Owner`s manual

....... i1,,i, _,,i i ii_l,l_,,i,Wl,i1,1,1,11,1, i ...... i ,i......................i,i,i,,i,,,,i,ij i i....
TROUBLESHOOTING POINTS
................... II ,i, ,i,,i i,,
PROBLEM
. IIIP
Will not start
Hard to start
Loss of power
............... i[,i
Engine overheats
i iii iiii ],lWl, ,,_.....
Excessive bounce/
difficult handling
Sell balls up or clumps
Engine runs but tiller
won't move
Engine runs but labors
when tilling
CAUSE
1,, Out of fuel.
2. Engine net "CHOKED" properly.,
3 Engine flooded,
4. Dirty air cleaner.
5. Water in fuel
6. Clogged fuel tank,
7. Loose spark ptug wire.
8. Bad spark plug or improper gap.,
9,, Carburetor out of adiustmenL
10. Fuel shut-off valve is closed.
I, Throttle control not set properly..
2. Dirtyair cleaner,
3 Bad spark plug or improper gap.
4, Stale or dirty fuel_
5, Loose spark plug wire.
6. Carburetor out of adjustment.
t., Engine ls overloaded.
2. Dirty air cleaner.
3, Low oil level/dirty oil,,
4, Faulty spark plug,
5 Ollinfuel.
6. Stale or dirty fuel
7, Water in fuel
8, Clogged fuel tank.,
9, Spark plug wire loose.
10. Dirtyengine atr screen 10,
tl. Dirtylclogged muffler. 11
12, Carburetor out of adjustment t2.
13, Poor compression, t3o
, UII, I'1 !:[y! ' i ii1,, ,i,1,1 I] I::':?
1, Low otl levelldirty otl. 1,
2, Dirty engine air screen 2,
3. Dirty engine_ 3,,
4., Partially plugged muffler. 4,
5 Improper carburetor adJustment. 5.
, ill
1. Ground too dry and hard t.
1 Ground too wet
, , ,,,,,,,,,,,,,,,,,,,,,,,,,,,,,,,,,,, ..................
CORRECTION
1,, Fill fuel tank
2. See "TO START ENGINE" tn Operation section,
3,, Wait several minutes before attempting to start,
4,, Clean or replace air cleaner cartridge,
5. Drain fuel lank & carburetor, refill tank with fresh gas,
6. Remove fuel tank and clean
7 Make sure spark ptug wire Is seated properly on plug.
8. Replace spark plug or adjust gap,
9. Make necessary adjustments.,
t0, Open valve,
.........: .................... i i iiww,,,i
1. Place throttle control in "FAST" position
2 Clean or replace air cleaner cartridge
3. Replace spark plug or adjust gap.,
4. Drain fuel tank and refill with fresh gasoline.
5. Make sure spark plug wire is seated properly on plug,
6. Make necessary adjustments°
1, Set depth stake for shallower tilling.
2, Clean or replace air cleaner cartridge.
3, Check oil leve!/change oli,
4. Clean and regap or change spark plug,,
5, Drain & clean fuel tank and refill, and clean carburetor,.
6. Drain fuettank and refi!l with fresh gasoline,
7, Drain fuel tank & carburetor, refill tank with fresh gas_
8, Remove fuel tank and dean.
9, Connect and tighten spark plug wire,.
Clean engine air screen
. Clean/replace muffler,
Make necessary adjustments,
Contact an authorized service centerldepartment.
i iii1'iii ,i,,11,,
Check oil leve!/change oil,
Clean engine air screen
Clean cylfnder fins, air screen, and muffler area.,
Remove and clean muffler_
Adjust carburetor to richer position
Moisten ground or wait for more favorable soil
conditions,
1., Wait for more favorable soil conditions
.............. i,ii1,1,,,,,,,11
1. Ddve control bar is not engaged,
2. V-belt not correctly adjusted,
3, V-belt is off pulley(s).,
1. Tilling too deep.,
2. Throt'Je control not propedy adjusted,
3, Carburetor out of adjustmenL
1, Engage drive control
2, Inspect/adjust V-belt,
3_ Inspect V-belt
t,, Set depth stake for shallower tilling,
2. Check throttle centre1setting,,
3, Make necessary adjustments°
21