Owner's Manual JCRIIFTSMRN"J ROTARY LAWN MOWER 6.5 Horsepower 21" Rear Discharge Model No. 917.388751 CAUTION: Read and follow all Safety Rules and Instructions before operatingthis equipment Sears, Roebuck and Co., Hoffman Estates, IL 60179 U.S.A. Visit our Craftsman website: www.sears.
Warranty ................................................. 2 Safety Rules ........................................ 2-4 Assembly / Pre-Operation ...................... 5 Operation ............................................. 6-9 Maintenance Schedule ........................ 10 Maintenance .................................... 10-13 LIMITED TWO YEAR WARRANTY Product Specifications .......................... 11 Service and Adjustments ................. 13-14 Storage .........................................
I. GENERAL OPERATION • Read, understand, and follow all • • • • • • • • • • • • • • • instructions on the machine and in the manual(s) before starting. Be thoroughly familiar with the controls and the proper use of the machine before starting. Do not put hands or feet near or under rotating parts. Keep clear of the discharge opening at all times. Only allow responsible individuals, who are familiar with the instructions, to operate the machine.
IV. SERVICE • Never tamper with safety devices. Check their proper operation regularly. • Keep machine free of grass, leaves, or other debris build-up. Clean oil or fuel spillage. Allow machine to cool before storing. • Stop and inspect the equipment if you strike an object. Repair, if necessary, before restarting. • Never attempt to make wheel height adjustments while the engine (motor) is running.
Read these instructions and this manual in its entirety before you attempt to assemble or operate your new lawn mower. Your lawn mower handle can be adjusted for your mowing comfort. Refer to "ADJUST HANDLE" in the Service and Adjustments section of this manual, IMPORTANT: This lawn mower is shipped WITHOUT OIL OR GASOLINE in the engine. Your new lawn mower has been as- Operator I control bar sembled at the factory with the exception of those parts left unassembled for shipping purposes.
TO ASSEMBLE GRASS CATCHER 1. Put grass catcher frame into grass bag with rigid part of bag on the bottom. Make sure the frame handle is outside of the bag top. 2. Slip vinyl bindings over frame. NOTE: If vinyl bindings are too stiff, hold them in warm water for a few minutes. If bag gets wet, let it dry before using. Catcher frame handle Frame opening TO INSTALL ATTACHMENTS Your lawn mower was shipped ready to be used as a mulcher.
KNOWYOUR LAWN MOWER READ THIS OWNER'S MANUALAND ALL SAFETY RULES BEFORE OPERATING YOUR LAWN MOWER. Compare the illustrations with your lawn mower to familiarize yourself with the location of various controls and a_ustments. Save this manual for future reference. These symbols may appear on your lawn mower or in literature product. Learn and understand their meaning. CAUTION OR WARNING ENGINE ON ENGINE OFF FAST SLOW CHOKE FUEL supplied OIL with the DANGER.
TO CONVERT MOWER The operation of any lawn mower can result in foreign objects thrown into the eyes, which can result in severe eye damage. Always wear safety glasses or eye •shields while operating your lawn mower or performing any adjustments or repairs. We recommend a standard safety glasses or wide vision safety mask worn over spectacles. Your lawn mower was shipped ready to be used as a mulcher.
BEFORE STARTING ENGINE Engine ADD OIL oil cap Your lawnmower is shipped without oil in the engine. For type and grade of oil to use, see "ENGINE" in the Maintenance section of this manual. CAUTION: DO NOT overfill engine with oil, or it will smoke on startup. 1. Be sure lawnmower is level and area around oil fill is clean. 2. Remove oil dipstick from oil fill spout. Make sure that rim of spout is clean. 3, You receive a container of oil with the unit.
MOWING TIPS • Under certain conditions, such as very tall grass, it may be necessary to raise the height of cut to reduce pushing effort and to keep from overloading the engine and leaving clumps of grass clippings. It may also be necessary to reduce ground speed and/or run the lawn mower over the area a second time. • For extremely heavy cutting, reduce the width of cut by overlapping previously cut path and mow slowly.
FILL MAINTENANCE IN DATES SCHEDULE ___,r- AsYou =.P E REGULARSERVICE '_/';_"_.
PRODUCT SPECIFICATIONS Serial number: Date of purchase: Gasoline capacity / type: 1.6 Quarts (Unleaded Oil type (API-SF-SJ): SAE 30 (above Oil capacity: 20 Ounces Spark plug (gap: .030") Blade bolt torque: Champion 32°F); Regular) SAE 5W-30 (below 32°F) RJ19LM 35-40 ft. Ibs. The model and serial numbers will be found on a decal on the rear of the mower housing. Record both serial number and date of purchase in space provided above.
