway Bar 38/42" eck Retainer Spring Bar Sway Deck Bolt, Hex 3/8-24 x 1.25 Gr.
DANA TRANSAXL£ TRACTOR ° ° MODEL NUMBER o o MODEL NUMBER D4360=140 46 917.
DANA TRANSAXLE TRACTOR o o MODEL NUMBER o o MODEL NUMBER D4360°140 KEY NO. PART NO.
TRACTOR o ° MODEL NUMBER 917.273352 BRmGGSENGmNE-MODEL NUMBER31C707,TYPE NUMBER0230-E1 11 25_ .
TRACTOR o o MODEL NUMBER 917.273352 BRmGGS ENGmNE=MODEL NUMBER 31C707,TYPE NUMBER 0230=E1 d 1095 VALVE GASKET 617 238 0 SET 1022 868 35 13_' _.
TRACTOR o ° MODEL NUMBER 917.273352 BRmGGS ENGmNE-MODEL NUMBER 31C707,TYPE NUMBER 0230-E1 108A _ 130 _ _ 231 95 _' 987 634A,_ 93t e.
TRACTOR o o MODEL NUMBER 917.273352 BRmGGS ENGmNE-MODEL NUMBER 31C707,TYPE NUMBER 0230oE1 305A _ 3041 1265 968 729 801 (_ 697 _ 37 74 603 @ 310 1 73_ 67_'46 _ _7_7 _ 60_ 75@ 1070 _ 802 (_ _7-q-- _OlA (_ 1005 363 783A_ 544A 513 803A _A ] 31o 783 @ 1083 _/311A NOTE: For Replacement Starter Motor, See Reference 309.
TRACTOR o ° MODEL NUMBER 917.273352 BRmGGS ENGmNE-MODEL NUMBER 31C707,TYPE NUMBER 0230-E1 KEY NO. PART NO.
TRACTOR oo MODEL NUMBER 917.273352 BRmGGSENGmNE=MODEL NUMBER310707,TYPE NUMBER0230=E1 KEY NO. PART NO.
SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION ONLY RIDE UP AND DOWN HILL, NOT ACROSS HILL L_ 15 DEGREES MAX. _ down the face of slopes, never across the face. Do not mow ARNING: To avoid serious injury, operate your tractor and slopes greater than 15 degrees. Make turns gradually to up prevent tipping or loss of control. Exercise extreme caution when changing direction on slopes.
Your Home For repair - in your home - of all major brand appliances, lawn and garden equipment, or heating and cooling systems, no matter who made it, no matter who sold it! For the replacement parts, accessories and owner's manuals that you need to do-it-yourself. For Sears professional installation of home appliances and items like garage door openers and water heaters. 1-800-4-MY-HOME ® (1-800-469-4663) www.sears.com Anytime, day or night (U.S.A. and Canada) www.sears.
