Owner's Manual ICRIIFTSMRN'J 6.0 HORSEPOWER 22" REAR DISCHARGE ROTARY LAWN MOWER Model No. 917.377171 • • • • • • Safety Assembly Operation Maintenance Espa5ol Repair Parts CAUTION: Read and follow all Safety Rules and Instructions before operating this equipment Seam, Roebuck and Co., Hoffman Estates, IL 60179 Visitour Craftsmanweb_te:www.sears.
Warranty ............................................... Safety Rules ......................................... Assembly .............................................. Operation .............................................. Maintenance Schedule ...................... Maintenance ....................................... 2 2 5 6 11 11 Product Specifications ........................ 12 Service and Adjustments .................... 14 Storage ............................................... 16 Troubleshooting .
• Stoptheblade(s) whencrossing gravel drives, walks,orroads. • Stop the engine (motor) whenever you leave the equipment, before cleaning the mower or unclogging the chute. • Shut the engine (motor) off and wait until the blade comes to complete stop before removing grass catcher. • Mow only in daylight or good artificial light. • Do not operate the machine while under the influence of alcohol or drugs. • Never operate machine in wet grass.
_Look for this symbol to point out important safety precautions. It means CAUTION!!! BECOMEALERT!!T YOUR SAFETY IS INVOLVED. _, WARNING: In order to prevent accidental starting when setting up, transporting, adjusting or making repairs, always disconnect spark plug wire and place wire where it cannot contact spark plug.
Read these instructions and this manual in its entirety before you attempt to assemble or operate your new lawn mower. IMPORTANT: This lawn mower is shipped WITHOUT OIL OR GASOLINE in the engine. Your new lawn mower has been assembled at the factory with the exception of those parts left unassembled for shipping purposes. All parts such as nuts, washers, bolts, etc., necessary to complete the assembly have been placed in the parts bag.
TO PREPARE BATTERY NOTE: Your battery must be charged before you can start your lawn mower. t. Disconnect engine battery connector (male) from battery connector (female) 2. Connect battery charger connector (male) to battery connector (female). 3. Plug battery charger into 110 volt A.C. outlet. 4. Leave batterychargerconnected for 24 hours beforestarting yourengine forthefirst time. 5. Aftercharging,connect engine connector (male) to battery connector (female).
KNOWYOUR LAWNMOWER READ THIS OWNER'S MANUAL AND SAFETY RULES BEFORE OPERATING YOUR LAWN MOWER. Compare the illustrations with your lawn mower to familiarize yourself with the location of vadous controls and adjustments. Save this manual for future These symbols may appear on your lawn mower or in literature supplied with the product. Learn and understand their meaning.
The operation of any lawn mower can result in foreign objects thrown into the eyes, which can result in severe eye damage. Always wear safety glasses or eye shields while operating your lawn mower or performing any adjustments or repairs. We recommend a wide vision safety mask over spectacles or standard safety glasses. HOWTO ENGINE USEYOUR SPEED LAWN MOWER The engine speed is controlled by a throttle located on the side of the upper handle.
DRIVE CONTROL • Fill fuel tank. Use fresh, clean, regular unleaded gasoline with a minimum of 87 octane. Do not mix oil with gasoline. Purchase fuel in quantities that can be used within 30 days to assure fuel freshness. AWARNING: Experience indicates that alcohol blended fuels (called gasohol or using ethanol or methanol) can attract moisture which leads to separation and formation of acids during storage. Acidic gas can damage the fuel system of an engine while in storage.
• To start engine using the rope starter, follow the steps above. Exchange the use of the start button for starter rope. Do not allow starter rope to snap back. TO STOP ENGINE • To stop engine, move throttle control lever to slow position and release operator presence control bar. NOTE: In cooler weather it may be necessary to repeat priming steps. In warmer weather over priming may cause flooding and engine will not start.