GRASS CATCHER drained from engine, you may not need the entire container of a 20 oz. bottle of oil. Slowly pour 3/4 of the oil from the container down the oil fill spout into the engine. 6. Wait one minute to allow oil to settle. Insert and tighten dipstick, then remove it to check oil level. 7. Continue adding small amounts of oil and rechecking the dipstick until it reads full. DO NOT overfill, or engine will smoke on startup. 8. Always be sure to retighten oil dipstick before starting engine. 9.
MUFFLER A('_CAUTION: Disconnect spark plug wire from spark plug and place wire where it cannot come in contact with the spark plug. • Clean the underside of your lawn mower by scraping to remove build-up of grass and trash. • Clean engine often to keep trash from accumulating. A clogged engine runs hotter and shortens engine life. * Keep finished surfaces and wheels free of all gasoline, oil, etc.
ENGINE ENGINE CARBURETOR SPEED Your carburetor is not adjustable. If your engine does not operate properly due to suspected carburetor problems, take your lawn mower to a Sears or other qualified service center for repair and/or adjustment. Your engine speed has been factory set. Do not attempt to increase engine speed or it may result in personal injury. If you believe that engine is running too fast or too slow, take your mower to a Sears or other qualified service center for repair and adjustment.
ENGINE ENGINEOIL FUELSYSTEM Drain oil (with engine warm) and replace with clean engine oil. (See "ENGINE" in the Maintenance section of this manual). IMPORTANT: It is important to prevent gum deposits from forming in essential fuel system parts such as carburetor, fuel filter, fuel hose, or tank during storage. Also, alcohol blended fuels (called gasehol or using ethanol or methanol) can attract moisture which leads to CYLINDER 1. Remove spark plug. 2.
TROUBLESHOOTING to a Sears Service PROBLEM Loss of power - See appropriate section in manuel unless directed Center, CORRECTION CAUSE 1. Rear of lawn mower housing or cutting blade dragging in heavy grass. 2. Cutting too much grass. 3. Dirty air filter. 4. Buildup of grass, leaves, and trash under mower. 5. Too much oil in engine. 6. Walking speed too fast. Poor cut uneven 1. Worn, bent or loose blade. 2. Wheel heights uneven. 3. Buildup of grass, leaves and trash under mower.
Garant_a ........................................................ 18 Reglas de Seguridad ............................... 18-19 Montaje / Operaci6n ...................................... 21 Operaci6n ................................................ 23-26 Mantenimiento ......................................... 27-30 Programa de Mantenimiento ......................... 27 Especificaciones del Producto ..................... 28 Servicio y Adjustes ................................. 30-31 Almacenamiento ..........
I. OPERACION • Antes de empezar, debe familiarizarse completamente con los controles y el use correcto de la maquine. Para esto, debe leer y comprender todas las instrucciones que aparecen en la maquina yen los manuales de operacibn. • No ponga las manes o los pies cerca o debajo de las partes mtatorias, Mantengase siempre lejos de la abertura de la descarga. • Permita que solamente las personas responsables que est6n tamiliadzadas con las instrucciones operen la mf_quina. • Daspeje el _.
• Nunca haga funcionar una m&quina dentro de un &rea cerrada. • Nunca haga ajustes o reparaciones mientras el motor est_ en marcha. Desconecte el cable de la bujia, y mant_ngalo a cierta distancia de _sta para preveoir un arranque accidental. • Mantenga las tuercas y los pemos, especialmente los pemos del accesorio de la cuchilla, apretados y mantenga el equipo en buenas cendiciones. • Nunca manipule de forma indebida los dispositivos de seguridad. Controle regularmente su funcionamiento correcto.
Lea estas instrucciones y este manual completamente antes de tratar de montar u operar su segadora nueva. IMPORTANTE: Este cortacesped viene SIN ACEITE O GASOLINA en el motor. Su segadora nueva ha sido montada en la f&brica con la excepci6n de aquellas partes que se dejaron sin montar pot razones de env{o. Todas las partes como las tuercas, las arandelas, los pernos, etc., que son necesarias para completar el montaje hart sido colocadas en la bolsa de partes.
PARA INSTALAR LOS ACCESORIOS Su segadora fue enviada lista para usarse como una acolchadora de capa vegetal. Para convertida de modo que pueda ensacar, refi6rase a "PARA CONVERIR LA SEGADORA" en la Seccibn de Operaci6n de este manual. PARA MONTAR EL RECOGEDOR DE CESPED 1. Ponga el bastidor del recogedor de c6sped en la bolsa del c_sped con la parte r{gida de Is bolsa en la parte inferior. Aseg_rese que el mango del bastidor est_ en el exterior de la parte supedor de Is bolsa. 2.
FAMIUARICESE CON SU SEGADORA LEA ESTE MANUAL DEL DUENO Y I_AS REGLAS DE SEGURIDAD ANTES DE OPARAR SU SEGADORA. Compare las ilustracionescon su segadora para familiarizarse con la ubicac_n de los diversoscontrolesy ajustes. Guarde este manual para referenciaen el future. Estos sfmbolos pueden apareser sobre su segadora o en la literatura proporcionada el producto. Aprenda y comprenda sus significados.
Laoperaci6nde cualquier segadora puede hacer que salten objetos extraf_os dentro de sus ojos. Io que puede producir daf_os graves en 6stos. Siempre use anteojos de seguridad o protecci6n para los ejos mientras opere su segadora o cuando haga ajustes o reparaciones. Recomendamos gafas o una mascara de seguridad de visi6n amplia de seguridad usada sobre las gafas. COMO USAR SU SEGADORA VELOCIDAD DEL MOTOR La velocidad del motor se estableci6 en la tdbrica para un rendimiento 6primo.
ANTES DE HACER ARRANCAR EL MOTOR AGREGUE ACEITE Su segadora fue enviada sin aceite en el motor. Para el tipo y el grado del aceite a utiltzar, vea el "MOTOR" en la seccibn del Mantenimiento de este manual. ,APRECAUCI6N: NO sobrellene el motor con aceite, o fumar_, cuando Io valla a arrancar. 1. Aseg_rese que la segadora est_ nivelada y que el drea alrededor del dep6sito de aceite est_ limpia. 2. Remueva la varila medidora de aceite del tubo de desarga de aceite.
PARA PARAR EL MOTOR • Para parar el motor, suelte la barra de controles que exigen la presencia del operador. AVISO: En climas m._s frios puede que sea necesafio repetir los pasos del cebado. En climas m_s calurosos el cebar demasiado puede producir el ahogo y el motor no va a arrancar. Si se ahoga el motor espere unos cuantos minutos antes de tratar de hacerlo arrancar y no repita los pasos del cebado.
PROGRAMA DE MANTENIMIENTOL"', /.JJ JJ QUE COMPLsuEsERvlclo REQU R c.As ffy yfj I_l_r S 81hsysujetadoms sueltos o.
ESPECIFICACIONES DEL PRODUCTO NOmero de serie: Fecha de compra: Capacidad y tipo de gasolina: 1.6 cuartos (regular sin plomo) Tipo de aceite (API-SF-SJ): SAE 30 (sobre 32°F);SAE Capacidad 20 onzas de aceite: Bujia (abertura: ,030") Torsi6n del pemo de la cuchilla: Champion 5W-30 (debajo 32°F) RJ19LM 35-40 FT. LBS. El n0mero del nodelo y el de serie se encuentran en la calcomania adjunta a la parte trasera de la caja de la segadora.
RECOGEDOR DE CleSPED (Si comprado como un accesorio) • El recogedor de c_ped puede ser rosiado con el agua de la manguera pero tiene que estar seco cuando se vaya a usar. • Revise su recogedor de c_ped a menudo para vedficar si estd daSado o detedorado. Se va a desgastar con el use normal. Si se necesita cambiar el recogeder, c_mbielo solamente por uno que sea aprobado por el fabdcante. D_ el n_tmerodel modelo de la segadora cuando Io ordene.
SILENCIADOR Inspeccione y cambie el silenciador si est,_ corro_dopuede producir un peligro de incendio y/o dafio, BUJ[A Cambie el buifa al comienzo de cada temperada de siega o despu_s de cada 100 horas de operaci6n, Io que suceda primero. El tipo de bujia y el ajuste de la abertura aparecen en =ESPECIFICACIONES DEL PRODUCTO" secci6n de este manual. LIMPIEZA IMPORTANTE: Para obtener el mejor rendimineto, mantenga la caja de la segadora sin acumulacion de cesped y basura.