3ERVICE DATES Check for Loose Fasteners Clean/Inspect GrassCatcher (If Equipped) Clean Lawn Mower Clean Under Odve Cover (Power-Prope_ed MOwers ! ;Check ddve ulleys (Power-Pr_oellb_°Mowers) I/ =_ I- K i Ill m i_/ fl/ ChecWShaq0en/Replace Blade _1'3 Lubrication Chart Clean Baitery/Rechar IElectdc Start Mowe_ e 1/ b#' II/ li/4 Check Engine OII Level Change Engine Oil {11_1.
PRODUCT SPECIFICATIONS SERIAL NUMBER DATE OF PURCHASE GASOLINE CAPACITY/TYPE: 1.6 QUARTS UNLEADED OILTYPE (API-SF-SJ): REGULAR OIL CAPACITY: SAE 30 (ABOVE 32°F) SAE 5W-30 (BELOW 32°F) 20 OZS. SPARK PLUG(GAP: .030") BLADE BOLT TORQUE: CHAMPIONR J19LM OR Jf9LM 35-40 FT. LBS. • The model and sedal numbers will be found on a decal attached to the rear of the lawn mower housing.Record both serial number and date of purchase in space provided above.
Blade adapter ENGINE LUBRICATION Use only high quality detergent oil rated with API service classification SF-SJ. Select the oirs SAE viscosity grade according to your expected operating temperature. Key_ Lockwasher_ /O,aO° 1 SAE VISCOSI'Pf \ washer GRASS CATCHER _iling edge GRADES { 1 adapter • The grass catcher may be hosed with water, but must be dry when used. • Check your grass catcher often for damage or deterioration. Through normal use it will wear.
AIR FILTER SPARK PLUG Your engine will not run properly and may be damaged by using a dirty air filter. Replace the air filter every year, more often if you mow in very dusty, dirty conditions. Change your spark plug each year to make your engine start easier and run better. Set spark plug gap at .030 inch. CLEANING TO 1. 2. 3. CLEAN AIR FILTER Loosen screw and tilt cover to remove. Carefully remove cartridge. Clean by gently tapping on a flat surface. If very dirty, replace cartridge.
Catcher frame handle ,/ Push f down TO ADJUST HANDLE The handle can be mounted in a high or low position, The mounting holes in the bottom of lower handle are off center for raising or lowering the handle, 1. Remove upper handle and all parts attached to lower handle. 2. Remove hairpin cotters from lower handle bracket mounting pin. 3. Squeeze lower handle in to remove it from mounting pins. 4. Turn lower handle over to raise or lower handle. 5.
Immediately prepare your lawn mower for storage at the end of the season or if the unit will not be used for 30 days or more. LAWN MOWER FUEL SYSTEM IMPORTANT: It is importantto prevent gum depositsfrom formingin essential fuel systemparts such as carburetor,fuel filter, fuel hose, or tank duringstorage. Also, experience indicatesthat alcohol blended fuels (called gasoholor using ethanol or methanol)can attractmoisture which leads to separationand formation of acids duringstorage.
• Cover your unit with a suitable protective cover that does not retain moisture. Do not use plastic. Plastic cannot breathe which allows condensation to form and will cause your unit to rust. IMPORTANT: Never cover mower while engone and exhaust areas are still warm. CAUTION:Never store the lawn mower with gasoline in the tank inside a building where fumes may reach an open flame or spark• Allow the engine to cool before storing in any enclosure.
TROUBLESHOOTING CHART PROBLEM CAUSE CORRECTION Loss of drive I. Drive wheels not turning with drive control engaged, 2. Belt not driving Adjust or replace drive control cable. 2. Put belt on pulleys or replace belts if broken. Grass catcher _notfilling(ifso iequipped) 1. Cutting height too low. 2. Lift on blade worn off. 3. Catcher not venting air. 1. Raise cutting height. 2, Replace blade. 3. Clean grass catcher, Hard topueh 1. Grass is too high or wheel height is too low. 2.
ROTARY LAWN MOWER - - MODEL NO. 917.377171 BATTERY %%%% KEY NO. 1 2 3 4 5 PART NO, 157553 750909 17411312 86353 _ 111549X DESCRIPTION Battei_ Bracket BatteP/ Hex Washer Head Screw 13 x .
ROTARY LAWNMOWER--MODELNO.917.377171 GEARCASEASSEMBLY PARTNUMBER 702511 17 tS I KEY NO. PART NO, I 2 3 4 6 174gO416 137(_5X004 137053 57072 48373 7 8 9 10 11 77881 137051 137074 57079 131484 KEY NO. DESCRIPTION Tapping Screw 1/4-20 x 1-1/4 Engagement Bmcket Shifter Seal Gear Case Halves Kit (Includes Key Nos. 4, and 7) Bea_ng Worm Shalt Ddve Shaft Hardened Washer Clutch Yoke 12 13 14 15 16 17 18 19 PART NO.
ROTARY LAWN MOWER MODEL NUMBER 917.
ROTARY LAWN MOWER MODEL NUMBER 917.377171 KEY PART NO. NO. 1 2 3 6 7 9 10 11 12 13 14 15 16 17 20 21 22 23 25 27 28 29 30 31 32 34 35 37 39 40 41 44 166860X479 171595 63601 136376 63601 170947 128415 t._ STD5125C6 701650 156374X479 700365X479 176655X479 14_661X479 14(To40 150425 84596 87677 839"23 151158 142748 62335 145935X004 7010_7 _1X004 14_630 _X007 150078 173569X479 ! 73570X479 150406 172833 DESCRIPTION KEY PART NO. NO.
ROTARY LAWN MOWER MODEL NUMBER 917.
ROTARY LAWN MOWER MODEL NUMBER 917.377171 KEY PART NO. NO. =, 2 4 5 6 8 9 1t 12 13 14 15 16 17 18 27 145755 158755 146527 150495 774OO 145212 151156 120O0058 137054 88O8O 88118 67725 14579_ 7010_7 143603 DESCRIPTION Dnve Control Hex Washer Head Screw 1/4-20 x 2-1/8 V-Belt Spnng Retainer HubCap Hex Nut Wheel & Tire Assembly E-F_g Rblon Dust Cover Felt Was_er Washer 1/2 x 1_1F2x ,134 ConUbl Bar Selector Knob Hex Washer Head Screw #10-24 x 3/4 KEY PART NO. NO.
MODEL NO. 12H807 TYPE NO. 2632-B1 BRIGGS & STRATTON 4-CYCLE ENGINE 91 525 i 8 11 •306 1095 VALVE OVERHAUL GASKET SET 1102 _r REQUIRES SPECIAL TOOLS TO INSTALL* SEE REPAIR INSTRUCTION MANUAL.
MODEL NO. 12H807 TYPE NO. 2632-B1 BRIGGS & STRATTON 4-CYCLE ENGINE 959 968 668 )66 423 . 974 j t+ ®,+.j 977 CARBURETOR GASKET 163_137 61_ SET I 53 0 110 121 CARBURETOR 634 _ ,lo_ KIT I 634A ,_ _ i 43 i_ + 6.
MODEL NO. 12H807 TYPE NO. 2632-B1 BRIGGS & STRATTON 4-CYCLE ENGINE 455 3O4 3o5 373_ 58_ -m- 7 -_j © L 1036 LABEL-EMISSIONS 3o9A O J L 44 .
BRIGGS & STRATTON 4-CYCLE ENGINE 5101 MODEL NO. 12H807 TYPE NO.
MODEL NO. 12H807 TYPE NO. 2632-B1 BRIGGS & STRATTON 4-CYCLE ENGINE KEY NO, PART NO.
MODEL NO. 1211807 TYPE NO. 2632-B1 BRIGGS & STRATTON 4-CYCLE ENGINE KEY NO. PART NO.
Get it fixed, at your home or ours! For repair of major brand appliances In your own home... no matter who made it, no matter who sold it! 1-800-4-MY-HOM E s. A,yt_. deyo,,_ght (140o-4694663) www.sears.com To bring in products such as vacuums, lawn equipment and electronics for repair, call for the location of your nearest Sears Parts & Repair Center. 1-800-488-1222 Anytime, day or night www.