CARBURADOR Su carburador tiene un chorro principal fijo no ajustable para controlar la mezcla. Si su motor no est& funcionando en lorma adecuada debido a problemas que se sospecha vienen del carburador, Ileve su segadora a contacto con su centro de servicio Sears o con un otro centro de servicio cualificado para repararla y/ o ajustarla. IMPORTANTE: Nunca manipule el regulador del motor, el que ha sido ajustado en la f_.brica para la velocidad del motor adecuada.
combustible, la mangura del combustible o an el estanque durante el almacenamiento. Los combustibles mezclados con alcohol (conocido come gasohol o que tienen etanol o metanol) Pueden atraer humedad. Io que conduce a la separacion y a la formacibn de acidos durante el almacenamiento. La gasolina acida puede danar el sistema de combustible de un motor durante el perido de almacenamiento. 1. 2. Drene el estanque de combustible.
SOLUCION DE PROBLEMAS - Vea la seccl6n apropiada en el manual amenos que estd dirigido a un centro de servico Sears. CORRECCION PROBLEMA CAUSA Falta de fuerza CuchiUa desgastada, doblada o suelta. Altura de las ruedas dispareja. 2. 3. Velocidad del motor lenta. 4. Acumulaci6n de cdsped, hojas o basura debajo de la segadora. 5. Demasiado aceite en motor. 6. Velocidad de recorrido demasiado rdpida. Mal cortedisparejo 1. Cuchilla desgastada, doblada o suelta. 2. Altura de las ruedas dispareja. .
CRAFTSMAN ROTARY LAWN MOWER -- MODEL NUMBER 2 917.
CRAFTSMAN KEY NO, 1 2 3 4 5 6 7 8 11 12 13 14 15 17 18 19 20 21 22 23 24 25 26 27 29 30 33 34 35 36 37 38 39 40 41 PART NO. 182811 181222X479 161195X479 179585 132OO4 131959 66426 74780512 175148 750634 850733X004 181202 51793 165946X479 17600406 167132X004 167133X004 165858 168360X004 166875 751153 166236X479 166243x479 851856 160835X007 19112206 181197 1804(_X004 166785 16_]28 15O339 164362 83923 180635 88652 ROTARY LAWN MOWER-- MODEL NUMBER 917.
BRIGGS & STRATTON 4oCYCLE ENGINE MODEL NUMBER 123K02-0181-E1 684 _' 11019 LABEL KIT I 51 868 40 _ 4_ 4_ 36 24 33 270 332 455 43 15_ 36
BRIGGS & STRATTON 4-CYCLE ENGINE MODEL NUMBER 123K02-0181-E1 969 | 188 921 304 305 443 _ln 159!_ 29q_;:) 9;'o _, C 968 445 '1 I' 977 CARBURETOR GASKET SET 163_137 % 183_ 0 365 633 ) 137 1_CARBURetOR OVERRAU" K,_ 276_ 127_ 633_ I _ 276 _ 163 ,_. 61;, J' _.
BRIGGS & STRATTON 4-CYCLE ENGINE MODEL NUMBER 123K02-0181-E1 358 ENGINE GASKET SET 621_ 1036 601 KEY NO. PART NO. 1 2 3 4 5 7 8 9 10 11 697322 399269 299819 493279 691160 692249 695250 696125 691125 691781 EMISSIONS LABEL DESCRIPTION Cylinder Assembly Kit, Bushing/Seal • Seal, Oil, Magneto Side Sump, Engine Head, Cylinder • Gasket, Cylinder Head Breether Assembly Gasket, Breather Screw, Breather Assembly Tube, Breather KBY PART NO. NO.
BRIGGS NO. 26 27 28 29 32 32.A 33 34 35 36 37 40 43 46 46 48 50 51 54 58 58 60 65 78 81 95 97 104 117 118 121 125 127 130 133 134 137 146 159 163 187 188 190 202 209 222 227 276 287 300 304 305 306 307 332 333 334 337 356 358 363 365 383 404 & STRATTON PART NO. 499425 499426 499427 499428 691866 499423 499424 691664 695759 262651 262652 691270 691270 694086 692194 691997 690548 691449 498826 4-CYCLE ENGINE DESCRIPTION Ring Set, Piston, Standard Ring Set, Piston, .010" Oversize Ring Bet, Piston, .
'%!iiiiiijililiiiiiiiii Your Home For repair - in your home - of all major brand appliances, lawn and garden equipment, or heating and cooling systems, no matter who made it, no matter who sold it! For the replacement parts, accessories and owner's manuals that you need to do-it-yourself. E® (1÷800-469-4663) www,sears.com ::::::::: ,::,::::::: E,E'E_E For Sears professional installation of home appliances and items like garage door openers and water heaters.